Short Trip/City Maintenance Schedule Intervals
The services shown in this schedule up to 166 000 km (100,000 mi) should be performed after 166 000 km (100,000 mi) at the same intervals. The services shown in this schedule to be performed at 240 000 km (150,000 mi) should be performed after 240 000 km (150,000 mi) at the same intervals.
For explanations of the maintenance inspections and services included in this Maintenance Schedule, refer to
Explanation of Scheduled Services
.
For additional maintenance inspections and services which are not included in this Maintenance Schedule, refer to
Periodic Maintenance Inspection
.
Footnotes
[Dagger] The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.
# Lubricate the chassis components with each engine oil and filter change. Lubricate the front suspension, ball joints, steering linkage. transmission shift linkage, transfer case shift linkage, parking brake cable guides, and brake front axle. Ball joints should not be lubricated unless their temperature is -12°C (10°F) or higher, or they could be damaged.
+ A good time to check the brakes is during tire rotation. Refer to Brake System Inspection.
5 000 km (8,000 mi)
| • | Change the engine oil and filter (or 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
16 000 km (10,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is An emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
24 000 km (15,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. |
| • | Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damaged parts as necessary. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
32 000 km (20,000 mi)
| • | Change engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. |
| • | Replace passenger compartment air filter, if equipped. |
40 000 km (25,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). |
| • | Check rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. |
| • | Replace fuel filler cap if driving in dusty conditions. |
| | This is an Emission Control Service. |
| • | Allison Transmission Only: Change automatic transmission fluid and filters if this vehicle is mainly driven under one of these conditions: |
| - | In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher |
| - | In hilly or mountainous terrain |
| - | When doing frequent trailer towing |
| - | Uses such as found in taxi, police or delivery service |
If the vehicle is not used under any of these conditions, change the fluid and filter every 80 000 km (50,000 mi)
48 000 km (30,000 mi)
| • | Change engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. |
| • | Replace passenger compartment air filter, if equipped. |
| • | Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damaged parts as necessary. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | Replace the fuel filter. |
| | This is an Emission Control Service. [Dagger] |
56 000 km (35,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. |
64 000 km (40,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
72 000 km (45,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
| • | Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. Tighten connections and fasteners or replace damaged parts as necessary. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
80 000 km (50,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. check the constant velocity joints and axle seals for leaking. |
| • | Replace the fuel fill cap if driving in dusty conditions. |
| | This is an Emission Control Service. |
| • | Change the automatic transmission fluid and filter. Manual transmission fluid does not require change. |
88 000 km (55,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
96 000 km (60,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
| • | Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. tighten connections and fasteners or replace damaged parts as necessary. |
| | This is a Noise emission Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable to vehicles sold in the United States. |
| • | Replace the fuel filter. |
| | This is an Emission Control Service. [Dagger] |
| • | Inspect the engine accessory drive belt. |
| | This is an Emission Control Service. |
104 000 km (65,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 3 months, whichever occurs first). # |
| • | Check rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. |
112 000 km (70,000 mi)
| • | Change engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 3 months, whichever occurs first). # |
| • | Check rear/front axle fluid level and add fluid as needed. Check constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
120 000 km (75,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
| • | Replace the fuel filler cap if driving in dusty conditions. |
| | This is an Emission Control Service. |
| • | Allison Transmission Only: Change automatic transmission fluid and filters if this vehicle is mainly driven under one of these condition: |
| - | In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher. |
| - | In hilly or mountainous terrain. |
| - | When doing frequent trailer towing. |
| - | Uses such as found in taxi, police or delivery service. |
128 000 km (80,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
136 000 km (85,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 3 months, whichever occurs first). # |
| • | Check rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
144 000 km (90,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
| • | Inspect the shields and underhood insulation for damage or looseness. Adjust or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets are properly sealed and that all hose connections, fasteners and other components are tight. Also check to be sure that the air cleaner housing is properly seated and the cover fits tightly. tighten connections and fasteners or replace damaged parts as necessary. |
| | This is a Noise emission Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable to vehicles sold in the United States. |
| • | Replace the fuel filter. |
| | This is an Emission Control Service. [Dagger] |
152 000 km (95,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first), # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
160 000 km (100,000 mi)
| • | Change the engine oil and filter (or every 3 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components (or every 3 months, whichever occurs first). # |
| • | Check the rear/front axle fluid level and add fluid as needed. Check the constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
| • | Replace the fuel filler cap if driving in dusty conditions. |
| | This is an Emission Control Service. |
| • | Change automatic transmission fluid and filter. Manual transmission fluid does not require change. |
240 000 km (150,000 mi)
| • | Drain, flush and refill the cooling system (or every 60 months since the last service, whichever comes first). |
| • | Clean the following components: |
| • | Pressure test the cooling system and the pressure cap. |
| | This is an Emission Control Service. |
