GM Service Manual Online
For 1990-2009 cars only

2005 Chevrolet Equinox Intermittent P0481 and COOL FAN HI 25 Amp Fuse Is Open - kw CEL code coolant DTC GMT191 lamp light MIL relay short

Subject:2005 Chevrolet Equinox Intermittent P0481 and the COOL FAN HI 25 Amp Fuse Is Open

Models:.



The following diagnosis might be helpful if the vehicle exhibits the symptom described in the PI.

Condition/Concern:

Intermittent P0481 and the COOL FAN HI 25 Amp Fuse Is Open

Recommendation/Instructions:

The Cooling Fan S/P relay may have an internal short a and cause the COOL FAN HI 25 amp fuse to go open. Check the LOT code on the side of the Cooling Fan S/P Relay which is located at the left front corner of the engine compartment, below the left headlamp assembly, attached to the frame. If the lot code on the relay is 4075 A2 replace the Cooling Fan S/P Relay. This concern can sometimes be duplicated by shaking the Cooling Fan S/P relay or wiggling the connector to the relay.

.

Please follow this diagnosis process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed. If these steps do not resolve the condition, please contact GM TAC for further diagnostic assistance.

Models:

(05 Chevrolet Equinox)

.