GM Service Manual Online
For 1990-2009 cars only

Long Trip/Highway Scheduled Maintenance (Gasoline)

The services shown in this schedule up to 166 000 km (100,000 mi) should be performed after 166 000 km (100,000 mi) at the same intervals. The Services shown at 240 000 km (150,000 mi) should be performed at the same interval after 240 000 km (150,000 mi).

Footnotes

@ The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

# Lubricate the front suspension, kingpin bushings, steering linkage, transmission shift linkage, transfer case shift linkage, park brake cable guides, rear driveline center splines, front axle propshaft spline and brake pedal springs. Ball joints and kingpin bushings should not be lubricated unless their temperature is -12°C (10°F) or higher, or they could be damaged.

+ A good time to inspect the brakes is during tire rotation.

12 500 km (7,500 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first).
        This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote #.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Rotate tires. (See footnote +.)

25 000 km (15,000 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first).
        This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote #.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Inspect shields and underhood insulation for damage or looseness. Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    â€¢ Rotate tires. (See footnote +.)

37 500 km (22,500 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote #.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Rotate tires. (See footnote +.)

50 000 km (30,000 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first).
        This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote #.)
    â€¢ Inspect rear axle fluid level and add fluid as needed. Change axle fluid if the vehicle is driven in high-speed (above 40 mph or 70 km/h) conditions for extended peiods of time.
    â€¢ Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    â€¢ Rotate tires. (See footnote +.)
    â€¢ Replace fuel filter.
        This is an Emission Control Service. (See footnote @.)
    â€¢ Inspect shields and underhood insulation for damage or looseness. Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

62 500 km (37,500 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote+.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Rotate tires. (See footnote +.)

75 000 km (45,000 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote +.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Inspect shields and underhood insulation for damage or looseness. Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    â€¢ Rotate tires. (See footnote +.)

83 000 km (50,000 mi)

Change automatic transmission fluid and filter.

Manual transmission fluid does not require change.

87 500 km (52,500 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote +.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Rotate tires. (See footnote +.)

100 000 km (60,000 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12  months, whichever occurs first). (See footnote +.)
    â€¢ Inspect rear axle fluid level and add fluid as needed. Change axle fluid if the vehicle is driven in high-speed (above 40 mph or 70 km/h) conditions for extended periods of time.
    â€¢ Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    â€¢ Rotate tires. (See footnote +.)
    â€¢ Inspect engine accessory drive belt.
        This is an Emission Control Service.
    â€¢ Replace fuel filter.
        This is an Emission Control Service. (See footnote @.)
    â€¢ Inspect shields and underhood insulation for damage or looseness. Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    â€¢ Inspect Evaporative Control system. Inspect all fuel and vapor lines and hoses for proper hook-up, routing and condition. Inspect that the purge valve works properly, if equipped. Replace as needed.
        This is an Emission Control Service. (See footnote @.)

112 500 km (67,500 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote +.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Rotate tires. (See footnote +.)

125 000 km (75,000 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote +.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢  Inspect shields and underhood insulation for damage or looseness. Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    â€¢ Rotate tires. (See footnote +.)

137 500 km (82,500 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote +.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Rotate tires. (See footnote +.)

150 000 km (90,000 mi)

    â€¢ Change engine oil and filter (or every 12  months, whichever occurs first). This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote +.)
    â€¢ Inspect rear axle fluid level and add fluid as needed. Change axle fluid if the vehicle is driven in high-speed (above 40 mph or 70 km/h) conditions for extended periods of time.
    â€¢ Clean and repack the front wheel bearings (or at each brake relining, whichever occurs first).
    â€¢ Replace fuel filter. This is an Emission Control Service. (See footnote +.)
    â€¢ Inspect shields and underhood insulation for damage or looseness. Adjust or replace as required.
        This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.
    â€¢ Rotate tires. (See footnote +.)

162 500 km (97,500 mi)

    â€¢ Change engine oil and filter (or every 12 months, whichever occurs first).
        This is an Emission Control Service.
    â€¢ Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote #.)
    â€¢ Inspect rear axle fluid level and add fluid as needed.
    â€¢ Rotate tires.(See footnote +.)

166 000 km (100,000 mi)

    â€¢ Inspect spark plug wires.
        This is an Emission Control Service.
    â€¢ Replace spark plugs.
        This is an Emission Control Service.
    â€¢ Change automatic transmission fluid and filter.
        Manual transmission fluid does not require change.

240 000 km (150,000 mi)

    â€¢ Drain, flush and refill the cooling system (or every 60 months since the last service, whichever comes first).
    â€¢ Inspect the hoses.
    â€¢ Clean the following components:
       - The radiator
       - The pressure cap
       - The neck
    â€¢ Pressure test the cooling system and the pressure cap.
        This is an Emission Control Service.