Technical Service Bulletins

2008-09-29: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement (02-07-30-029L)
2008-09-29: Eliminating Unwanted Odors in Vehicles (00-00-89-027E)
2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-26: Fluid Leak from Transmission Oil Cooler Lines due to Corrosion - keywords leak line loose rust tight (PIT4722)
2008-09-23: Special Coverage Adjustment - Analog OnStar Deactivation (08089B)
2008-09-16: Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017A)
2008-09-05: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses (02-08-42-001C)
2008-08-28: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) (08-08-44-028)
2008-08-27: New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-00-89-014E)
2008-08-26: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs) (08-08-44-015A)
2008-08-25: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006E)
2008-08-22: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process (For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB, Audio, Display, Map, Noise) (08-08-44-010B)
2008-08-14: Fuel Gauge Fluctuation In Park Or Neutral - keywords gage inaccurate intermittent ip ipc (PIT3046E)
2008-08-11: Informaiton on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
2008-08-08: Information on Water or Ethylene Glycol in Transmission Oil (08-07-30-035)
2008-08-06: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022E)
2008-08-05: Question Regarding Installation Of Dealer Installed Accessories (PIT3099E)
2008-08-01: SWC Operation After OnStar ADT Upgrade - keywords call calling control inoperative steering wheel (PIC4820A)
2008-07-25: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 (05-03-08-002B)
2008-07-23: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information led no operation red (PIC3597F)
2008-07-23: OnStar Power Consumption - keywords battery digital discharge drain draw parasitic VCIM (PIC4935)
2008-07-21: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output (02-06-03-008D)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-27: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) (07-00-89-047B)
2008-06-27: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009B)
2008-06-24: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047H)
2008-06-24: GM Goodwrench Limited Lifetime Service Guarantee (03-00-89-003A)
2008-06-23: Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011)
2008-06-20: Information on Use of Customer Concern Verification Sheets, Comeback Prevention, GM Technical Assistance Information Form (TAC), Strategy Based Diagnostics (SBD), Intermittent Concerns, Diagnostics (01-00-89-010H)
2008-06-18: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement (08-08-44-023)
2008-06-18: OnStar Voice Recognition Operation Issues - keywords information intermittent microphone performance voice (PIC3011E)
2008-06-18: Unable To Connect To OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication droppedcall failedtovoice information intermittent OPC operation no noconnect performance region (PIC4310C)
2008-06-17: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy (05-00-89-072B)
2008-06-16: Questions Regarding Installation Of Dealer Installed Accessories (PIT3099D)
2008-06-11: Unwanted Repeated Calls to OnStar / Replace VCIM - keywords call letter mail phantomcall phone repeat (PIC4893)
2008-06-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
2008-06-06: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002E)
2008-06-05: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors (07-08-64-022A)
2008-06-04: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
2008-05-30: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. Only) (07-03-10-016A)
2008-05-30: Intermittent, Current or History DTC B2476 in Onstar GEN 6 or 7 VCIM - keywords blue button call communication data digital information keypad led OPC operation red (PIC4574B)
2008-05-29: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory (08-06-03-005)
2008-05-16: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
2008-05-12: Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
2008-05-12: Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036G)
2008-05-12: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
2008-05-08: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036E)
2008-05-07: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Intrument Panel Clusters (IPC) (08-08-44-015)
2008-05-06: Disc Brake Warranty Service and Procedures (00-05-22-002K)
2008-05-05: Engagement Time of Electronically Controlled Transmissions in General Motors Vehicles (Garage Shifts, Park to Reverse, Neutral to Drive, Neutral to Reverse, Park to Drive, Delayed Engagement) (03-07-30-007E)
2008-05-02: Manual Transmission Operating Characteristics (03-07-29-004E)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005)
2008-05-01: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) (08-03-10-006)
2008-05-01: Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
2008-04-30: ACDelco Replacement Battery Warranty Procedures (03-06-03-003B)
2008-04-29: Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
2008-04-18: Information for Dealers on How to Submit a Field Product Report (02-00-89-002G)
2008-04-17: Electronic Exchange Program Goodwill Procedures (05-00-89-045A)
2008-04-17: Key Code Information (99-00-89-011C)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-16: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines (05-08-44-024A)
2008-04-14: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information LED no operation red (PIC3597E)
2008-04-14: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts (00-06-01-012C)
2008-04-10: Midtronics Code Generated by J 42000 or J 42000EU Battery Tester Required for Claim Processing On Labor Operation N0110 (03-06-03-004C)
2008-04-10: Handsfree Calling Inop With Demo Message On OnStar Keypress - keywords 05-08-46-006N blue button communication digital disabled message no OPC operation vs3bgen6 vs3bgen7 (PIC4564A)
2008-04-07: Interior Lights Inoperative After BCM Replacement B2618 DTC - keywords calibration control courtesy dome inop lamp light module program (PIT4619)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-01: Warranty Claims Submission - Importance of GM Part Numbers and Parts with Date Codes (06-00-89-054B)
2008-03-31: Escalation Process for Critical Orders for Electronic Service Center (ESC) Parts (06-00-89-032A)
2008-03-27: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-25: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories (08-03-10-004)
2008-03-19: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication failedtovoice information intermittent OPC operation no noconnect performance (PIC4310B)
2008-03-19: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001G)
2008-03-14: SWC Operation After OnStar ADT Upgrade - keywords call calling control inoperative operation onstar steering wheel (PIC4820)
2008-03-12: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation (08-08-51-002)
2008-03-11: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006D)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-25: General Motors Position Statement on Installation of Used, Salvaged or Imitation Air Bag System Components (08-09-41-003)
2008-02-22: Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow (02-07-30-052E)
2008-02-20: Rules Of Thumb American Axle Manufacturing General Information - keywords bearing howl noise pinion ring whine (PIP3720A)
2008-02-19: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001F)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-06: GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078B)
2008-02-05: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
2008-02-05: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience (04-06-01-029B)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-02-04: Driveline Characteristics for All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
2008-02-01: Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
2008-02-01: Distortion in Outer Surface of Vehicle Glass (00-08-48-005C)
2008-02-01: Information on Eliminating Noise in Audio System When Using Portable Playback Device (06-08-44-015A)
2008-01-31: 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
2008-01-31: Vibration Analysis Worksheet (03-00-91-001D)
2008-01-30: Remote Keyless Entry Operational Characteristics (99-08-52-005C)
2008-01-25: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006B)
2008-01-25: Information on New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
2008-01-23: 18 Digit Snapshot/Charge Summary Code No Longer Required for A/C Refrigerant System repairs Submitted for Warranty Reimbursement (05-01-38-008B)
2008-01-18: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
2008-01-18: Warranty Administration - Repair Order (RO) Documentation (00-00-89-015B)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-17: Engineering Information (EI) Process (04-00-89-053B)
2008-01-17: Re-establishing Communications with OnStar Center After Battery Disconnect (00-08-46-004C)
2008-01-17: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007D)
2008-01-15: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003C)
2008-01-15: GM Technical Assistance Information Form (TAC) and Service Strategy Process Utilizing Customer Service Comeback Prevention, Strategy Based Diagnostics (SBD) and Intermittent Concern Diagnosis (01-00-89-011g)
2008-01-09: Availability of GM OnStar Vehicle Diagnostics and GM Goodwrench Remote Diagnostic Services (06-08-46-002B)
2008-01-09: Seat Belt Extender Availability (99-09-40-005E)
2008-01-09: Information on Tire Radial Force Variation (RFV) (00-03-10-006C)
2008-01-09: OnStar Labor Operation Codes (05-08-46-005B)
2008-01-08: OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System (05-08-46-004B)
2008-01-08: Incorrect OnStar Global Positioning System (GPS) Location Reported During OnStar Call (02-08-46-006C)
2008-01-07: Tire Puncture Repair Procedures for All Cars and Light Duty Trucks (04-03-10-001D)
2008-01-04: Information on The Use of Bonded Valve Body Spacer Plate and Gaskets - keywords part shift (PIP4309)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2007-12-17: Warranty Parts Center/Corporate Parts Return Program (99-00-89-019E)
2007-12-13: 4WD Models With Noise Vibration On Dry Pavement - keywords grind growl moan rattle (PIP3300B)
2007-12-10: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT - CH-47976) (03-06-04-030F)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-21: Release of DEXRON-VI Automatic Transmission Fluid (ATF) (04-07-30-037D)
2007-11-19: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007C)
2007-11-12: Customer Concern Not Duplicated/Verified Labor Operations (06-00-89-026A)
2007-11-09: Underbody Corrosion - keywords appearance body frame rust (PIT3749B)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Corrosion Protection for Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008D)
2007-10-29: Revised General Motors New Vehicle Tire Warranty Program (00-03-10-003M)
2007-10-23: Information on Proper Tire Pressure (00-00-90-002I)
2007-10-05: Guidelines When Changing Tire Size - keywords calibration program rim wheel (PIT3271D)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-09-28: Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
2007-09-21: Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires (03-03-10-007C)
2007-09-17: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016A)
2007-09-12: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006B)
2007-09-05: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
2007-08-23: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors (07-00-89-043)
2007-08-16: Warranty Admin. - Courtesy Transportation and Roadside Assistance Programs (07-00-89-037)
2007-08-14: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016)
2007-08-06: Guidelines for Usage of Transmission K Labor Operation Recondition Add Time (07-07-30-020)
2007-08-02: Warranty Admin. - GM Dealer Empowerment Program and Goodwill Procedures (05-00-89-055B)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-07-26: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022D)
2007-07-23: Warranty Administration - Required Operating Procedures (04-00-89-015A)
2007-07-19: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) (06-08-50-009B)
2007-07-19: Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
2007-06-27: ABS Light On DTC C0055 C0235 C0236 Or C0237 Stored In The EBCM - keywords brake lamp light sensor speedometer VSS (PIT3521E)
2007-06-27: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 (07-01-38-004)
2007-06-27: GM Training:May 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-028)
2007-06-26: GM Training:Number of Technicians Required Reduced for Two Categories (U.S. Dealers) (07-00-89-016)
2007-06-26: GM Training:Three Technology Close-Up IDL Seminars as New 2007 Service Training Standard (STS) Requirements (U.S. Dealers) (07-00-89-014)
2007-06-26: GM Training:March 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-013)
2007-06-26: GM Training:Course Information (For U.S. Dealers and Aftermarket) (07-00-89-011)
2007-06-26: GM Training:January 2007 GM Service Know-How Emerging Issues Seminar (#10207.01D) (For U.S. Dealers Only) (07-00-89-007)
2007-06-26: GM Training:Maintaining GM STC Master Technician Certification (MTC) (For U.S. Dealers Only) (07-00-89-005)
2007-06-26: GM Training:HVAC Systems and Operation Stage 2 WBT and IDL (11044.03) (For U.S. Dealers Only) (07-01-38-001)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-22: Use of Silicone for Weatherstrip Maintenance (99-08-64-016B)
2007-06-21: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage (00-06-01-026B)
2007-06-21: 1998-2007 Cars And Light Duty Trucks TCC Operation - keywords shudder slip surge speed (PIP4001A)
2007-06-15: Repeat HVAC Actuator Replacements - keywords door cool heat mode temperature (PIT4427)
2007-06-14: Communication Strategy of Service Information/Strategy Based Diagnostics (05-00-89-067B)
2007-06-12: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT - CH-47976) (03-06-04-030E)
2007-06-08: Windshield Wiper Performance, Cleaning Instructions and Maintenance (06-08-43-003A)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-24: Corrosion Protection for Metal Panels with Dealer Installed Accessories Fastened by Drilled Holes (03-00-89-008C)
2007-05-21: Information on 2-3 Upshift or 3-2 Downshift Clunk Noise (01-07-30-042E)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-17: Improved Oil Fluid Wear Pump Clip - keywords 136 149 246 246EAU 261 263 263EAU housing leak case transfer transfercase (PIP4118)
2007-04-17: Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-12: Tailgate Cable Slack - keywords body endgate gate loose tail (PIT3227D)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-04-02: Info - Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair (07-08-98-001)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-13: Information on OnStar System - Possible Loss of GPS and/or Unable to Replenish Hands-Free Calling Minutes (02-08-46-007B)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-20: Information on Diesel Fuel Additives (03-06-04-017D)
2007-02-15: Info - New Bulletin Category: Technical Training (U.S. Only) (07-00-89-003)
2007-02-09: Info - Availability of Transmission Shield to Protect Shift Cable/Manual Shaft Area from Snow and Ice Build-Up on Allison Automatic Transmissions (04-07-30-018B)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2007-01-03: Information on Low Fuel Lubricity and Fuel System Metal Contamination (99-06-04-047C)
2006-12-13: Information on OnStar Analog-Only Systems (06-08-46-007)
2006-12-07: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001E)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-28: LN2, L43 or L35 Engine SES/MIL Light Illuminated, AIR Pump Ingesting Water and DTC P0410 Set (Replace AIR Pump and Inlet Hose Assembly) (04-06-04-015A)
2006-11-27: No Start With DTC P1626 Or P1631 - keywords crank deterrent no nostart stall theft theftdeterrent (PIT4001A)
2006-11-09: Crank No Start When Cold Due To Compression Loss - keywords cylinder cylinderhead extended hard head lifter loss (PIP3146B)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-24: Warranty Admin. - Revised Mass Air Flow Core Return Requirements (06-06-04-057)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-10: Info - Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-28: Service VME - Additional Information About Passenger Presence Systems (PPS) - keywords bladder information passenger PPS presence restraint seat sensor SIR system weight (PIT4138)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-22: Info - Pitting and Brake Dust on Chrome Wheels (04-03-10-012A)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Information on Engine Misfire MIL/SES Light Illuminated or Flashing DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, P0420 or P0430 (06-06-04-046)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-12: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
2006-09-11: Special Policy Adjustment - Tailgate Support Cable Replacement (06020A)
2006-09-08: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (06-08-111-004)
2006-09-08: Electronic Transfer Case Unable To Complete Shift - keywords code DTCs hot inoperative (PIP3424A)
2006-09-07: Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010)
2006-08-31: Clunk Noise Felt Through Floor Pan - keywords bar bump frame front mount torsion turn suspension (PIT4114)
2006-08-30: Rattle Noise In Engine (Install Timing Tensioner Kit) (03-06-01-024C)
2006-08-30: Engine/Balance Shaft Rattle Noise (00-06-01-023C)
2006-08-24: Grind/Ratchet Noise Occurs When Shifting Into Park While in 4 Wheel Drive Low - keywords case shift transmission transfer (PIP3366A)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-17: 4T65E Whine Noise Park/Neutral - keywords bearing drive sprocket support (PIP3894)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-14: Loss of Power Hesitates on Acceleration - keywords 2.8 3.5 4.2 4.3 4.8 4L60E 4L65E 5.3 5.7 6.0 accelerate cold L35LK5 LL8 LM7 loss LQ4 LQ9 LS1 LS6 LU3 M30 M32 miss misfire neutral no performance power (PIP3796A)
2006-08-11: TCC Engagement in 1st, 2nd or Reverse - keywords chuggle shudder (PIP3885)
2006-08-11: 4L60E/4L65E/4L70E Snap Noise 2-1 Downshift - keywords clunk (PIP3106B)
2006-08-11: Info on Utra Low Sulfur Diesel Fuel and Warning Labels on Fuel Station Pumps -This Info Applies to Diesel Engines w/RPOs LBZ, LB7, LH6, LLY, LMM, LL4, LQM, LQN, L49, L56, L57, L65, LG4, 1C3, 1C2, 1L5 (06-06-04-041)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-04: Light and Medium Duty Truck Warranty and Crossline Warranty Eligibility and Guidelines for Chevrolet and GMC Dealers (02-00-89-007A)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-28: Info - Recreational (Dinghy) Towing (00-00-89-008F)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-08: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002D)
2006-05-30: GM Product Recall Campaign Follow Up Post Card (06-00-89-019A)
2006-05-25: Fuel Gauge Fluctuation in Park or Neutral - keywords gage inaccurate intermittent IP IPC (PIT3046D)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-17: Info - Instructions to be Followed to Aid in Obtaining Root cause Analysis on Both OEM and Goodwrench Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
2006-05-17: Info - Updated Transfer Case Connector Service Kit Now Available for Transfer Case Speed Sensor Wire Harness Connector that Comes Loose or Connector Retainer Clip Breaks (06-04-21-001)
2006-05-02: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Intermittent Neutral from a Stop or 2-3 Shift - keywords 4L60E 4L65E flare launch slip (PIP3002D)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-11: Info - Cellular Error Messages Received when Trying to Connect to OnStar (02-08-46-004A)
2006-04-06: Discontinuation of the Field Product Reminder Bulletin/Bulletin Subscription Information (06-00-89-018)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-29: Info - Vibration Analysis Worksheet (03-00-91-001C)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-16: Front Axle Grind Whine Noise in 2WD, Gone in 4WD - keywords 231 233E 236 axle bearing case differential front gear HI2 HI4 loud moan pinion rough transfer vibration (PIP3183A)
2006-03-07: Intermittent No Crank, No Start (Clean Battery Side Terminal Stripped Threads, Replace Battery Cable Bolt) (02-06-04-015A)
2006-03-02: Warranty Admin. - Labor Operation Assignments for All Control Module Reprogramming (02-06-04-057E)
2006-03-01: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
2006-02-24: Service VME - Underbody Corrosion - keywords appearance body frame rust (PIT3749A)
2006-02-24: Questions Regarding Installation of Dealer Installed Accessories - keywords 2.8 3.5 4.2 4.8 5.3 6.0 8.1 accessory part Partech (PIT3099C)
2006-02-17: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance (06-08-45-001)
2006-02-14: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004b)
2006-02-14: Info - Diagnostic Tips For Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036F)
2006-02-09: Diagnostic Information for Front Wheel Drive Transaxle/Transmission Final Drive and/or Front Hub Bearing Hum and/or Grind Noise (06-07-30-006)
2006-02-07: Info - Unable to Connect to OnStar or OnStar Personal Calling Inoperative (04-08-46-003B)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-24: Info - Expediting Warranty Parts (99-00-89-021E)
2006-01-19: 4WD Models with Noise, Vibration on Dry Pavement - keywords 04-04-18-001D 226 233E 236 241 243E 246 246EAU axle bearing bind case chatter chuggle decelerate differential front grab high HI4 (PIP3300A)
2006-01-18: Info - New Product Feedback Form and Process for Automatic Transmission Core Returns (01-07-30-029A)
2006-01-12: 4T65-E Automatic Transmission Fluid Leak from Reverse Servo Cover (Replace Reverse Servo Cover Seal) (04-07-30-028A)
2006-01-11: IPC, Interior Lights and/or Headlamps Flicker - keywords battery courtesy electrical fluctuation generator head intermittent lamp light (PIT3170E)
2006-01-05: Antilock Brake (ABS) Activation at Low Speeds (Clean Wheel Speed Sensor Mounting Surface) (02-05-25-006B)
2006-01-04: Info - Maintenance Cleaning of Fuel Injectors (04-06-04-051B)
2005-12-22: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
2005-12-12: Hood Hinge Rattle (Install Spring Washer) (01-08-63-001B)
2005-12-07: SMU - Revised Front Drive Axle Carrier Lubricant Information (05-00-90-010)
2005-11-21: Info - Paint-less Dent Repair Process (99-08-51-001A)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-11-04: Light Duty Truck, Van, Utility Rear Axle Lubrication Service Interval - keywords differential fluid housing label oil (PIP3001A)
2005-10-20: Trip Odometer Resets While Cranking or Ignition Cycle - keywords cluster IPC instrument (PIT3399A)
2005-10-18: 4L60-E/4l65-E Automatic Transmission Diagnostic Information on Harsh 1-2 Upshift (01-07-30-030B)
2005-10-06: Info - Transmission Fluid Leak Diagnosis (01-07-30-041B)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-08-18: Info - Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
2005-08-17: Info - Release of GM Tool Organizaiton DVD Version 8.0 (J-43921-G) (05-00-89-056)
2005-08-10: Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inop I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
2005-08-05: Info - SPAC Case Escalation Process (05-00-89-050)
2005-08-02: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case (05-04-21-004)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-27: Warranty Admin. - Out-Of-Warranty Parts for Engineering Analysis (05-00-89-037)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-08: Info - On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
2005-06-03: Goodwrench Powertrain Wholesale Program (U.S. Only) (05-06-01-017)
2005-05-26: Repeat SIR Light on with a Current DTC B1000 - keywords air bad code lamp SDM (PIT3467A)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-05: Power Door Locks, Power Mirrors and Rear Hatch Inoperative - keywords door fuse hatch inoperative lock mirror power rear (PIT3410A)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-12: Info - Top Tether Hardware Package for Child Restraint Seats (99-09-40-004a)
2005-04-12: Info - OnStar System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
2005-04-12: Shudder on Turns - keywords 136 236 246 4WD automatic AWD bind case contaminated NP4 NP8 vibration (PIP3012D)
2005-03-21: 2001-2003 Chevrolet Blazer, S-10, GMC Envoy, Jimmy, Sonoma with 233E Transfer Case: Supplement to 03-01-38-009 Oil in HVAC Vacuum Lines - keywords 4WD AC case contamination control head mode NP1 (PIT3153A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-17: Info - GM Parts Ordering System (05-00-89-018)
2005-03-10: Info - Guidelines for Replacement of Transfer Case Control Module (TCCM) (05-04-21-002)
2005-03-08: Info - Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
2005-03-08: Information on Excessive Use of RTV Silicone Sealant on New Venture Gear (NVG) and Borg Warner Transfer Cases During Service (05-04-21-001)
2005-03-07: Info - Required Reconfiguration on OnStar Modules After Replacement (01-08-46-001A)
2005-02-11: 96-04 Chevrolet and GMC Classic S/T 2 Door Utility and Ext-cab P/U Quarter Glass Seal Torn - kw door molding side seal tear weatherstrip (PIT3439)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-09: Info - Proper Air Bag System Diagnosis and Service (03-09-41-003A)
2005-01-31: Warranty Admin. - Guidelines for Claiming C0034 - Windshield Replacement (05-08-48-001)
2005-01-31: 4L60E, 4L65E Replacement Valve Body Gaskets Does Not Seem to Fit - kw chatter clutch repair second shift shudder slip (PI00773)
2005-01-28: Poor Engine Performance-Misfire, Rough Idle, Stalls, Engine Cranks but Does Not Run, SES/Check Engine Light On, DTC P0300 Set (Inspect Distributor Ignition(DI) System Components, Replace as Necessary) (03-06-04-041A)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-14: Info - OnStar Proactive Parts Shipment Process (02-08-46-013A)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2005-01-06: 1998 - 2004 Chevrolet and GMC S/T Classic Front Suspension Leans Left - kw low GMT325 lean (PIT3355)
2005-01-05: Cranks But No Start, Stall, Inaccurate/Incorrect Fuel Gauge Reading, No Fuel, Vehicle is Out of Fuel and Fuel Gauge Reads Above Empty (Replace Fuel Level Sensor) (04-08-49-018E)
2004-12-13: Info - Battery Specification Label (04-06-03-016)
2004-12-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022C)
2004-12-02: 96-04 Classic S/T Pickup and Utility Rust in Cooling System, Heater Inoperative, Blows Cold Air, Engine Overheats - kw 4.3 99-06-02-012d contaminated contamination coolant GMT325 GMT330 heat L35 LF6 (PIT3295)
2004-11-18: Info - Shipping Enhancements for Owners Manuals and Service Manuals Ordered from Helm, Inc. (04-00-89-057)
2004-11-18: Warranty Admin. - Warranty Return Parts (04-00-89-051)
2004-11-10: Warranty Admin. - New Alignment Procedure for Labor Operation Numbers E2020 and E2000 (04-03-07-002A)
2004-10-21: 95-03 Chevrolet S10 ZR2 Highrider and GMC Sonoma ZR2 Highrider Paint Code Unknown for RPO: ZR2 Front Bumper and Wheel Flare - kw body cover fender GMT325 GMT330 (PIT3232)
2004-10-20: Info - Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
2004-10-12: 99-05 Chevrolet/GMC All Full and Mid Size Trucks and Utilities, 99-01 Oldsmobile Bravada, 02-05 Cadillac Full Size Utilities and 03-05 Hummer H2 IPC Gauges Float Up After Ignition Key Turned Off (PIT3215)
2004-10-11: Info - Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002A)
2004-09-23: 96-04 Chev/GMC S/T Classic, 96-01 Oldsmobile S/T Classic: Heat Coming from Vents with HVAC Off- kw air hot leak temperature GMT325 GMT330 (PIT3176A)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-14: SMU - Revised Rear Rotor Minimum Allowable Thickness After Refinish Specification (04-05-23-008)
2004-09-14: Info - Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (01-01-38-006D)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-09-03: Diagnostic Information on Rear Axle Vent Hose to Avoid Moisture/Water Intrusion (04-04-20-003)
2004-09-01: 98-05 All General Motors Light Duty Trucks and Hummer H2 Bridgestone Dueler A/T Tires Size LT285/75R16 Load Range D (PIT3146)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-03: Warranty Admin. - Dealer Installed Regular Production Options (RPO) and Regular Production Accessories (RPA) (01-00-89-015A)
2004-08-02: Info - Repair Procedure for Service Sheet Metal, Craters in ELPO Surface (04-08-98-002)
2004-07-27: Warranty Admin. - Changes to General Motors Vehicle Inquiry System (GMVIS) (04-00-89-029)
2004-07-23: Info - Application of Anti-Corrosion Materials (01-08-51-003A)
2004-07-23: SES Light and P0300 When Towing , Cruising Uphill or on Hard Acceleration - kw 4.3 5.0 5.7 accelerate cruise cylinderhead DTC L30 L31 L35 LF6 LU3 P0300 P0301 P0302 P0303 P0304 P0305 P0306 P0307 P0308 (PIP3081)
2004-07-02: Info - Battery Parasitic Drain (02-06-03-010A)
2004-06-29: Driver Information Center ( DIC ) Stays in Bulb Check -kw compass gauge temperature GMT325 GMT330 (PIT3031A)
2004-06-22: Info - J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
2004-06-22: Info - New Owner Orientation Clinic Materials Now Available Online (03-00-89-002A)
2004-05-26: Info - Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
2004-05-10: No Start with DTC P1626 or P1631 - kw 2.8 3.5 4.2 4.8 5.3 6.0 8.1 crank fuel information stall theftdeterrent theft (PI02068)
2004-04-29: Information on Serpentine Belt Wear (04-06-01-013)
2004-04-22: Red OnStar LED , No Keypad Response When Pushed DTC B2476 - kw inoperative UE1 (PI02018)
2004-04-13: Adm Msg - Alignment Questionnaire (VSS20040092)
2004-03-29: Warranty Administration - Part and Accessory Replacement Policy (04-00-89-011)
2004-03-23: Adm Msg - Wheel Alignment Questionnaire (Fax Number Change) (VSS20040057-01)
2004-03-23: Adm Msg-Warranty Admin Bulletin 00-05-22-002C for Brake Warranty, Service and Procedures-Required Measurement Documentation (VSS20040074)
2004-02-25: Info - 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L80-E or Allison Transmissions (01-07-30-031A)
2004-02-20: 4.3L L35 Engine Wide Open Throttle DTC P0335 P0336 P0339 - kw crank crankshaft DTC data LU3 miss misfire sensor speed stall tachometer (PI00700B)
2004-02-20: 4L60E , 4L65E No 2nd , No 4th and No Reverse - automatic fourth second shift transmission (PI00822C)
2004-02-11: Info - 4L65-E, 4L60-E, 4L60 and 200-4R Automatic Transmission Oil Pump Spring First and Second Design Identification (04-07-30-006)
2004-02-10: 4.3 L35 LU3 Rattle or Buzz Noise from Engine - kw cable IPC PCV throttle valve (PI01727)
2004-02-05: Warranty Admin. - Dealer Disclosure Requirements (02-00-89-005A)
2004-02-05: Diagnostic Information for Intermittent Vehicle No Crank/Dead Battery (04-06-03-002)
2004-01-06: Info - HVAC Control Knob Replacement (04-01-37-001)
2003-12-23: 4L60E, 4L65E Forward and Low Reverse Waved Steel Clutch Plate Appearance Change - kw appearance chatter first fourth PQC second shift shudder slip third transmission valve (PI01599)
2003-12-22: 4.3 L35 , LU3 5.0 L30 , 5.7 L31 Engine Coolant Leak at Intake Gasket - kw consumption smoke white (PI01225A)
2003-11-11: Info - Search Tips for Locating Preliminary Information (PI) Documents in Service Information (03-00-89-039)
2003-11-05: Special Policy Adjustment-Sequential Central Port Fuel Injection (SCPI) Failures in California Only (YF5 Emission Equipped) (99066G)
2003-11-05: Info - 4L60-E Automatic Transmission Oil Pump First and Second Design Identification (03-07-30-056)
2003-10-29: Diagnostic Information to Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
2003-09-19: Warranty Admin. - Sublet Administrative Allowance (Coverage: S) Labor Operations (03-00-89-027)
2003-09-15: Vibration at Highway Speeds - suspension wheel (PI01273B)
2003-07-14: Info - J 44551 A/C Suction Screen Kit Repair Recommendations and Procedures After Catastrophic Compressor Failures (01-01-39-003A)
2003-07-14: Info - HomeLink Transceiver/Garage Door Opener Transmitter Test Kit Available As Essential Tool (01-08-97-001B)
2003-06-25: HVAC Mode Switch Inoperative or Stuck in Vent Mode, Oil in HVAC Control Head and/or Vacuum Lines (Replace Transfer Case Vacuum Switch and Contaminated HVAC Components) (03-01-38-009)
2003-06-25: Info - Most Frequently Asked Questions and Answers for J 45096 TransFlow Transmission Oil Cooling System Flushing Machine (03-07-30-027)
2003-06-17: Dead Battery , Headlamps Stay On , No Start - accessory crank cut dim endgate electrical fuse generator glass inoperative instrument lamp light panel passenger power rear seat tailgate voltage wire (PI00382A)
2003-06-10: Service VME - Transflow Transmission Cooling System Service Tool J45096 Optional Heater Blanket - 3T40 372LE 3L30 3T40 4L30E 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60E 4T65E 4T80E 5L40E automatic fluid (PI01163)
2003-06-05: Info - Shift Stabilization and Tow/haul Mode Feature for Hydra-Matic 4L60-E/4L65-E and 4L80-E/4L85-E Transmissions (99-07-30-022A)
2003-05-19: Intermittent ABS Communication Codes - C0243 C0244 C0245 C0246 C0247 C0248 C0253 C0255 C0268 C0286 DTC U1031 U1041 (PI00714A)
2003-05-09: SMU - Revised Cruise Control Inoperative/Malfunctioning Diagnostic Information (03-08-68-001)
2003-04-29: Warranty Admin. - Courtesy Transportation Program (02-00-89-004B)
2003-04-29: SMU - Revised Transfer Case Disassemble and Transfer Case Assemble Procedures (03-04-21-003)
2003-04-24: Info - Bulletins Released Week of April 14, 2003 and Car and Truck Fix It Right the First Time Issues (03-00-89-010)
2003-04-22: Water Leak in Front Floor Carpet Area - body case cowl housing odor (PI01031)
2003-03-19: Inaccurate or Erratic Fuel Gauge Readings at 1/4 Tank or Lower (Replace Fuel Level Sensor and Reprogram PCM) (03-08-49-003)
2003-03-14: Info - Automatic Air Conditioning Control Operation (99-01-39-007B)
2003-03-07: Info - A/C Refrigerant System Sealer and A/C System Leak Detection Guidelines (03-01-38-001)
2003-03-07: Info - Changes to Essential and Available Tool Numbering System (03-00-89-005)
2003-03-05: 2.2L LN2 Rough Run or Idle Possible P0300, P0301 After Engine or Cylinder Head Replacement (PI00903)
2003-02-27: Info - Powertrain Quality Center for Performance Parts Engine Replacements (03-06-01-006)
2003-02-11: Slips in 4-Wheel Drive, Noise, Vibration, Leaks, Hot Odor (Diagnose and Repair Front Differential and/or Transfer Case) (02-04-21-005A)
2003-01-30: Rough Idle After Start, And/Or A Service Engine Soon (SES) Light (Unstick And Clean Central Sequential Fuel Injection (CSFI) Poppet Valves or Convert to MFI) (00-06-04-003B)
2003-01-29: Info - Automatic Transmission Oil Cooler Flushing and Flow Check Procedures (99-07-30-017A)
2002-12-16: Adm Msg - New Labor Time Guide Available Effective February 1, 2003 (WIW20020026)
2002-12-16: SMU - Revised Heater/Vent Module Replacement (02-01-38-005)
2002-10-25: Proper Diagnostic Procedures for No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, SIR, Brake, Security, Theft, ABS, Hot, DIC Messages, Lamp, Light, Battery and Generator Diag. Testing (02-06-03-012)
2002-10-14: Diagnostic Information for Intermittent Transmission Downshift, Slip, Busy/Cycling TCC or Noisy Cooling Fan (99-07-30-016B)
2002-09-23: Adm Msg - Important Programming/TIS Information for Technicians (Admin Number 20020120 - 9/10/02) (VSS20020120)
2002-09-11: Info - Release of New Tool J 45380 - Rear Output Shaft Bushing Remover and Installer (02-04-21-007)
2002-08-09: Info - Engine Crankcase Flush (02-06-01-028)
2002-07-24: Warranty Admin. - Claim Procedures for Warrantable Electronic Failures on Vehicles Sold As Certified Used Vehicles or Certified Pre-Owned Vehicles (02-00-89-013)
2002-07-19: Warranty Admin. - Revised Empowerment Level-Authorization Code E (02-00-89-009)
2002-07-19: Info - Preliminary Information (PI) Text Available in Service Information (SI) (02-00-89-008)
2002-07-18: SMU - Revised DTCs B1000, B1004, B1007, B1009, B1013 (02-08-47-001)
2002-06-21: Info - Expandable Acoustic Foam (Two Component Sound Dampener) Usage with Collision Damage Repairs (02-08-98-003)
2002-06-13: Info - Automatic Transmission Serial Number and Site Code Locations (02-07-30-028)
2002-06-13: Info - Engine Identification Information (02-06-01-026)
2002-06-05: General Water Leak Guide (02-08-57-004)
2002-05-24: Info - DTCs B1001, B1271 or B1780 Set When Replacing/Reprogramming Other Modules (02-09-41-001)
2002-04-30: Exhaust Boom/Groan Noise in Passenger Compartment (Install Exhaust Bracket and Dampers to Exhaust System) (02-06-05-002)
2002-03-14: Third Door Hard to Open and/or Handle Breakage (Adjust Lock Rods) (02-08-64-007)
2002-03-05: SMU - Revised DTC P0140 (02-06-04-011)
2002-02-27: Information on a New Engine Preluber Tool (02-06-01-008)
2002-01-11: Info - Engineering Changes to Reaction Shell Thrust Washer and use of New Service Kit (02-07-30-003)
2002-01-02: SMU - Revised Ignition Lock Cylinder Replacement (02-02-35-001)
2001-12-18: Info - Tire Sidewall Damage (01-03-10-011)
2001-12-17: Info - Diagnostic Tips for Slipping or Missing Second, Third and/or Fourth Gear (01-07-30-043)
2001-11-14: Info - Test Guidelines for Use of Essential Tool J41413-200 Evaporative System Tester (01-06-04-044)
2001-11-14: Info - Programming the HomeLink Transmitter (01-08-97-002)
2001-11-02: Exhaust System Rumble/Rattle Noise (Replace Exhaust Pipe Seals and Modify Exhaust Pipe Ring Flanges) (01-06-05-006)
2001-10-19: Info - 2-Cut vs. 5-Cut Rear Axle Ring and Pinion Gearsets (00-04-20-001A)
2001-10-04: Info - Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
2001-09-25: Information on Lowering Spare Tires Stored Under Vehicle (01-03-10-007)
2001-09-17: Warranty Admin. - Correct Use of Labor Operation R4490, RKE Transmitter, Replace (01-00-89-013)
2001-08-17: SMU - Revised Theft DeterrentDiagnostic Information (01-08-56-005)
2001-06-25: Info - Cleaning the Cassette Tape Player and Clearing the CLN Message from the Radio Display (01-08-44-006A)
2001-06-21: Info - Seat Belt System Replacement Guidelines for Vehicles Involved in Collisions (01-09-40-002)
2001-05-23: Security Lamp Illuminated on the IP, Engine Stalls, No Start, DTC B2960 (Security System Sensor Data Incorrect But Valid) Set (Inspect and Repair Cause of DTC B2960) (01-08-56-001A)
2001-05-14: F/CMVSS Noncompliance - Seat Belt Buckle (00067B)
2001-05-08: Info - Replacement of Keys, Key Numbers and/or Security Chips (01-00-89-009)
2001-05-02: Park/Neutral Position Switch Connector Cannot Be Removed (Replace Switch and Connectors) (01-07-30-021)
2001-04-09: Info - Guidelines for Use of Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
2001-04-06: Info - Current CIPS Campaign Number to Previous DIvisional Campaign Number (01-00-89-008)
2001-03-29: Info - New Control Valve Body, Spacer Plate and Gaskets for 4L60-E Automatic Transmission (01-07-30-012)
2001-03-02: Info - February, 2001 Bulletin Summary (01-00-89-006)
2001-02-08: Info - Recommended Rear Axle Lubricant (01-00-90-001A)
2001-02-02: Info - January, 2001 Bulletin Summary (01-00-89-005)
2001-01-11: Info - Air Conditioning Compressor Shaft Seal Replacement (01-01-38-001)
2001-01-03: Info - December, 2000 Bulletin Summary (01-00-89-001)
2000-12-18: Warranty Admin. - January 1, 2001 Labor Time Guide Updates (00-00-89-031)
2000-12-04: Info - November, 2000 Bulletin Summary (00-00-89-030)
2000-11-13: Warranty Admin. - December, 2000 Labor TIme Guide Updates (00-00-89-029)
2000-11-02: Info - October. 2000 Bulletin Summary (00-00-89-028)
2000-10-27: Info - Eliminationof Short Method (Short Cut Method) for Stationary Glass Replacement (00-08-48-003)
2000-10-24: Info - The Importance of Chassis Lubrication (00-00-90-001)
2000-10-17: Warranty Admin. - November, 2000 Labor Time Guide Updates (00-00-89-025)
2000-10-09: Information on 2001 French Label Installation Instructions (00-00-89-009A)
2000-10-06: Info - September, 2000 Bulletin Summary (00-00-89-024)
2000-09-21: Info - Correct Diagnostic Procedure When Reviewing A/C Performance/Leak Suspected (00-01-38-007)
2000-09-19: Warranty Admin. - October, 2000 Labor Time Guide Updates (00-00-89-023)
2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
2000-08-17: Warranty Admin. - Cross-line Warranty (00-00-89-021)
2000-08-10: Warranty Admin. - New Electrical Relay Labor Operation Numbers (00-00-89-019)
2000-08-03: Info - Essential Tool J 43600 ACR 2000 (00-01-38-006)
2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
2000-02-23: Informational - January, 2000 Bulletin Summary (00-00-89-003)