General Motors Corporation warrants to the owner that the medium duty truck was designed, built, and equipped so as to conform at the time of sale with applicable regulations of the Federal Environmental Protection Agency (EPA), or to the California Air Resources Board, and is free from defects in materials and workmanship which cause the vehicle to fail to conform with those regulations during the warranty period.
| • | For heavy duty gasoline engines, the warranty period is 5 years or 50,000 miles, whichever comes first. |
| • | For heavy duty diesel engines, the warranty period is 5 years, or 100,000 miles, whichever comes first. |
Emission-related defects in the genuine GM components listed below, including related diagnostic costs, parts, and labor, are covered by this warranty.
The applicable warranty period shall begin on the date the vehicle is delivered to the first retail purchaser, or, if the vehicle is first placed in service as a demonstrator or company vehicle prior to sale at retail, on the date the vehicle is first placed in such service.
What is Covered
Listed below are most of the systems that affect emissions of your medium duty truck. Emission control components of these systems are covered by the emissions warranties as applicable. Maintenance items that require scheduled replacement are warranted up to the replacement interval specified in your Maintenance Schedule.
Powertrain Control System
ABS Control Module
Camshaft Position Actuator
Camshaft Position Actuator Valve
Coolant Level Sensor
Data Link Connector
Engine Control Module (ECM)
Engine Coolant Temperature Sensor
Fuel Control Module
Intake Air Temperature Sensor
Malfunction Indicator Lamp
Manifold Absolute Pressure Sensor
Mass Air Flow Sensor
Oil Pressure Sensor Active Fuel Management™ (AFM) only
Oxygen Sensor(s)
Powertrain Control Module (PCM)
Throttle Position Sensor
Vehicle Control Module (VCM)
Vehicle Speed Sensor
Wheel Speed Sensor
Transmission Controls and Torque Management
GMLAN (CAN) Communications Circuit
Manual Transmission Clutch Switch
Park//Neutral Switch
Torque Converter Clutch Solenoids
Torque Converter Clutch Switch
Transmission Control Module
Transmission Fluid Temperature Sensor
Transmission Gear Selection Switch (Diesel)
Transmission Internal Mode Switch
Transmission Pressure Control Solenoids
Transmission Pressure Switches
Transmission Shift Solenoids (7/70 Only Cobalt, G5, HHR)
Transmission Speed Sensor (Input)
Transmission Speed Sensor (Output)
Fuel Management System
Common Rail Assembly (6.6L DURAMAX® Diesel)
Diesel Fuel Injection Pump
Diesel Fuel Injector Control Module - EDU (6.6L DURAMAX® Diesel)
Direct Fuel Injector Assembly (6.6L DURAMAX® Diesel)
Fuel Injector
Fuel Pressure Regulator
Fuel Pressure Sensor
Fuel Rail Assembly
Fuel Temperature Sensor
Function Block (6.6L DURAMAX® Diesel)
High Pressure Fuel Pump (SIDI)
Air Management System
Air Cleaner
Air Cleaner Resonator
Air Intake Ducts
Charge Air Control Actuator
Charge Air Control Solenoid Valve
Charge Air Control Valve
Charge Air Cooler
Charge Air Cooler Fan
Idle Air Control Valve
Idle Speed Control Motor
Intake Air Heater
Intake Manifold
Intake Manifold Gasket (7/70 Only 6.6L DURAMAX® Diesel and Impala with 3.5L or 3.9L)
Intake Manifold Heater
Intake Manifold Tuning Valve
Supercharger Assembly
Throttle Body (Replacement Only)
Throttle Body Heater
Turbocharger Assembly
Turbocharger Boost Sensor
Turbocharger Oil Separator
Vacuum Pump (6.6L DURAMAX® Diesel)
Ignition System
Camshaft Position Sensor(s)
Crankshaft Position Sensor(s)
Glow Plug(s) (Diesel)
Glow Plug Controller (Diesel)
Ignition Coil(s)
Ignition Control Module
Knock Sensor
Spark Plug Wires
Spark Plugs
Catalytic Converter System
Catalytic Converter(s) and Muffler if attached as assembly
Diesel Exhaust Temperature and Pressure Sensors
Diesel Particulate Filter (DPF)
Exhaust Manifold (7/70 Only Corvette 7.0L Equinox and Torrent with 3.4L, DTS, STS and Lucerne with 4.6L, XLR, Impala and LaCrosse with 5.3L right bank)
Exhaust Manifold with Catalytic Converter attached as assembly
Exhaust Manifold Gasket
Exhaust Pipes and/or Mufflers (when located between catalytic converters and exhaust manifold)
Positive Crankcase Ventilation (PCV) System
Oil Filler Cap
PCV Filter
PCV Oil Separator
PCV Valve
Exhaust Gas Recirculation (EGR) System
EGR Feed and Delivery Pipes or Cast-in Passages
EGR Valve (7/70 Only Express and Savana with 6.6L DURAMAX® Diesel)
EGR Valve Cooler (6.6L DURAMAX® Diesel)
EGR Vacuum Pump Assembly (6.6L DURAMAX® Diesel)
Secondary Air Injection System
Air Pump
Check Valves
Evaporative Emission Control System (Gasoline Engines)
Canister
Canister Purge Solenoid Valve
Canister Vent Solenoid
Fuel Feed and Return Pipes and Hoses
Fuel Filler Cap
Fuel Level Sensor
Fuel Limiter Vent Valve
Fuel Tank(s)
Fuel Tank Filler Pipe (with restrictor)
Fuel Tank Vacuum or Pressure Sensor
Hybrid
Auxiliary Transmission Fluid Pump
Battery Cooling Fan
Battery Pack Control Module (BPCM)
Battery Pack Current Sensor
Brake Pedal Travel Sensor
Drive Motors A and B
Drive Motor A and B Resolvers
Drive Motor/Generator Control Module (DMCM - HCP, MCPA, MCPB)
Electro-Hydraulic Brake Control Module (EBCM)
Energy Storage Control Module
Fuel Filler Pipe Adapter Seal
Hybrid Batteries
Hybrid Battery Temperature Sensors
Hybrid Battery Voltage Sensors
SGCM Coolant Circuit (fan and fan relay and pump)
Starter Generator
Starter Generator Control Module (SGCM)
Transmission Friction Elements
Transmission Substrate Temperature Sensor
Miscellaneous Items Used with Above Components are Covered
Belts
Boots
Clamps
Connectors
Ducts
Fittings
Gaskets
Grommets
Hoses
Housings
Mounting Hardware
Pipes
Pulleys
Sealing Devices
Springs
Tubes
Wiring and Relays
Parts specified in your maintenance schedule that require scheduled replacement are covered up to their first replacement interval or the applicable emission warranty coverage period, whichever comes first. If failure of one of these parts results in failure of another part, both will be covered under the Emission Control System Warranty.
For detailed information concerning specific components covered by these emission control systems warranties, ask your GM dealer.
What is Not Covered
These warranty obligations do not apply to:
| • | conditions resulting from tampering, abuse, neglect or improper maintenance; or |
| • | any other item listed under "What is Not Covered" in the New Vehicle Limited warranty. See New Vehicle Limited Warranty . |
The "Other Terms" presented in the New Vehicle Limited warranty, also apply to these warranties.
General Motors of Canada Limited warrants to owners of Medium Duty Trucks and Chassis sold in Canada, that the engine (1) was designed, built and equipped so as to conform at the time of sale with the Emission Regulations under the Canadian Environmental Protection Act and (2) is free from defects in materials and workmanship which cause the vehicle to fail to conform with those regulations during the warranty period.
| • | For heavy duty gasoline engines, the warranty period is 5 years or 80 000 kilometres (whichever first occurs). |
| • | For heavy duty diesel engines, the warranty period is 5 years or 160 000 kilometres (whichever first occurs). |
Emission-related defects in the genuine GM components listed below including related diagnostic costs, parts, and labour are covered by this warranty. The applicable warranty period shall begin on the date the vehicle is delivered to the first retail purchaser, or, if the vehicle is first placed in service as a demonstrator or company vehicle prior to sale at retail, on the date the vehicle is first placed in such service.
Emission Performance
Some provinces and local jurisdictions have established periodic vehicle Inspection and Maintenance (I/M) programs to encourage proper maintenance of your vehicle. If a provincial I/M program is enforced in your area you may also be eligible for Emission Performance coverage when all of the following three conditions are met:
- the vehicle has been maintained and operated in accordance with the instructions for proper maintenance and use set forth in the Owner Manual, New Vehicle Warranty, or Maintenance Schedule supplied with your vehicle;
- the vehicle fails a provincial I/M test during the emission warranty period indicated above; and
- the failure results, or will result, in the owner of the vehicle having to bear a penalty or other sanctions (including the denial of the right to use the vehicle) under local, provincial, or federal law.
General Motors of Canada Limited warrants that your dealer will replace, repair, or adjust to GM specifications, at no charge to you, any of the parts listed under the "Emission Warranty Parts List" later in this section which may be necessary to conform to the applicable emission standards. Non-GM parts labeled "Certified to EPA Standards" are covered by the Federal Emission Performance Warranty.
Claims Procedure
Make your vehicle available to any authorized GM dealer as soon as possible after failing a provincial I/M test or at any time you suspect a defect in a part. If all the above conditions are met, GM warrants that your dealer will replace, repair, or adjust to GM specifications, at no charge to you, any of the parts listed under "Emission Control Systems Warranty Parts List" which may be necessary to cause your vehicle to conform to the applicable emission standards.
Repairs which do not qualify will be charged to you.
In the event a warranty matter is not handled to your satisfaction, refer to "Customer Satisfaction Procedure" in this booklet under Owner Assistance.
Emission Control Systems Warranty Parts List
Listed below are most of the systems that affect emissions of your engine. Emission control components of these systems are covered by the Emission Control Systems Warranty as applicable. Items that require replacement as scheduled maintenance are covered up to the replacement interval specified in your Maintenance Schedule booklet.
If failure of one of the above parts results in failure of another part under the Emission Control Systems Warranty, both will be covered by this warranty. For detailed information concerning specific parts covered by the Emission Control Systems Warranty, ask your dealer.
Powertrain Control System | |
|---|---|
ABS Control Module | Manifold Absolute Pressure Sensor |
Camshaft Position Actuator | Mass Air Flow Sensor |
Camshaft Position Actuator Valve | Oil Pressure Sensor Active Fuel Management™ (AFM) only |
Coolant Level Sensor | Oxygen Sensor(s) |
Data Link Connector | Powertrain Control Module (PCM) |
Engine Control Module (ECM) | Throttle Position Sensor |
Engine Coolant Temperature Sensor | Vehicle Control Module (VCM) |
Fuel Control Module | Vehicle Speed Sensor |
Intake Air Temperature Sensor | Wheel Speed Sensor |
Malfunction Indicator Lamp |
|
Fuel Management System | |
|---|---|
Common Rail Assembly (6.6L DURAMAX® Diesel) | Fuel Pressure Sensor |
Diesel Fuel Injection Pump | Fuel Rail Assembly |
Diesel Fuel Injector Control Module - EDU (6.6L DURAMAX® Diesel) | Fuel Temperature Sensor |
Direct Fuel Injector Assembly (6.6L DURAMAX® Diesel) | Function Block (6.6L DURAMAX® Diesel) |
Fuel Injector | High Pressure Fuel Pump (SIDI) |
Fuel Pressure Regulator |
|
Catalytic Converter System | |
|---|---|
Catalytic Converter(s) and muffler if attached as assembly | Exhaust Manifold with Catalytic Converter attached as assembly |
Diesel Exhaust Temperature and Pressure Sensors | Exhaust Manifold Gasket |
Diesel Particulate Filter (DPF) | Exhaust pipes and/or mufflers when located between converter and exhaust manifold |
Exhaust Manifold (7/70 only Corvette 7.0L, Equinox and Torrent w/3.4L, DTS, STS & Lucerne w/4.6L, XLR, Impala and Allure w/5.3L right bank) |
|
Transmission Controls and Torque Management | |
|---|---|
GMLAN (CAN) Communications Circuit | Transmission Gear Selection Switch (Diesel) |
Manual Transmission Clutch Switch | Transmission Internal Mode Switch |
Park/Neutral) Switch | Transmission Pressure Control Solenoids |
Torque Converter Clutch Solenoids | Transmission Pressure Switches |
Torque Converter Clutch Switch | Transmission Shift Solenoids (7/70 only Cobalt, G5, HHR) |
Transmission Control Module | Transmission Speed Sensor (Input) |
Transmission Fluid Temperature Sensor | Transmission Speed Sensor (Output) |
Air Management System | |
|---|---|
Air Cleaner | Intake Manifold |
Air Cleaner Resonator | Intake Manifold Gasket (7/70 only 6.6L DURAMAX® Diesel and Impala w/3.5L or 3.9L) |
Air Intake Ducts | Intake Manifold Heater |
Charge Air Control Actuator | Intake Manifold Tuning Valve |
Charge Air Control Solenoid Valve | Supercharger Assembly |
Charge Air Control Valve | Throttle Body (Replacement Only) |
Charge Air Cooler | Throttle Body Heater |
Charge Air Cooler Fan | Turbocharger Assembly |
Idle Air Control Valve | Turbocharger Boost Sensor |
Idle Speed Control Motor | Turbocharger Oil Separator |
Intake Air Heater | Vacuum Pump (6.6L DURAMAX® Diesel) |
Ignition System | |
|---|---|
Camshaft Position Sensor(s) | Ignition Control Module |
Crankshaft Position Sensor(s) | Knock Sensor |
Glow Plug(s) (Diesel) | Spark Plug Wires |
Glow Plug Controller (Diesel) | Spark Plugs |
Ignition Coil(s) |
|
Evaporative Emission Control System (Gasoline Engines) | |
|---|---|
Canister | Fuel Level Sensor |
Canister Purge Solenoid Valve | Fuel Limiter Vent Valve |
Canister Vent Solenoid | Fuel Tank(s) |
Fuel Feed and Return Pipes and Hoses | Fuel Tank Filler Pipe (with Restrictor) |
Fuel Filler Cap | Fuel Tank Vacuum or Pressure Sensor |
Positive Crankcase Ventilation (PCV) System | |
|---|---|
Oil Filler Cap | PCV Oil Separator |
PCV Filter | PCV Valve |
Exhaust Gas Recirculation (EGR) System | |
|---|---|
EGR Feed and Delivery Pipes or Cast-In Passages | EGR Valve Cooler (6.6L DURAMAX® Diesel) |
EGR Valve (7/70 Only Express and Savana with 6.6L DURAMAX® Diesel) | EGR Vacuum Pump Assembly (6.6L DURAMAX® Diesel) |
Secondary Air Injection System | |
|---|---|
Air Pump | Check Valves |
Hybrid | |
|---|---|
Auxiliary Transmission Fluid Pump | Fuel Filler Pipe Adapter Seal |
Battery Cooling Fan | Hybrid Batteries |
Battery Pack Control Module (BPCM) | Hybrid Battery Temperature Sensors |
Battery Pack Current Sensor | Hybrid Battery Voltage Sensors |
Brake Pedal Travel Sensor | SGCM Coolant Circuit (fan and fan relay and pump) |
Drive Motor/Generator Control Module (DMCM - HCP, MCPA, MCPB) | Starter Generator |
Drive Motors A and B | Starter Generator Control Module (SGCM) |
Drive Motor A and B Resolvers | Transmission Friction Elements |
Electro-Hydraulic Brake Control Module (EBCM) | Transmission Substrate Temperature Sensor |
Energy Storage Control Module |
|
Miscellaneous Items Used in Above Components are Covered | |
|---|---|
Belts | Housings |
Boots | Mounting Hardware |
Clamps | Pipes |
Connectors | Pulleys |
Ducts | Sealing Devices |
Fittings | Springs |
Gaskets | Tubes |
Grommets | Wiring and Relays |
Hoses |
|
What Is Not Covered
These Warranty Obligations Do Not Apply To:
| • | Conditions resulting from tampering, abuse, neglect or improper maintenance; or |
| • | Any other item listed under "What Is Not Covered" in the GM Medium Duty Truck Limited Warranty. |
| • | Parts specified in your maintenance schedule as requiring scheduled replacement are covered up to their first replacement interval or the applicable emission warranty coverage period, whichever comes first. There is no coverage under this warranty for the failure of parts which are not replaced as required. If failure of one of these parts results in failure of another part, both will not be covered under the Emission Control System Warranty. |
| For detailed information concerning specific parts covered by these emission control systems warranties, ask your dealer. |
THE "OTHER TERMS" PRESENTED IN THE GM MEDIUM DUTY TRUCK LIMITED WARRANTY ALSO APPLY TO THIS WARRANTY.
