Technical Service Bulletins

2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-23: Special Coverage Adjustment - Analog OnStar Deactivation (08089B)
2008-09-22: Information on OnStar Analog-Only Systems (06-08-64-007A)
2008-09-05: Information on Speedometer Accuracy (08-08-49-011B)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
2008-06-04: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-15: Revised Cylinder Head Bolt Torque Specification and Tightening Sequence (02-06-01-003B)
2008-04-08: Engine Oil or Coolant Leak (Install New Lower Intake Manifold Gasket) (03-06-01-010C)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-01-31: 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
2008-01-30: Remote Keyless Entry Operational Characteristics (99-08-52-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-04: Information on The Use of Bonded Valve Body Spacer Plate and Gaskets - keywords part shift (PIP4309)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-30: OnStar Unwanted or Phantom Phone Calls - keywords call handsfree intermittent mmute OnStar OPC performance phantomcalls unwanted (PIC3278C)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication digital failedtovoice information intermittent OnStar OPC operation no noconnect (PIC4310A)
2007-10-29: Revised General Motors New Vehicle Tire Warranty Program (00-03-10-003M)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-21: Information on 2-3 Upshift or 3-2 Downshift Clunk Noise (01-07-30-042E)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-20: Supplement To Campaign 01013 (Power Sliding Door) - keywords body lock open PIC4485 power psd side (PIC4485)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2006-12-22: Premature Aluminum Panel Hood Corrosion/Blistering (Refinish) (01-08-51-004E)
2006-12-13: Information on OnStar Analog-Only Systems (06-08-46-007)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-10: Info - Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-22: Info - Pitting and Brake Dust on Chrome Wheels (04-03-10-012A)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-12: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-08: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002D)
2006-05-30: GM Product Recall Campaign Follow Up Post Card (06-00-89-019A)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-17: Info - Instructions to be Followed to Aid in Obtaining Root cause Analysis on Both OEM and Goodwrench Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
2006-05-02: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-10: Info - Power Sliding Side Door Parts Restriction (06-08-64-018)
2006-04-06: Discontinuation of the Field Product Reminder Bulletin/Bulletin Subscription Information (06-00-89-018)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-29: Info - Vibration Analysis Worksheet (03-00-91-001C)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-02: Warranty Admin. - Labor Operation Assignments for All Control Module Reprogramming (02-06-04-057E)
2006-03-01: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
2006-02-17: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance (06-08-45-001)
2006-02-14: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004b)
2006-02-14: Info - Diagnostic Tips For Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036F)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-24: Info - Expediting Warranty Parts (99-00-89-021E)
2006-01-18: Info - New Product Feedback Form and Process for Automatic Transmission Core Returns (01-07-30-029A)
2006-01-12: 4T65-E Automatic Transmission Fluid Leak from Reverse Servo Cover (Replace Reverse Servo Cover Seal) (04-07-30-028A)
2006-01-04: Info - Maintenance Cleaning of Fuel Injectors (04-06-04-051B)
2005-12-22: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
2005-11-21: Info - Paint-less Dent Repair Process (99-08-51-001A)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-10-06: Info - Transmission Fluid Leak Diagnosis (01-07-30-041B)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-08-18: Info - Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
2005-08-17: Info - Release of GM Tool Organizaiton DVD Version 8.0 (J-43921-G) (05-00-89-056)
2005-08-10: Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inop I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
2005-08-05: Info - SPAC Case Escalation Process (05-00-89-050)
2005-08-04: Info - Brake Rotor Minimum Allowable Thickness After Refinish Specification Correction (04-05-23-002A)
2005-08-02: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case (05-04-21-004)
2005-07-27: Poor Heat with Cold Outside Temperatures at Low Engine RPM (Install Auxiliary Coolant Pump) (00-01-38-011C)
2005-07-12: DRL Disable - OFFICIAL GOVERNMENT VEHICLES ONLY - keywords daytime indicate lamp light module off running (PIC3136A)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-27: Warranty Admin. - Out-Of-Warranty Parts for Engineering Analysis (05-00-89-037)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-08: Info - On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
2005-06-03: Goodwrench Powertrain Wholesale Program (U.S. Only) (05-06-01-017)
2005-05-31: Power Door Lock Inoperative - keywords fob intermittent key leak lock RKE (PIC3571)
2005-05-24: Product Safety - Right Hand Power Sliding Door Interior Handle (04110)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-12: Info - Top Tether Hardware Package for Child Restraint Seats (99-09-40-004a)
2005-04-12: Info - OnStar System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-17: Info - GM Parts Ordering System (05-00-89-018)
2005-03-10: Info - Guidelines for Replacement of Transfer Case Control Module (TCCM) (05-04-21-002)
2005-03-08: Info - Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
2005-03-08: Info - OnStar Kit Part Numbers and Compatibility (99-08-46-001A)
2005-03-08: Information on Excessive Use of RTV Silicone Sealant on New Venture Gear (NVG) and Borg Warner Transfer Cases During Service (05-04-21-001)
2005-02-16: Battery Drain on Vehicles Equipped with Power Sliding Doors - keywords accessory electric failure ignition initialize module motor (PIC3042A)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-09: Info - Proper Air Bag System Diagnosis and Service (03-09-41-003A)
2005-02-09: Windnoise at Base of Windshield (Seal Sheet Metal Seams) (02-08-58-005B)
2005-01-31: Warranty Admin. - Guidelines for Claiming C0034 - Windshield Replacement (05-08-48-001)
2005-01-31: Excessive Lateral Movement of Some Aftermarket Child Seats (Replace Rear Seat Buckle) (00-09-40-001C)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-14: Info - OnStar Proactive Parts Shipment Process (02-08-46-013A)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2004-12-13: Info - Battery Specification Label (04-06-03-016)
2004-12-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022C)
2004-11-18: Info - Shipping Enhancements for Owners Manuals and Service Manuals Ordered from Helm, Inc. (04-00-89-057)
2004-11-18: Warranty Admin. - Warranty Return Parts (04-00-89-051)
2004-10-20: Info - Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
2004-10-11: Info - Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002A)
2004-10-08: Information on Error Codes on Radio Display - Their Cause and Corrective Action (01-08-44-005A)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-14: Info - Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (01-01-38-006D)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-03: Warranty Admin. - Dealer Installed Regular Production Options (RPO) and Regular Production Accessories (RPA) (01-00-89-015A)
2004-08-02: Info - Repair Procedure for Service Sheet Metal, Craters in ELPO Surface (04-08-98-002)
2004-07-27: Warranty Admin. - Changes to General Motors Vehicle Inquiry System (GMVIS) (04-00-89-029)
2004-07-23: Info - Application of Anti-Corrosion Materials (01-08-51-003A)
2004-07-02: Info - Battery Parasitic Drain (02-06-03-010A)
2004-06-22: Info - J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
2004-06-22: Info - New Owner Orientation Clinic Materials Now Available Online (03-00-89-002A)
2004-05-26: Info - Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
2004-05-10: No Start with DTC P1626 or P1631 - kw 2.8 3.5 4.2 4.8 5.3 6.0 8.1 crank fuel information stall theftdeterrent theft (PI02068)
2004-04-29: Information on Serpentine Belt Wear (04-06-01-013)
2004-04-22: Red OnStar LED , No Keypad Response When Pushed DTC B2476 - kw inoperative UE1 (PI02018)
2004-04-02: Water Leaks at Overhead Console Map - kw body dome door front lamp lightroof water window (PI01933A)
2004-03-29: Warranty Administration - Part and Accessory Replacement Policy (04-00-89-011)
2004-03-18: No TCC Apply , MIL On , TCC Surge , Possible P0740 , P1870 , or 39 after Installation of Reman ( SRTA ) 4T60 / 4T60E - kw case cover converter slip transmission (PI01880A)
2004-02-11: Info - 4L65-E, 4L60-E, 4L60 and 200-4R Automatic Transmission Oil Pump Spring First and Second Design Identification (04-07-30-006)
2004-02-05: Warranty Admin. - Dealer Disclosure Requirements (02-00-89-005A)
2004-01-05: Info - Correct Location When Servicing Right Side 2nd Row Seat Belt Upper Anchor Bolt (04-09-40-001)
2003-11-13: Second Row Seat Belt Will Not Retract: Passenger Side - kw actuator belt grab hard interior intermittent mount operation part rear release restraint seatbelt trim unwanted (PI01507)
2003-11-11: Info - Search Tips for Locating Preliminary Information (PI) Documents in Service Information (03-00-89-039)
2003-10-29: Info - Release of New Outer Tie Rod Ends for Service (03-02-32-049)
2003-10-29: Diagnostic Information to Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
2003-10-24: Engine Oil or Coolant Leak (Install New Intake Manifold Gasket) (03-06-01-010B)
2003-09-19: Warranty Admin. - Sublet Administrative Allowance (Coverage: S) Labor Operations (03-00-89-027)
2003-07-14: Info - J 44551 A/C Suction Screen Kit Repair Recommendations and Procedures After Catastrophic Compressor Failures (01-01-39-003A)
2003-07-14: Info - HomeLink Transceiver/Garage Door Opener Transmitter Test Kit Available As Essential Tool (01-08-97-001B)
2003-07-10: Water Puddles on Interior Swing-Out Glass Weatherstrips - air door floor gasket information intermittent leak panel seal water window (PI01233)
2003-06-30: Service VME - Under Body Noise - Fuel Tank Clunk or Slosh - Normal - accelerate boom bump knock intermittent rear suspension (PI01214)
2003-06-25: Info - Most Frequently Asked Questions and Answers for J 45096 TransFlow Transmission Oil Cooling System Flushing Machine (03-07-30-027)
2003-06-10: Service VME - Transflow Transmission Cooling System Service Tool J45096 Optional Heater Blanket - 3T40 372LE 3L30 3T40 4L30E 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60E 4T65E 4T80E 5L40E automatic fluid (PI01163)
2003-06-06: 4T65E PCS Wire Harness Is Stretched After Installing a Service Replacement Valve Body - automatic movement no noise part PQC shift slip transmission valve (PI01138)
2003-04-30: Product Safety - Power Steering Gear Lower Pinion Bearing Separation (02049)
2003-04-29: Warranty Admin. - Courtesy Transportation Program (02-00-89-004B)
2003-04-24: Info - Bulletins Released Week of April 14, 2003 and Car and Truck Fix It Right the First Time Issues (03-00-89-010)
2003-04-01: TCS Light Lit on IPC and DTC C1312 -- TCS Switch Bulb Open - ABS brake booster control EBTCM electrical light lens dim indicator off inoperative indicator part wire (PI00962A)
2003-03-14: Roof Perforation (Replace Roof) (02-08-67-006B)
2003-03-14: Info - Automatic Air Conditioning Control Operation (99-01-39-007B)
2003-03-07: Info - A/C Refrigerant System Sealer and A/C System Leak Detection Guidelines (03-01-38-001)
2003-03-07: Info - Changes to Essential and Available Tool Numbering System (03-00-89-005)
2003-02-27: Info - Powertrain Quality Center for Performance Parts Engine Replacements (03-06-01-006)
2003-02-04: Info - New Polymer Coated Piston and Rod Assembly (03-06-01-002)
2003-01-29: Info - Automatic Transmission Oil Cooler Flushing and Flow Check Procedures (99-07-30-017A)
2002-12-16: Adm Msg - New Labor Time Guide Available Effective February 1, 2003 (WIW20020026)
2002-11-13: Upcoming Safety Recall Power Steering Gear Lower Pinion Bearing Separation (wia20020074)
2002-10-25: Proper Diagnostic Procedures for No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, SIR, Brake, Security, Theft, ABS, Hot, DIC Messages, Lamp, Light, Battery and Generator Diag. Testing (02-06-03-012)
2002-09-23: Adm Msg - Important Programming/TIS Information for Technicians (Admin Number 20020120 - 9/10/02) (VSS20020120)
2002-08-09: Info - Engine Crankcase Flush (02-06-01-028)
2002-07-24: Warranty Admin. - Claim Procedures for Warrantable Electronic Failures on Vehicles Sold As Certified Used Vehicles or Certified Pre-Owned Vehicles (02-00-89-013)
2002-07-19: Warranty Admin. - Revised Empowerment Level-Authorization Code E (02-00-89-009)
2002-07-19: Info - Preliminary Information (PI) Text Available in Service Information (SI) (02-00-89-008)
2002-07-09: SMU-Revised DTC P0101 (02-06-04-040)
2002-06-21: Info - Expandable Acoustic Foam (Two Component Sound Dampener) Usage with Collision Damage Repairs (02-08-98-003)
2002-06-13: Info - Automatic Transmission Serial Number and Site Code Locations (02-07-30-028)
2002-06-13: Info - Engine Identification Information (02-06-01-026)
2002-06-11: Road Noise Heard Behind Front Seats (Seal Sheet Metal Seams) (02-08-58-003)
2002-05-01: Power Sliding Door Reverses on Closing (Replace Plunger and Contact Plate Using Kit, Replace Door Module and Latch, if Applicable) (02-08-64-011)
2002-04-11: SMU - Revised Lower Intake Manifold Installation (02-06-01-014)
2002-02-27: Information on a New Engine Preluber Tool (02-06-01-008)
2002-01-15: Product Safety Recall- Power Sliding Door (01013)
2001-12-18: Info - Tire Sidewall Damage (01-03-10-011)
2001-11-14: Info - Test Guidelines for Use of Essential Tool J41413-200 Evaporative System Tester (01-06-04-044)
2001-11-05: General Waterleak Diagnosis Guide (01-08-57-006)
2001-10-19: Product Safety - Power Sliding Door (01059)
2001-10-19: Info - 2-Cut vs. 5-Cut Rear Axle Ring and Pinion Gearsets (00-04-20-001A)
2001-10-11: Info - Proper Use of HVAC System to Achieve Maximum Cooling (01-01-38-011)
2001-10-04: Info - Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
2001-09-25: Information on Lowering Spare Tires Stored Under Vehicle (01-03-10-007)
2001-09-17: Warranty Admin. - Correct Use of Labor Operation R4490, RKE Transmitter, Replace (01-00-89-013)
2001-09-13: SMU - Side Impact Air Bag Inflator Module Replacement (01-09-41-008)
2001-08-29: Customer Satisfaction - Power Sliding Door Operation (99016A)
2001-08-24: Driveability Symptoms Due to Clogged Fuel Injectors (Clean Injectors) (99-06-04-005B)
2001-08-02: SMU - Revised Excessive Wheel Speed Variation DTC Tables (C1225, C1226, C1227, C1228) (01-05-25-006)
2001-06-21: Info - Seat Belt System Replacement Guidelines for Vehicles Involved in Collisions (01-09-40-002)
2001-05-24: SMU - Revised Fasten Requirements for Front and Rear Brake Caliper Bracket Replacement (01-05-23-006A)
2001-05-08: Info - Replacement of Keys, Key Numbers and/or Security Chips (01-00-89-009)
2001-04-09: Info - Guidelines for Use of Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
2001-04-06: Info - Current CIPS Campaign Number to Previous DIvisional Campaign Number (01-00-89-008)
2001-04-06: Info - New Frame Insulator Remover/Installer Available (01-08-61-003)
2001-03-05: SMU - Revised Tool Requirements for Front and Rear Brake Caliper Overhaul (01-05-23-003)
2001-03-02: Info - February, 2001 Bulletin Summary (01-00-89-006)
2001-02-27: Exchange Program - Video Entertainment System (99-08-44-001B)
2001-02-08: Power Sliding Door Edge Guard Comes Loose (Install New Edge Guard) (00-08-64-015A)
2001-02-02: Info - January, 2001 Bulletin Summary (01-00-89-005)
2001-01-03: Info - December, 2000 Bulletin Summary (01-00-89-001)
2000-12-18: Warranty Admin. - January 1, 2001 Labor Time Guide Updates (00-00-89-031)
2000-12-04: Info - November, 2000 Bulletin Summary (00-00-89-030)
2000-11-13: Warranty Admin. - December, 2000 Labor TIme Guide Updates (00-00-89-029)
2000-11-02: Info - October. 2000 Bulletin Summary (00-00-89-028)
2000-10-24: Info - The Importance of Chassis Lubrication (00-00-90-001)
2000-10-17: Warranty Admin. - November, 2000 Labor Time Guide Updates (00-00-89-025)
2000-10-06: Info - September, 2000 Bulletin Summary (00-00-89-024)
2000-09-21: Info - Correct Diagnostic Procedure When Reviewing A/C Performance/Leak Suspected (00-01-38-007)
2000-09-19: Warranty Admin. - October, 2000 Labor Time Guide Updates (00-00-89-023)
2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
2000-08-28: Special Policy Adjustment - Spare Tire Hoist Performance-Severe Corrosion Areas (00007)
2000-08-25: Outside Rear View Mirror Housing Turns Chalky/Dull (Color/Clear Coat Mirror) (00-08-51-001)
2000-08-17: Warranty Admin. - Cross-line Warranty (00-00-89-021)
2000-08-14: Warranty Admin. - September, 2000 Labor Time Guide Updates (00-00-89-020)
2000-08-10: Warranty Admin. - New Electrical Relay Labor Operation Numbers (00-00-89-019)
2000-08-08: Info - July, 2000 Bulletin Summary (00-00-89-018)
2000-08-03: Info - Essential Tool J 43600 ACR 2000 (00-01-38-006)
2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
2000-06-19: Warranty Admin. - July, 2000 Labor Time Guide Updates (00-00-89-014)
2000-06-19: Warranty Admin.- PCM Product Feedback Program (00-06-04-026)
2000-06-08: Info - California Consent Order on Settlement of Lawsuit on Batteries (Prop 65) (00-06-03-006)
2000-06-06: Info - May, 2000 Bulletin Summary (00-00-89-013)
2000-05-30: Tech - Slow/Non-Moving Glass, Bent Regulator Arm or Window is Inope (00-08-64-007)
2000-05-30: Info - Headlamp Capsule Availability (00-08-42-003)
2000-05-15: Info - Proper Service of Quick Connect EVAP System Connectors (00-06-04-021)
2000-05-12: Warranty Admin. - June, 2000 Labor TIme Guide Updates (00-00-89-012)
2000-05-08: Info - Brake Fluid Level and Filling Recommendations (00-05-22-004)
2000-05-03: Info - April, 2000 Bulletin Summary (00-00-89-011)
2000-05-03: Brown, Gel-Like Substance on Rad. Cap/Upper Filler Neck (Replace Cap/Clean Neck) (00-06-02-004)
2000-04-14: Warranty Admin. - May, 2000 Labor Time Guide Updates (00-00-89-010)
2000-04-04: Info - March, 2000 Bulletin Summary (00-00-89-007)
2000-02-23: Informational - January, 2000 Bulletin Summary (00-00-89-003)
2000-02-11: Warranty Admin. - March, 2000 Labor Time Guide Updates (00-00-89-002)
2000-01-19: HVAC Lack of Performance/Single A/C System Only (Evacuate/Recharge A/C System) (00-01-38-001)
2000-01-19: February, 2000 Labor Time Guide Updates (00-00-89-001)
2000-01-13: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
2000-01-04: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (99-09-41-004)
1999-12-10: Warranty Admin. - January, 2000 Labor Time Guide Updates (99-00-89-023)
1999-12-06: Info - The Year 2000 (Y2K) and Vehicle Electronics (99-00-89-022)
1999-11-08: Accessory Receptacle is Inoperative (Check Aftermarket Device Plug) (99-08-45-005)
1999-10-26: Info - PCM Reprogramming (99-06-04-053)
1999-10-22: Informational - CS-144 Generator Replacement (99-06-03-011)
1999-10-20: Info - Radiator Repair/Replacement Guidelines (99-06-02-017)
1999-10-14: November, 1999 Labor Time Guide Updates (99-00-89-020)
1999-10-11: Info - New Solenoid Testing Kit for Hydra-Matic Transmissions (99-07-30-021)
1999-10-08: Warranty Administration - October, 1999 Labor Time Guide Updates (99-00-89-017)
1999-10-08: Info - Discontinue Usage of Tool J 6627A for Wheel Stud Removal (99-03-10-103)
1999-10-06: Info - Cassette Player Cleaning and Maintenance (99-08-44-008)
1999-09-10: Technical - Upper Roller Bracket Rattle (Install Bumper) (99-08-64-017)
1999-09-02: Tech - On Board Diagnostic (OBD) System Improvements (Reprogram PCM) (99-06-04-037)
1999-08-16: MIL Lamp Illuminates with No Driveability Concerns, DTC P0172 (Reprogram PCM) (99-06-04-031)
1999-08-10: Warranty Admin - September, 1999 Labor Time Guide Updates (99-00-89-016)
1999-07-29: Info - Compact Disc (CD) Players and Compatible CDs (99-08-44-006)
1999-07-28: Warranty Admin - August, 1999 Labor Time Guide Updates (99-00-89-012)
1999-06-25: Warranty Admin - July 1999 Labor Time Guide Updates (99-00-89-010)
1999-05-25: Information - Original Equipment Chrome Plated Aluminum Wheel Identification (99-03-10-102)
1999-05-19: June 1999 Labor Time Guide Updates (99-00-89-008)
1999-04-20: Warranty Admin. - May, 1999 Labor Time Guide Update (99-00-89-006)
1999-04-20: Info-Front Disc Brake Pads (Shoe/Lining Assem) Interim Design Change for Brakes (99-05-23-004)
1999-04-06: Labor Time Guide Updates - April 1999 (99-00-89-004)
1999-04-01: Info - 1998 Bill 101 French Label Installation Instructions (99-00-89-005)
1999-03-31: Info - Cleaning of Upper Instrument Panel Surfac (99-08-49-006)
1999-03-09: Labor Time Guide Updates (99-00-89-003)
1999-03-04: Battery Insulator Replacement (99-06-03-002)
1999-03-02: Info - Instrument Cluster Identification (99-08-49-002)
1999-02-26: Essential Tool J 42000 Battery Tester (99-06-03-001)
1999-02-24: Poor Rear Washer Performance (Replace Washer Nozzle) (99-08-43-001)
1999-02-19: Warranty Parts Center/Corporate Parts Return Program (40-05-01C)
1999-02-19: 1-2 Accumulator Piston and Outer Spring Replacement (87-74-74)
1999-02-16: Warranty Administration - Labor Time Updates (99-00-89-001)
1998-11-24: INOP. POWER SLIDING SIDE DOOR GEN II ONLY (83-15-25)
1998-11-16: INFO - ESSENTIAL TOOL J43435 ADJUSTER LOCKNUT (83-32-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-10-20: INFO - ESSENTIAL TOOL J43485 POWER STEERING BLEEDER ADAPTER (83-32-09)
1998-10-20: INFO - IMPROVED PERFORMANCE OF VARIOUS ELECTRICAL DEVICES (83-90-15)
1998-10-09: DOOR HANDLES ON WHITE PAINTED VEHICLES TURNING YELLOW (83-17-04)
1998-10-08: WARRANTY ADMIN - LTG UPDATES (83-05-09)
1998-10-07: INFO - ALIGNMENT SPECIFICATIONS (83-31-09)
1998-10-01: INFO - NEW WINDSHIELD AND STATIONATY GLASS URETHANE (83-15-16)
1998-09-29: INFO ON RECOMMENDED AXLE LUBRICANT (76-02-02A)
1998-09-17: WARRANTY ADMIN. - LTG UPDATES (83-05-08)
1998-09-16: INFO - NEW PCM CONNECTOR SERVICE KITS (83-81-32)
1998-09-16: SMU - SEC. 0B - CORRECTED CRANKCASE VENTILATION SYSTEM (83-02-01)
1998-08-21: WARRANTY ADMIN - LTG UPDATES (83-05-07)
1998-08-21: A/C SYSTEM MOAN NOISE (REPLACE A/C HOSE ASSEMBLY) (83-12-20)
1998-08-20: INFO - ESSENTIAL TOOL J-43241 REMOTE KEYLESS ENTRY AND (83-90-12)
1998-08-17: CAMPAIGN: VOLUNTARY EMISSION RECALL CAMP.RELOC. OF EVAP (98008B)
1998-08-17: CAMPAIGN:PROTECTIVE COVERS - REAR LATCH MECHANISM (98034)
1998-08-14: INFO - CORRECT LABOR CODE USAGE FOR ENTERTAINMENT SYS. (84-96-01)
1998-08-12: WARRANTY ADMIN. - REDEFINED USE OF PARTS WARRANTY SPECIAL (80-05-03)
1998-08-04: SMU-SEC.3C-REVISED FRONT STRUT COMPONENET (83-33-02A)
1998-07-15: WARRANTY ADMIN. - LTG UPDATES (83-05-06)
1998-06-30: CAMPAIGN:SHIFT CABLE RETAINING TABS BREAKING (98023)
1998-06-26: FUEL TANK THUD/CLUNK NOISE (INSTALL NEW FUEL TANK STRAPS (83-63-16)
1998-06-11: COLD ENGINE TICK OR RATTLE AFTER AFTER START-UP (57-61-24A)
1998-06-11: WARRANTY ADMIN. - LTG UPDATES (83-05-05)
1998-06-09: NO START, ENGINE MISS, ROUGH IDLE, MIL MAY ILLUMINATE (87-63-06)
1998-06-08: ENG. OIL ODOR (REPLACE REAR MAIN BEARING SEAL) (87-60-02A)
1998-06-03: INFO - NEW TOOL J-42958, REV. CHARTS AND SCHEM. FOR CRUISE (83-90-08)
1998-05-22: INFO - 1998-99 DELCO RADIO EXCHANGE REFERENCE (83-96-04)
1998-05-18: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-04)
1998-05-04: WINDSHIELD WIPER LINK INTERFERENCE WITH TRACTION (98014)
1998-04-24: GENERAL MOTORS WARRANTY INQUIRY SYSTEM (82-05-05)
1998-04-21: WARRANTY ADMIN - REQ. FOR WHOLESALE AUTH. OR WARRANTY (82-05-02)
1998-04-21: WARRANTY ADMIN - ELIMINATION OF LABOR OPS ZZ920 & Z7930 (82-05-03)
1998-04-16: WARRANTY ADMIN. - LTG UPDATES (83-05-03)
1998-04-16: INFORMATION - 1998-99 GM SOUND SELLING RADIO PROGRAM (83-96-03)
1998-04-02: INFO. USE OF'SURFACE CONDITIONING DISCS' (87-61-24)
1998-03-24: WINDSHIELD WIPER BLADE CHATTER (REP. WIPER ARM (83-82-05)
1998-03-16: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-02)
1998-03-10: INFO. NEW TOOL J-41450-B RELEASED FOR CS GEN DIAG. (83-64-09)
1998-03-04: INSUFFICIENT WINDSHIELD CLEARING IN THE DEFROST MODE (83-11-12)
1998-03-02: INFO - FUEL LEVEL SENSOR REPLACEMENT PROC (83-83-07)
1998-02-25: INFO - INSTRUMENT CLUSTER ID. (83-83-09)
1998-02-20: WARRANTY ADMIN - LABOR TIME GUIDE UPDATES (83-05-01)
1998-02-18: TEXT CHANGES IN 'UNIFORM' TIRE QUALITY GRADING (86-35-04)
1998-02-18: HIGH EFFORT REQUIRED TO SOUND HORN(REPL. STEERING WHEEL (83-82-04)
1998-02-16: DRIVEABILITY SYMPTOMS DUE TO FUEL INJECTOR DEPOSITS (77-63-04A)
1998-02-13: INFO. ON VIN PLATE REPLACEMENT (83-01-14)
1998-02-03: SMU - SEC. 5 - ABS - REV. SCHEM. & DIAG. CHART (73-50-35)
1998-01-27: SMU - SEC. 8A-133 - THEFT DETERENT SYSTEM (83-81-21)
1998-01-27: SMU - SEC. 8A-51 - BODY CONT. MOD. - REV. DIAG. (83-81-22)
1998-01-23: AM BAND RADIO INTERFERENCE WITH WINDSHIELD WIPERS OPER. (83-96-01)
1998-01-14: INFO. - DIAG PROC. WHEN A/C DIAG INFO LEAK (73-12-12A)
1998-01-12: INFO. FRONT. SUPP. INFLAT. RESTRAINTS (SIR) ON-OFF SWITCH (73-90-23)
1998-01-07: SMU-SEC. 9J - SIR REV. DTC B1041 CHART (73-90-20)
1997-12-18: WARRANTY ADMIN. - REPAIR/ REPLACE POLICIES & PROC. (72-05-13)
1997-12-18: WARRANTY ADMIN. - ENHANCED SUBLET REPAIR POLICY (72-05-14)
1997-12-16: WARR. ADMIN - LABOR TIME GUIDE UPDATES (73-05-09)
1997-11-28: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (73-05-07)
1997-11-26: INFO. ON TECHNICAL ASSISTANCE CALL PREPARATION (73-01-10)
1997-11-20: CLARIFICATION OF RAIL DUST REM (A5575-A5580) (72-05-11)
1997-11-20: SMU-SEC. 10-FRAME & UNDERBODY NEW DIMENSION TABLES & ARTWORK (73-10-71)
1997-11-12: LOOSE LUMBER NOISE FROM REAR OF VEHICLE (73-34-06)
1997-11-12: INFORMATION - PUREGUARD 2 OPERATING ALERT (73-12-13)
1997-11-06: SMU-SEC.9J - SIR - REVISED FASTEN. TIGHT. SPEC. FOR SIDE (73-90-21)
1997-11-01: WARRANTY ADMIN. - LABOR OPERATION CODE Z1241 (62-05-02A)
1997-10-24: WARR. ADMIN-LTG UPDATES 1989-98 PASS. CAR & TRUCK (73-05-06)
1997-10-23: WARRANTY ADMIN: 1998 G.S.A. FUEL EXPL FUEL PRICE CHANGE (72-05-10)
1997-10-10: INFO. BALANCING ALUMINUM WHEELS (73-35-05)
1997-09-25: INFO - DIAG. HINTS FOR 'ROLLING CODE' REMOTE FUNC. (73-90-18)
1997-09-12: LOSS OF OWNER CUSTOMER SETTINGS (73-90-17)
1997-09-11: WARRANTY: TIRE REPLACEMENT DURING BUMPER TO BUMPER (70-05-01)
1997-08-21: WARRANTY ADMIN - GUIDELINES FOR USING E0420 WHEEL (72-05-05)
1997-08-21: WARRANTY ADMIN- GUIDELINES FOR USING I/M 240 LABOR OP (72-05-06)
1997-08-12: WARRRANTY ADMIN - LABOR TIME GUIDE UPDATES (73-05-05)