Technical Service Bulletins

2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-22: Information on OnStar Analog-Only Systems (06-08-64-007A)
2008-09-05: Information on Speedometer Accuracy (08-08-49-011B)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
2008-06-04: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-03-31: Transfer Case Takes A Long Time To Disengage From Lock Position - keywords 4HI 4LO 4Lock (PIP4381)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-01-31: 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
2008-01-30: Remote Keyless Entry Operational Characteristics (99-08-52-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2007-12-13: 4WD Models With Noise Vibration On Dry Pavement - keywords grind growl moan rattle (PIP3300B)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-30: OnStar Unwanted or Phantom Phone Calls - keywords call handsfree intermittent mmute OnStar OPC performance phantomcalls unwanted (PIC3278C)
2007-11-28: Procedure To Unlock Family Radio With Theftlock - keywords audio deterrent display entertainment inoperative loc lock theft theftdeterrent theftloc theftlock (PIC4696)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication digital failedtovoice information intermittent OnStar OPC operation no noconnect (PIC4310A)
2007-10-29: Revised General Motors New Vehicle Tire Warranty Program (00-03-10-003M)
2007-10-05: Guidelines When Changing Tire Size - keywords calibration program rim wheel (PIT3271D)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-09-27: Information on 4L60-E M30 Rear Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0756, P0894, Harsh 1-2 Shift (07-07-30-024)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-07-13: Product Emission - Ignition Coil Wire Arcing (98007)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-18: Special Coverage (Policy) Adjustment - Electronic Diesel-Fuel Injection Pump Failure-Repair/Replace (00064G)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Information on Low Fuel Lubricity and Fuel System Metal Contamination (99-06-04-047C)
2006-12-13: Information on OnStar Analog-Only Systems (06-08-46-007)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-09-23: Left Front Axle Shaft Difficult To Remove - keywords axle differential leak seal shaft shudder (PIP3340C)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
2006-08-31: Repeat HVAC Control Head Replacement - keywords control electrical ground inoperative module short (PIT4115)
2006-08-24: Info - Replacement of Connector When Replacing Fuel Tank Module/Fuel Pump Module (04-06-04-088C)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-01: No Start or Rough Running After Engine Replacement - keywords 7.4L crank crankshaft DTC Goodwrench L19 L29 nostart SES stall (PIP3877)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-08: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002D)
2006-05-17: Info - Instructions to be Followed to Aid in Obtaining Root cause Analysis on Both OEM and Goodwrench Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
2006-05-02: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-06: Discontinuation of the Field Product Reminder Bulletin/Bulletin Subscription Information (06-00-89-018)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-29: Info - Vibration Analysis Worksheet (03-00-91-001C)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-02: Warranty Admin. - Labor Operation Assignments for All Control Module Reprogramming (02-06-04-057E)
2006-03-01: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
2006-02-17: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance (06-08-45-001)
2006-02-14: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004b)
2006-02-13: Info - Radio Knobs Available for Service (05-08-44-029A)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-24: Info - Expediting Warranty Parts (99-00-89-021E)
2006-01-19: 4WD Models with Noise, Vibration on Dry Pavement - keywords 04-04-18-001D 226 233E 236 241 243E 246 246EAU axle bearing bind case chatter chuggle decelerate differential front grab high HI4 (PIP3300A)
2006-01-18: Info - New Product Feedback Form and Process for Automatic Transmission Core Returns (01-07-30-029A)
2006-01-12: 4T65-E Automatic Transmission Fluid Leak from Reverse Servo Cover (Replace Reverse Servo Cover Seal) (04-07-30-028A)
2006-01-05: Antilock Brake (ABS) Activation at Low Speeds (Clean Wheel Speed Sensor Mounting Surface) (02-05-25-006B)
2006-01-04: Info - Maintenance Cleaning of Fuel Injectors (04-06-04-051B)
2005-12-23: Location of Interior Lamp Control Module - keywords control dim dome electrical entry ground illumination inoperative keyless lens light remort resistor RKE short (PIT3819)
2005-12-22: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
2005-11-21: Info - Paint-less Dent Repair Process (99-08-51-001A)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-10-06: Info - Transmission Fluid Leak Diagnosis (01-07-30-041B)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-08-18: Info - Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
2005-08-17: Info - Release of GM Tool Organizaiton DVD Version 8.0 (J-43921-G) (05-00-89-056)
2005-08-10: Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inop I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
2005-08-05: Info - SPAC Case Escalation Process (05-00-89-050)
2005-08-02: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case (05-04-21-004)
2005-07-21: Hydro-Boost Brake Pedal Moves or Self Applies at Full Turns - keywords booster hydroboost press steering turn wheel (PIT3665)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-27: Warranty Admin. - Out-Of-Warranty Parts for Engineering Analysis (05-00-89-037)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-16: Light Throttle Hesitation or Misfire - keywords 4.3 5.0 5.7 accelerate backfire buck chuggle code decelerate detonation DTC hard harsh hot injector L30 L31 L35 launch miss noise surge (PIP3470)
2005-06-08: Info - On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
2005-06-03: Goodwrench Powertrain Wholesale Program (U.S. Only) (05-06-01-017)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-12: Info - Top Tether Hardware Package for Child Restraint Seats (99-09-40-004a)
2005-04-12: Info - OnStar System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-17: Info - GM Parts Ordering System (05-00-89-018)
2005-03-10: Info - Guidelines for Replacement of Transfer Case Control Module (TCCM) (05-04-21-002)
2005-03-08: Info - OnStar Kit Part Numbers and Compatibility (99-08-46-001A)
2005-03-08: Information on Excessive Use of RTV Silicone Sealant on New Venture Gear (NVG) and Borg Warner Transfer Cases During Service (05-04-21-001)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-09: Info - Proper Air Bag System Diagnosis and Service (03-09-41-003A)
2005-01-31: Warranty Admin. - Guidelines for Claiming C0034 - Windshield Replacement (05-08-48-001)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-14: Info - OnStar Proactive Parts Shipment Process (02-08-46-013A)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2005-01-04: 95 - 00 Chevrolet GMC Oldsmobile and Cadillac Utilities Washer Fluid Leaks from Rear Nozzle - kw wiper GMT330 GMT400 (PIT3345)
2004-12-13: Info - Battery Specification Label (04-06-03-016)
2004-12-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022C)
2004-11-18: Info - Shipping Enhancements for Owners Manuals and Service Manuals Ordered from Helm, Inc. (04-00-89-057)
2004-11-18: Warranty Admin. - Warranty Return Parts (04-00-89-051)
2004-10-20: Info - Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
2004-10-11: Info - Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002A)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-14: Info - Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (01-01-38-006D)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-03: Warranty Admin. - Dealer Installed Regular Production Options (RPO) and Regular Production Accessories (RPA) (01-00-89-015A)
2004-08-02: Info - Repair Procedure for Service Sheet Metal, Craters in ELPO Surface (04-08-98-002)
2004-07-27: Warranty Admin. - Changes to General Motors Vehicle Inquiry System (GMVIS) (04-00-89-029)
2004-07-23: SES Light and P0300 When Towing , Cruising Uphill or on Hard Acceleration - kw 4.3 5.0 5.7 accelerate cruise cylinderhead DTC L30 L31 L35 LF6 LU3 P0300 P0301 P0302 P0303 P0304 P0305 P0306 P0307 P0308 (PIP3081)
2004-07-02: Info - Battery Parasitic Drain (02-06-03-010A)
2004-06-22: Info - J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
2004-06-22: Info - New Owner Orientation Clinic Materials Now Available Online (03-00-89-002A)
2004-06-08: 93-00 Full Size Utilities (GMT400 Old Style Only) AC Blows Warm and the High Side Pressure Is Too High - kw air condenser HVAC performance rear R134A temperature (PIT3005)
2004-05-26: Info - Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
2004-04-29: Information on Serpentine Belt Wear (04-06-01-013)
2004-03-29: Warranty Administration - Part and Accessory Replacement Policy (04-00-89-011)
2004-02-11: Info - 4L65-E, 4L60-E, 4L60 and 200-4R Automatic Transmission Oil Pump Spring First and Second Design Identification (04-07-30-006)
2004-02-05: Warranty Admin. - Dealer Disclosure Requirements (02-00-89-005A)
2003-11-11: Info - Search Tips for Locating Preliminary Information (PI) Documents in Service Information (03-00-89-039)
2003-11-05: Special Policy Adjustment-Sequential Central Port Fuel Injection (SCPI) Failures in California Only (YF5 Emission Equipped) (99066G)
2003-10-29: Diagnostic Information to Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
2003-09-19: Warranty Admin. - Sublet Administrative Allowance (Coverage: S) Labor Operations (03-00-89-027)
2003-07-14: Info - J 44551 A/C Suction Screen Kit Repair Recommendations and Procedures After Catastrophic Compressor Failures (01-01-39-003A)
2003-07-14: Info - HomeLink Transceiver/Garage Door Opener Transmitter Test Kit Available As Essential Tool (01-08-97-001B)
2003-06-25: Info - Most Frequently Asked Questions and Answers for J 45096 TransFlow Transmission Oil Cooling System Flushing Machine (03-07-30-027)
2003-05-28: Special Policy Adjustment-Windshield Wiper Motor Failures (02054A)
2003-04-29: Warranty Admin. - Courtesy Transportation Program (02-00-89-004B)
2003-04-24: Info - Bulletins Released Week of April 14, 2003 and Car and Truck Fix It Right the First Time Issues (03-00-89-010)
2003-03-14: Info - Automatic Air Conditioning Control Operation (99-01-39-007B)
2003-03-07: Info - A/C Refrigerant System Sealer and A/C System Leak Detection Guidelines (03-01-38-001)
2003-03-07: Info - Changes to Essential and Available Tool Numbering System (03-00-89-005)
2003-02-27: Info - Powertrain Quality Center for Performance Parts Engine Replacements (03-06-01-006)
2003-01-30: Rough Idle After Start, And/Or A Service Engine Soon (SES) Light (Unstick And Clean Central Sequential Fuel Injection (CSFI) Poppet Valves or Convert to MFI) (00-06-04-003B)
2003-01-29: Info - Automatic Transmission Oil Cooler Flushing and Flow Check Procedures (99-07-30-017A)
2003-01-07: SMU - Revised DTC P0122 (03-06-04-001)
2002-10-25: Proper Diagnostic Procedures for No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, SIR, Brake, Security, Theft, ABS, Hot, DIC Messages, Lamp, Light, Battery and Generator Diag. Testing (02-06-03-012)
2002-10-14: Diagnostic Information for Intermittent Transmission Downshift, Slip, Busy/Cycling TCC or Noisy Cooling Fan (99-07-30-016B)
2002-09-23: Adm Msg - Important Programming/TIS Information for Technicians (Admin Number 20020120 - 9/10/02) (VSS20020120)
2002-08-09: Info - Engine Crankcase Flush (02-06-01-028)
2002-08-07: 6.5L L65 Diesel Engine Idle Surge, Rough Idle, or Idle Flare No DTCs (PI00140A)
2002-07-24: Info - U.S. On-Board Diagnostics (OBD) II Retrofit Program (02-06-04-039A)
2002-07-24: Warranty Admin. - Claim Procedures for Warrantable Electronic Failures on Vehicles Sold As Certified Used Vehicles or Certified Pre-Owned Vehicles (02-00-89-013)
2002-07-19: Warranty Admin. - Revised Empowerment Level-Authorization Code E (02-00-89-009)
2002-07-19: Info - Preliminary Information (PI) Text Available in Service Information (SI) (02-00-89-008)
2002-06-21: Info - Expandable Acoustic Foam (Two Component Sound Dampener) Usage with Collision Damage Repairs (02-08-98-003)
2002-06-13: Info - Automatic Transmission Serial Number and Site Code Locations (02-07-30-028)
2002-06-13: Info - Engine Identification Information (02-06-01-026)
2002-03-11: SMU - Revised Drum Brakes Component Specifications (02-05-24-001)
2002-02-27: Information on a New Engine Preluber Tool (02-06-01-008)
2002-01-11: Info - Engineering Changes to Reaction Shell Thrust Washer and use of New Service Kit (02-07-30-003)
2001-12-18: Info - Tire Sidewall Damage (01-03-10-011)
2001-11-14: Info - Test Guidelines for Use of Essential Tool J41413-200 Evaporative System Tester (01-06-04-044)
2001-11-02: Exhaust System Rumble/Rattle Noise (Replace Exhaust Pipe Seals and Modify Exhaust Pipe Ring Flanges) (01-06-05-006)
2001-10-19: Info - 2-Cut vs. 5-Cut Rear Axle Ring and Pinion Gearsets (00-04-20-001A)
2001-10-04: Info - Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
2001-09-25: Information on Lowering Spare Tires Stored Under Vehicle (01-03-10-007)
2001-09-17: Warranty Admin. - Correct Use of Labor Operation R4490, RKE Transmitter, Replace (01-00-89-013)
2001-06-25: Info - Cleaning the Cassette Tape Player and Clearing the CLN Message from the Radio Display (01-08-44-006A)
2001-06-21: Info - Seat Belt System Replacement Guidelines for Vehicles Involved in Collisions (01-09-40-002)
2001-05-08: Info - Replacement of Keys, Key Numbers and/or Security Chips (01-00-89-009)
2001-05-02: Park/Neutral Position Switch Connector Cannot Be Removed (Replace Switch and Connectors) (01-07-30-021)
2001-04-09: Info - Guidelines for Use of Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
2001-04-06: Info - Current CIPS Campaign Number to Previous DIvisional Campaign Number (01-00-89-008)
2001-03-02: Info - February, 2001 Bulletin Summary (01-00-89-006)
2001-02-02: Info - January, 2001 Bulletin Summary (01-00-89-005)
2001-01-03: Info - December, 2000 Bulletin Summary (01-00-89-001)
2000-12-18: Warranty Admin. - January 1, 2001 Labor Time Guide Updates (00-00-89-031)
2000-12-04: Info - November, 2000 Bulletin Summary (00-00-89-030)
2000-11-13: Warranty Admin. - December, 2000 Labor TIme Guide Updates (00-00-89-029)
2000-11-02: Info - October. 2000 Bulletin Summary (00-00-89-028)
2000-10-24: Info - The Importance of Chassis Lubrication (00-00-90-001)
2000-10-17: Warranty Admin. - November, 2000 Labor Time Guide Updates (00-00-89-025)
2000-10-06: Info - September, 2000 Bulletin Summary (00-00-89-024)
2000-09-21: Info - Correct Diagnostic Procedure When Reviewing A/C Performance/Leak Suspected (00-01-38-007)
2000-09-19: Warranty Admin. - October, 2000 Labor Time Guide Updates (00-00-89-023)
2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
2000-08-17: Warranty Admin. - Cross-line Warranty (00-00-89-021)
2000-08-14: Warranty Admin. - September, 2000 Labor Time Guide Updates (00-00-89-020)
2000-08-10: Warranty Admin. - New Electrical Relay Labor Operation Numbers (00-00-89-019)
2000-08-08: Info - July, 2000 Bulletin Summary (00-00-89-018)
2000-08-03: Info - Essential Tool J 43600 ACR 2000 (00-01-38-006)
2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
2000-06-19: Warranty Admin. - July, 2000 Labor Time Guide Updates (00-00-89-014)
2000-06-19: Warranty Admin.- PCM Product Feedback Program (00-06-04-026)
2000-06-08: Info - California Consent Order on Settlement of Lawsuit on Batteries (Prop 65) (00-06-03-006)
2000-06-06: Info - May, 2000 Bulletin Summary (00-00-89-013)
2000-05-15: Info - Proper Service of Quick Connect EVAP System Connectors (00-06-04-021)
2000-05-12: Warranty Admin. - June, 2000 Labor TIme Guide Updates (00-00-89-012)
2000-05-08: Info - Brake Fluid Level and Filling Recommendations (00-05-22-004)
2000-04-14: Warranty Admin. - May, 2000 Labor Time Guide Updates (00-00-89-010)
2000-04-04: Info - March, 2000 Bulletin Summary (00-00-89-007)
2000-03-28: No/Hard/Slow Start, Backfire/Kickback (Replace Crankshaft Position Sensor) (00-06-04-014)
2000-03-21: Info - Essential Tool J 43690 - Rod Bearing Clearance Checking Tool (00-06-01-007)
2000-02-11: Warranty Admin. - March, 2000 Labor Time Guide Updates (00-00-89-002)
2000-01-19: February, 2000 Labor Time Guide Updates (00-00-89-001)
2000-01-13: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
2000-01-06: Hard, No Start, Excessive Smoke On Start Up (Replace Glow Plugs) (00-06-04-002)
1999-12-06: Info - The Year 2000 (Y2K) and Vehicle Electronics (99-00-89-022)
1999-10-26: Info - PCM Reprogramming (99-06-04-053)
1999-10-20: Info - Radiator Repair/Replacement Guidelines (99-06-02-017)
1999-10-14: November, 1999 Labor Time Guide Updates (99-00-89-020)
1999-10-08: Warranty Administration - October, 1999 Labor Time Guide Updates (99-00-89-017)
1999-10-07: Tech - Noise from Clutch Housing, Clutch May Not Engage (99-07-31-003A)
1999-09-02: Tech - Brake Lead/Pull and Frt Brake Wear (Repl. Frt Brake Pads, Rr Brake Shoes) (99-05-24-001A)
1999-08-10: Warranty Admin - September, 1999 Labor Time Guide Updates (99-00-89-016)
1999-07-29: Info - Compact Disc (CD) Players and Compatible CDs (99-08-44-006)
1999-07-28: Warranty Admin - August, 1999 Labor Time Guide Updates (99-00-89-012)
1999-06-25: Warranty Admin - July 1999 Labor Time Guide Updates (99-00-89-010)
1999-06-18: Info - Rear Axle Lubricant Compatibility and Usage (99-04-20-001)
1999-05-25: Information - Original Equipment Chrome Plated Aluminum Wheel Identification (99-03-10-102)
1999-05-19: June 1999 Labor Time Guide Updates (99-00-89-008)
1999-04-20: Warranty Admin. - May, 1999 Labor Time Guide Update (99-00-89-006)
1999-04-20: Engine Surge While Trailering (Reprogram VCM) (99-06-04-016)
1999-04-06: Labor Time Guide Updates - April 1999 (99-00-89-004)
1999-03-31: Info - Cleaning of Upper Instrument Panel Surfac (99-08-49-006)
1999-03-29: Engine Bearing Knock Noise (Re-suppport Crankshaft, Select-fit Rod Bearings) (99-06-01-003)
1999-03-19: Engine Tick/Knock/Rattle Noise (Reprogram VCM) (99-06-04-014)
1999-03-18: Info - Component Slipping/DTC P1870 - Diagnosis (99-07-30-005)
1999-03-09: Labor Time Guide Updates (99-00-89-003)
1999-03-04: Battery Insulator Replacement (99-06-03-002)
1999-02-26: Essential Tool J 42000 Battery Tester (99-06-03-001)
1999-02-24: Noise From A.I.R. Valves on Start-up (Replace A.I.R. Valves) (99-06-04-002)
1999-02-19: Warranty Parts Center/Corporate Parts Return Program (40-05-01C)
1999-02-19: 1-2 Accumulator Piston and Outer Spring Replacement (87-74-74)
1999-02-16: Warranty Administration - Labor Time Updates (99-00-89-001)
1999-02-12: Correct Solvent for SCPI Poppet Cleaning Procedure (99-06-04-006)
1998-11-16: INFO - ESSENTIAL TOOL J43435 ADJUSTER LOCKNUT (83-32-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-10-30: INFO. ON REAR AXLE LUBRICANT COMPATIBILITY (86-42-04)
1998-10-29: INFO - TEMP. CHANGES TO TECHLINE ESI APPLICATIONS (83-01-20)
1998-10-20: INFO - ESSENTIAL TOOL J43485 POWER STEERING BLEEDER ADAPTER (83-32-09)
1998-10-08: WARRANTY ADMIN - LTG UPDATES (83-05-09)
1998-10-01: INFO - NEW WINDSHIELD AND STATIONATY GLASS URETHANE (83-15-16)
1998-10-01: INFO - REDUCED RANGE/OPERATION OF RKE (86-90-06)
1998-09-29: INFO ON RECOMMENDED AXLE LUBRICANT (76-02-02A)
1998-09-22: EXTENDED ENGINE CRANKING TIME DURING HOT ENGINE RESTART IN (87-65-25)
1998-09-18: SLOW OR NO ENGAGEMENT OF FRT. AXLE WHEN 4WD IS SELECTED (76-43-01A)
1998-09-17: WARRANTY ADMIN. - LTG UPDATES (83-05-08)
1998-09-16: INFO - NEW PCM CONNECTOR SERVICE KITS (83-81-32)
1998-09-16: SMU - SEC. 0B - CORRECTED CRANKCASE VENTILATION SYSTEM (83-02-01)
1998-09-08: LOW TRANS. FLUID LEVEL, TRANSFER CASE FLUID OVERFILLED (86-74-04)
1998-08-31: CAMPAIGN:FUEL TANK MAY CONTACT BODY SILL (98044)
1998-08-26: INFO - DIAGNOSING VARIOUS DIESEL DRIVEABILITY CONDITIONS (87-65-13)
1998-08-21: WARRANTY ADMIN - LTG UPDATES (83-05-07)
1998-08-21: INFO - TOWING (16-01-01B)
1998-08-20: INFO - ESSENTIAL TOOL J-43241 REMOTE KEYLESS ENTRY AND (83-90-12)
1998-08-17: FLUID LEAK NEAR FRONT WHEELS OR FRONT ENGINE (86-43-06A)
1998-08-14: INFO - CORRECT LABOR CODE USAGE FOR ENTERTAINMENT SYS. (84-96-01)
1998-08-12: WARRANTY ADMIN. - REDEFINED USE OF PARTS WARRANTY SPECIAL (80-05-03)
1998-07-17: NO START, STALL, DTC 35 (94-95 M/Y) OR P1216 (77-63-06A)
1998-07-17: ROUGH IDLE AFTER START WHEN VEH. HAS SAT OVERNIGHT (87-65-07A)
1998-07-17: INFO. ON INSTALLATION OF A 6.5L DIESEL GOODWRENCH ENGINE (87-61-28)
1998-07-15: WARRANTY ADMIN. - LTG UPDATES (83-05-06)
1998-07-15: SMU - SEC. 4 - FRONT DRIVE AXLE REVISED PROCS. FOR (86-43-08)
1998-06-11: WARRANTY ADMIN. - LTG UPDATES (83-05-05)
1998-06-04: INFORMATION ON AUTO TRANS EXTERNAL OIL COOLERS (36-71-03A)
1998-06-03: INFO - NEW TOOL J-42958, REV. CHARTS AND SCHEM. FOR CRUISE (83-90-08)
1998-06-01: FUEL GAUGE INDICATES EMPTY W/ 7 - 8 GALLONS (76-83-03A)
1998-05-18: ACCESSORY DRIVE BELT NOISE DUE TO STEERING PUMP PULLEY (77-60-02)
1998-05-18: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-04)
1998-05-11: SMU - SEC. 6/6E - REV. 'NO SERIAL DATA' DIAGNOSTIC PROC. (81-65-40)
1998-04-24: HARSH 1-2 UPSHIFTS ALL GEARS (87-71-62)
1998-04-24: GENERAL MOTORS WARRANTY INQUIRY SYSTEM (82-05-05)
1998-04-21: WARRANTY ADMIN - REQ. FOR WHOLESALE AUTH. OR WARRANTY (82-05-02)
1998-04-21: WARRANTY ADMIN - ELIMINATION OF LABOR OPS ZZ920 & Z7930 (82-05-03)
1998-04-16: WARRANTY ADMIN. - LTG UPDATES (83-05-03)
1998-04-02: INFO. USE OF'SURFACE CONDITIONING DISCS' (87-61-24)
1998-03-31: SMU - SECTION 6E - ENGINE CONTROLS - REVISED (61-65-60A)
1998-03-24: HARD START, NO START, DTC 13 OR P0215, SES LIGHT ON (87-63-04)
1998-03-17: SMU - SEC. 6/6E - ENG CONTROLS REV. ENHANCED IGN.SYS. DIAG. (81-65-36)
1998-03-16: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-02)
1998-03-16: DIESEL ENG. HESITATION, WHITE SMOKE, ROUGH IDLE, LACK OF PWR (87-63-03)
1998-03-10: EXCESSIVE TICKING NOISE IN AMBIENT TEMP. (DIAG REPL. (87-63-02)
1998-03-10: INFO. NEW TOOL J-41450-B RELEASED FOR CS GEN DIAG. (83-64-09)
1998-03-02: INFO - FUEL LEVEL SENSOR REPLACEMENT PROC (83-83-07)
1998-03-01: INFO. - INJECTION PUMP EXCHANGE PROGRAM - GM CANADA (75-63-03A)
1998-02-20: WARRANTY ADMIN - LABOR TIME GUIDE UPDATES (83-05-01)
1998-02-13: HARDSTART & STUMBLE, WITH MIL ON & POSS. HISTORY DTC'S (77-65-27)
1998-02-13: SMU-SEC. 6E - ENG. CONTR. REV. DTC. P0137,P0172 (81-65-37)
1998-02-13: WHITE SMOKE ROUGH IDLE POOR THROTTLE RESPONSE (77-65-26)
1998-02-13: INFO. ON VIN PLATE REPLACEMENT (83-01-14)
1998-01-21: SMU - SEC. 6 - ENG. CONTROLS REVISED TDC OFFSET ADJ. (71-65-67)
1998-01-14: INFO. - DIAG PROC. WHEN A/C DIAG INFO LEAK (73-12-12A)
1998-01-12: INFO. FRONT. SUPP. INFLAT. RESTRAINTS (SIR) ON-OFF SWITCH (73-90-23)
1997-12-18: WARRANTY ADMIN. - REPAIR/ REPLACE POLICIES & PROC. (72-05-13)
1997-12-18: WARRANTY ADMIN. - ENHANCED SUBLET REPAIR POLICY (72-05-14)
1997-12-16: WARR. ADMIN - LABOR TIME GUIDE UPDATES (73-05-09)
1997-12-02: LOSS OF 4TH GEAR, SLIPPING IN 4TH GEAR, BUSY 3-4 (77-71-77)
1997-11-28: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (73-05-07)
1997-11-26: INFO. ON TECHNICAL ASSISTANCE CALL PREPARATION (73-01-10)
1997-11-20: CLARIFICATION OF RAIL DUST REM (A5575-A5580) (72-05-11)
1997-11-18: INFO. ON INSTRUMENT CLUSTER IDENTIFICATION (78-83-03A)
1997-11-12: INFORMATION - PUREGUARD 2 OPERATING ALERT (73-12-13)
1997-11-01: WARRANTY ADMIN. - LABOR OPERATION CODE Z1241 (62-05-02A)
1997-10-24: WARR. ADMIN-LTG UPDATES 1989-98 PASS. CAR & TRUCK (73-05-06)
1997-10-17: INFO. ON COOLER FLUSH ADAPTER TOOLS FOR HYDRA-MATIC (77-71-68)
1997-10-16: CAMPAIGN: FRONT SEAT MOUNTING BOLTS (97052)
1997-10-09: HVAC CONTROL KNOB SPINS FREELY (REPLACE) (76-11-01)
1997-10-01: SMU-SECT. 6-ENG. MECH CYLINDER HEAD INSTALLATION (77-61-14)
1997-09-25: INFO. NEW TUMBLERS FOR CYLINDERS RECODING REV. REPAIR (73-01-09)
1997-09-25: SMU-SEC.6-ENG. MECHANICAL CRANKSHAFT & BEARINGS (77-61-15)
1997-09-25: INFO - DIAG. HINTS FOR 'ROLLING CODE' REMOTE FUNC. (73-90-18)
1997-09-18: EXCESSIVE FUEL GUAGE FLUCTUATION (INSTALL FUEL (76-83-05)
1997-09-11: WARRANTY: TIRE REPLACEMENT DURING BUMPER TO BUMPER (70-05-01)
1997-09-01: ENGINE NOISE (INSTALL VALVE STEM OIL SEAL) (67-61-14B)
1997-09-01: INFO. ON ALUMINUM HEATER CORE AND/OR RADIATOR REPL. (73-62-13A)
1997-08-30: CAMPAIGN: INCORRECT LINEAR EXHAUST GAS (97024)
1997-08-21: WARRANTY ADMIN - GUIDELINES FOR USING E0420 WHEEL (72-05-05)
1997-08-21: WARRANTY ADMIN- GUIDELINES FOR USING I/M 240 LABOR OP (72-05-06)
1997-08-15: INFO ON DIAG OF TRANS NOISE,DELAYED, ENGAGED (77-71-67)
1997-08-12: WARRRANTY ADMIN - LABOR TIME GUIDE UPDATES (73-05-05)
1997-07-31: SMU-SECT. 6E-ENG. CONT REV. DIAG TROUBLE CODE (71-65-36)
1997-07-25: SMU - SEC. 8A-114-INT LIGHT REVISED (76-81-10)
1997-07-25: SMU-SEC-8A-81 INSTRUMENTAL CLUSTER REV. (76-81-11)
1997-07-25: SMU-SEC. 132 & 201 REMOTE KEY (76-81-12)
1997-07-25: SMU-SEC. 8A-76 AUDIBLE WARNINGS (76-81-13)
1997-07-25: SMU-SEC.8A-81 INSTRUMENT CLUSTER (76-81-14)
1997-07-25: SMU-SEC.8A-11 FUSE BLOCK DETAILS (76-82-08)
1997-07-24: SMU-SECTION 8A-91 WIPER/ WASHER - REVISED (76-81-15)
1997-06-13: STEERING WANDER (RESET ALIGN ADJ.REP. STEERING GEAR) (76-30-01)
1997-06-01: INFO. ON NEW AFTERMARKET PAINT SPECIFICATION (GM4901M) (63-17-07B)
1997-06-01: INFO. ON 1997 TRUCKS WITH 6.5L DIESEL ENGINE PRODUCTS UPDATES (67-61-20A)
1997-06-01: CAMPAIGN: SEAT RECLINER HINGE PINCH POINT (97008A)
1997-05-29: INFO ON AUTO TRANS OIL COOLER FLUSHING &FLOW CHECK PROC. (77-71-59)
1997-05-21: WARRANTY ADMIN: LTG UPDATES 89-97 (73-05-04)
1997-05-12: INFORMATION -TWO PART URETHANE ADHESIVE (73-10-54)
1997-05-01: SMU - SECTION 6E - REVISED ENHANCED IGNITION SYSTEM (71-65-40)
1997-05-01: SMU-SECTION 5E1-ANTILOCK BRAKE REVISED FRONT WHEEL SENSOR (76-50-09)
1997-04-18: INFORMATION DISTRIBUTOR SERVICE KITS (77-64-04)
1997-04-17: INFORMATION: FUEL GAUGE RESP. SLOWLY AFTER FUELING (73-83-15)
1997-04-17: INFO. ON A/C TOOL AND EQUIPMENT MAINTENANCE (63-12-08A)
1997-04-01: FIBER GLASS REAR FENDER PAINT STAR SHAPED CRACKS (66-15-09A)
1997-04-01: 1997 BILL 101 FRENCH LABEL INSTALLATION INSTRUCTIONS (35-01-04D)
1997-03-26: INFO. - REVISED SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) (73-01-07)
1997-03-21: EASY ENTRY SEAT NOISE, MOVEMENT, HIGH ADJUSTMENT (76-16-12)
1997-03-20: WARRANTY ADMINISTRATION - LABOR TIME GUIDE UPDATES (73-05-03)
1997-03-06: INFO. ON 1997 TRUCKS WITH 6.5L DIESEL ENGINE (77-61-08)
1997-03-06: INFORMATION ON REPROGRAMMING CAPABILITY (73-65-13)
1997-03-03: MALFUNCTION INDICATOR LIGHT (MIL) ON, POOR DRIVEABILITY (76-65-04)
1997-03-03: CHUGGLE / SURGE ON TCC APPLY NO DTC'S - REFLASH PCM (77-71-53)
1997-03-01: 'CLN' INDICATOR APPEARS ON RADIO DISPLAY (54-90-01A)
1997-02-27: BROKEN REAR CARGO DOOR HINGE (INSTALL REPLACEMENT HINGE) (76-15-10)
1997-02-20: WARRANTY ADMINISTRATION LABOR TIME GUIDE UPDATES (73-05-02)
1997-02-07: SERVICE ISSUES FOR VEHICLES WITH R12 OR R134A A/C SYSTEMS (73-12-04)
1997-02-05: INFO. ON PICTORIAL OF OXYGEN SENSOR DESIGNATIONS (67-65-40)
1997-02-01: CAMPAIGN: CLUTCH PEDAL SEP. FROM PIVOT BRACKET (97006)
1997-01-31: INFO. NEW BODY SEALER TAPE FOR COLLISION REPAIRS (73-10-49)
1997-01-29: SMU - SECTION 9J - REVISED REMOVE/INSTALL PROCEDURE (73-90-05)
1997-01-27: SMU - SECTION 8A-114 - INTERIOR LIGHTS - REVISED (76-81-02)
1997-01-24: WARRANTY ADMINISTRATION - LABOR TIME GUIDE UPDATES (73-05-01)
1997-01-23: SMU - SECTION 8A-120 - POWER WINDOWS - REVISED CHART (66-81-31)
1997-01-17: SMU - SECTION 6E - ENGINE CONTROLS - REVISED (61-63-16)
1997-01-13: INFO. ON COMPACT DISC PLAYERS- PROCEDURES (64-96-01)
1997-01-07: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (63-05-07)
1997-01-01: INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) WITH DTCS (67-65-39)
1997-01-01: ELECTRICAL INTERFERENCE IN MOBILE (TWO-WAY) RADIO (56-96-03A)
1996-12-03: WARRANTY ADMIN. - GM CERTIFIED USED VEHICLE WARRANTY REPAIRS (60-05-03)
1996-12-01: SMU - SECTION 7A - AUTOMATIC TRANSMISSION (67-71-63)
1996-12-01: CAMPAIGN: EMISSION LABEL ERROR (96072)
1996-11-21: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (63-05-06)
1996-11-15: INFO. REFERENCE CHART FOR A/C COMPRESSOR SEAL WASHERS (63-12-15)
1996-11-13: WATER LEAKS FROM REAR A/C INTO REAR COMPARTMENT (66-12-08)
1996-11-01: TRANS. PRODUCT UPDATES (NEW SHIFT SOLENOIDS) (37-71-48A)
1996-10-29: INFORMATION ON NEW PCM IDENTIFICATION LABEL (67-65-35)
1996-10-28: INFORMATION ON UNDER HOOD REEL LAMP (66-90-02)
1996-10-28: WARRANTY ADMIN. - GM TIRE WARRANTY POLICIES (60-05-02)
1996-10-25: INFORMATION ON 1997 4L80E TRANSMISSION PRODUCT UPDATES (67-71-57)
1996-10-22: WARRANTY ADMINISTRATION - LABOR TIME GUIDE UPDATES (63-05-05)
1996-10-15: INFO. ON THE GENERAL MOTORS KEY CODE VOICE RESPONSE SYSTEM (61-01-11)
1996-10-10: WARRANTY ADMIN. - SUBMISSION OF ALL OBDII P - CODES (67-05-02)
1996-10-02: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES 1989 -1997 (63-05-04)
1996-10-01: REAR CARGO DOOR HINGE BINDS (REPLACE PINS AND BUSHINGS) (36-10-14B)
1996-10-01: DRIVELINE CLUNK (56-44-01A)
1996-10-01: PROCEDURE TO HANDLE CUSTOMER RADIO CONCERNS (68-96-01A)
1996-09-04: FOUR WHEEL DRIVE HI RANGE DOES NOT ENGAGE DURING COLD WEATHER (66-74-07)
1996-09-01: SIR MODULE SHIPPING/RETURN PROCEDURES (31-90-04A)
1996-09-01: ACDELCO SERVICE CENTER LOC. FOR ODOMETER/SPEEDOMETER (66-83-04A)
1996-08-28: SMU - SECTION 1B - HVAC - UPDATED CCOT (66-12-06)
1996-08-28: INFORMATION ON NEW PRODUCT INFORMATION (67-71-51)
1996-08-14: WARRANTY ADMIN. - LABOR TIME GUIDE ' REQUEST FOR REVIEW ' (63-05-03)
1996-08-14: SMU - SECTION 1B - HEATING - VENTILATION & AIR CONDITIONING (66-12-05)
1996-06-28: SMU - SECTION 7A - AUTOMATIC TRANSMISSION / TRANSAXLE REV. (67-71-49)