Maintenance Schedule - Long Trip/Highway. Chevrolet Tahoe

For 1990-2009 cars only

Makes 🢒 Chevrolet 🢒 2001 🢒 Tahoe - 2WD 🢒 General Information 🢒 Maintenance and Lubrication 🢒 Maintenance Schedule - Long Trip/Highway

Long Trip/City Maintenance Schedule Intervals

The services shown in this schedule up to 160 000 km (100,000 mi) should be performed after 160 000 km (100,000 mi) at the same intervals. The services shown in this schedule to be performed at 240 000 km (150,000 mi) should be performed after 240 000 km (150,000 mi) at the same intervals.

For explanations of the maintenance inspections and services included in this Maintenance Schedule, refer to Explanation of Scheduled Services .

For additional maintenance inspections and services which are not included in this Maintenance Schedule, refer to Periodic Maintenance Inspection .

Footnotes

[Dagger] The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

# Lubricate the chassis components with each engine oil and filter change. Lubricate the front suspension, ball joints, steering linkage. transmission shift linkage, transfer case shift linkage, parking brake cable guides, and brake front axle. Ball joints should not be lubricated unless their temperature is -12°C (10°F) or higher, or they could be damaged.

+ A good time to check the brakes is during tire rotation. Refer to Brake System Inspection.

12 000 km (7,500 mi)

•	Change the engine oil and filter (or 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first).

•	Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

24 000 km (15,000 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first). #

•	Check the rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

•	Replace the passenger compartment air filter, if equipped.

•	Inspect the shields and underhood for damage or looseness. Adjust or replace as required.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•

Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damaged parts as necessary.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•	If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

36 000 km (22,500 mi)

•	Change engine oil and filter (or every 12 months, whichever occurs first).

•	Lubricate chassis components (or every 12 months, whichever occurs first). #

•	Check rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking

•	Rotate the tires. +

48 000 km (30,000 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first). #

•	Check the rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

•	Replace the passenger compartment air filter, if equipped.

•	Replace the fuel filter.

This is an Emission Control Service. [Dagger]

•	Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•	If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

60 000 km (37,500 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first). #

•	Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

72 000 km (45,000 miles)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first). #

•	Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

•	Replace the passenger compartment air filter, if equipped.

•	Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•

This is a Noise emission Control Service. Applicable only to vehicles sold in the United States.

•	If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.

This is a Noise Emission Control Service. Applicable to vehicles sold in the United States.

76 000 km (50,000 mi)

Change automatic transmission fluid and filter. Manual transmission fluid doesn't require change.

84 000 km (52,500 mi)

•	Change engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate chassis components (or every 12 months, whichever occurs first). #

•	Check rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

96 000 km (60,000 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate chassis components (or every 12 months, whichever occurs first). #

•	Check rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

•	Replace passenger compartment air filter, if equipped.

•	Inspect the engine accessory drive belt.

This is an Emission Control Service.

•	Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required.

This is a Noise Emission control Service. Applicable only to vehicles sold in the United States.

•	Check rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight.

Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damaged parts as necessary

This is a Noise Emission control Service. Applicable only to vehicles sold in the United States.

•	If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•	Replace the fuel filter.

This is an Emission Control Service. [Dagger]

108 000 km (67,500 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first). #

•	Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

120 000 km (75,000 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first). #

•	Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

•	Replace the passenger compartment air filter, if equipped.

•	Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•	Check the air intake system installation to assure that the gaskets are properly sealed and that all hose connections, fasteners and other components are tight.

Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. tighten connections and fasteners or replace damaged parts as necessary.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•	If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

132 000 km (82,500 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first). #

•	Lubricate the chassis components (or every 12 months, whichever occurs first).

•	Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

144 000 km (90,000 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first). #

•	Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

•	Replace passenger compartment air filter, if equipped.

•	Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•	Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight.

Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damage parts as necessary.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•	If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly.

This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States.

•	Replace the fuel filter.

This is an Emission Control Service. [Dagger]

156 000 km (97,500 mi)

•	Change the engine oil and filter (or every 12 months, whichever occurs first).

This is an Emission Control Service.

•	Lubricate the chassis components (or every 12 months, whichever occurs first). #

•	Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking.

•	Rotate the tires. +

160 000 km (100,000 mi)

•	Change the automatic transmission fluid and filter. Manual transmission fluid doesn't require change.

•	Automatic Transfer Case Only: Change the transfer case fluid.

240 000 km (150,000 mi)

•	Drain, flush and refill the cooling system (or every 60 months since the last service, whichever comes first).

•	Inspect the hoses.

•	Clean the following components.

-	The radiator

-	The condenser

-	The pressure cap

The neck

•	Pressure test the cooling system and the pressure cap.

This is an Emission Control Service.