Maintenance Schedule Gasoline
Long Trip/Highway Scheduled Maintenance (Gasoline)
The services shown in this schedule up to 166 000 km (100,000 mi)
should be performed after 166 000 km (100,000 mi) at the same
intervals. The Services shown at 240 000 km (150,000 mi) should
be performed at the same interval after 240 000 km (150,000 mi).
Footnotes
@ The U.S. Environmental Protection Agency or the California Air Resources Board
has determined that the failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the completion of the vehicle's
useful life. We, however, urge that all recommended maintenance services be performed
at the indicated intervals and the maintenance be recorded.
# Lubricate the front suspension, kingpin bushings, steering linkage, transmission
shift linkage, transfer case shift linkage, park brake cable guides, rear driveline
center splines, front axle propshaft spline and brake pedal springs. Ball joints and
kingpin bushings should not be lubricated unless their temperature is -12°C (10°F)
or higher, or they could be damaged.
+ A good time to inspect the brakes is during tire rotation.
12 500 km (7,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
25 000 km (15,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Rotate tires. (See footnote +.) |
37 500 km (22,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first).
This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
50 000 km (30,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. Change axle fluid
if the vehicle is driven in high-speed (above 40 mph or 70 km/h) conditions for extended
peiods of time. |
| • | Clean and repack the front wheel bearings (or at each brake relining,
whichever occurs first). |
| • | Rotate tires. (See footnote +.) |
| | This is an Emission Control Service. (See footnote @.) |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
62 500 km (37,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first).
This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote+.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
75 000 km (45,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first).
This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote +.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Rotate tires. (See footnote +.) |
83 000 km (50,000 mi)
Change automatic transmission fluid and filter.
Manual transmission fluid does not require change.
87 500 km (52,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first).
This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote +.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
100 000 km (60,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first).
This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote +.) |
| • | Inspect rear axle fluid level and add fluid as needed. Change axle fluid
if the vehicle is driven in high-speed (above 40 mph or 70 km/h) conditions for extended
periods of time. |
| • | Clean and repack the front wheel bearings (or at each brake relining,
whichever occurs first). |
| • | Rotate tires. (See footnote +.) |
| • | Inspect engine accessory drive belt. |
| | This is an Emission Control Service. |
| | This is an Emission Control Service. (See footnote @.) |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Inspect Evaporative Control system. Inspect all fuel and vapor lines and
hoses for proper hook-up, routing and condition. Inspect that the purge valve works
properly, if equipped. Replace as needed. |
| | This is an Emission Control Service. (See footnote @.) |
112 500 km (67,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first).
This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote +.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
125 000 km (75,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first).
This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote +.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Rotate tires. (See footnote +.) |
137 500 km (82,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first).
This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote +.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
150 000 km (90,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote +.) |
| • | Inspect rear axle fluid level and add fluid as needed. Change axle fluid
if the vehicle is driven in high-speed (above 40 mph or 70 km/h) conditions for extended
periods of time. |
| • | Clean and repack the front wheel bearings (or at each brake relining,
whichever occurs first). |
| • | Replace fuel filter. This is an Emission Control Service. (See footnote
+.) |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Rotate tires. (See footnote +.) |
162 500 km (97,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires.(See footnote +.) |
166 000 km (100,000 mi)
| • | Inspect spark plug wires. |
| | This is an Emission Control Service. |
| | This is an Emission Control Service. |
| • | Change automatic transmission fluid and filter. |
| | Manual transmission fluid does not require change. |
240 000 km (150,000 mi)
| • | Drain, flush and refill the cooling system (or every 60 months since the
last service, whichever comes first). |
| • | Clean the following components: |
| • | Pressure test the cooling system and the pressure cap. |
| | This is an Emission Control Service. |
Maintenance Schedule Diesel
Long Trip/Highway Scheduled Maintenance (Diesel)
The services shown in this schedule up to 166 000 km (100,000 mi)
should be performed after 166 000 km (100,000 mi) at the same
intervals. The Services shown at 240 000 km (150,000 mi) should
be performed at the same interval after 240 000 km (150,000 mi).
Footnotes
@ The U.S. Environmental Protection Agency or the California Air Resources Board
has determined that the failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the completion of the vehicle's
useful life. We, however, urge that all recommended maintenance services be performed
at the indicated intervals and the maintenance be recorded.
# Lubricate the front suspension, kingpin bushings, steering linkage, transmission
linkage, park brake cable guides, rear driveline center splines and brake pedal springs.
Additionally, for four - wheel - drive vehicles, lubricate the transfer case shift
linkage and the front axle propshaft spline. Ball joints and kingpin bushings should
not be lubricated unless their temperature is - 12°C (10°F) or higher,
or they could be damaged.
+ A good time to inspect the brakes is during tire rotation.
12 500 km (7,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
25 000 km (15,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. This is a Noise Emission Control Service. Applicable only
to vehicles sold in the United States. |
| • | Rotate tires. (See footnote +.) |
| • | Inspect the air intake system installation to assure that gaskets are
properly sealed and that all hose connections, fasteners and other components are
tight. Also inspect to be sure that the air cleaner housing is properly seated and
the cover fits tightly. Tighten connections and fasteners or replace damaged parts
as necessary. This is a Noise Emission Control Service. Applicable only to vehicles
sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all
hoses and ducts for proper hook-up (or every 12 months, whichever occurs first).
Be sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
37 500 km (22,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
50 000 km (30,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. Change axle fluid
if the vehicle is driven in high-speed (above 70km/h or 40 mph) conditions for extended
periods of time. |
| • | Clean and repack the front wheel bearings (or at each brake relining,
whichever occurs first). |
| • | Rotate tires. (See footnote +.) |
| | This is an Emission Control Service. (See footnote @.) |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Inspect the air intake system installation to assure that gaskets are
properly sealed and that all hose connections, fasteners and other components are
tight. Also inspect to be sure that the air cleaner housing is properly seated and
the cover fits tightly. Tighten connections and fasteners or replace damaged parts
as necessary. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all
hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be
sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
62 500 km (37,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
75 000 km (45,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Rotate tires. (See footnote +.) |
| • | Inspect the air intake system installation to assure that gaskets are
properly sealed and that all hose connections, fasteners and other components are
tight. Also inspect to be sure that the air cleaner housing is properly seated and
the cover fits tightly. Tighten connections and fasteners or replace damaged parts
as necessary. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all
hoses and ducts for proper hook-up (or every 12 months, whichever occurs first).
Be sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
83 000 km (50,000 mi)
Change Automatic Transmission Fluid and Filter.
Manual Transmission fluid does not require change.
87 500 km (52,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear/front axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
100 000 km (60,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. Change axle fluid
if the vehicle is driven in high-speed (above 70 km/h or 40 mph) conditions for extended
periods of time. |
| • | Clean and repack the front wheel bearings (or at each brake relining,
whichever occurs first). |
| • | Rotate tires. (See footnote +.) |
| • | Inspect engine accessory drive belt. |
| | This is an Emission Control Service. |
| • | Replace the fuel filter. |
| | This is an Emission Control Service (See footnote @.) |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Check the air intake system installation to assure that gaskets are properly
sealed and that all hose connections, fasteners and other components are tight. Also
check to be sure that the air cleaner housing is properly seated and the cover fits
tightly. tighten connections and fasteners or replace damaged parts as necessary. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | If your engine has a thermostatically controlled cooling fan, inspect
hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be
sure the valve works properly. |
| | This is a Noise Emission Control Service. applicable only to vehicles sold in
the United States. |
| • | Check the crankcase depression regulator valve system for any worn, plugged
or collapsed hoses. |
112 500 km (67,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
125 000 km (75,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Rotate tires. (See footnote +.) |
| • | Inspect the air intake system installation to assure that gaskets are
properly sealed and that all hose connections, fasteners and other components are
tight. Also inspect to be sure that the air cleaner housing is properly seated and
the cover fits tightly. Tighten connections and fasteners or replace damaged parts
as necessary. This is a Noise Emission Control Service. Applicable only to vehicles
sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all
hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be
sure the valve works properly. This is a Noise Emission Control Service. Applicable
only to vehicles sold in the United States. |
137 500 km (82,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
150 000 km (90,000 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). |
| | This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. Change axle fluid
if the vehicle is driven in high-speed (above 70 km/h or 40 mph) conditions for extended
periods of time. |
| • | Clean and repack the front wheel bearings (or at each brake relining,
whichever occurs first). |
| | This is an Emission Control Service. (See footnote @.) |
| • | Inspect shields and underhood insulation for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | Rotate tires. (See footnote +.) |
| • | Inspect the air intake system installation to assure that gaskets are
properly sealed and that all hose connections, fasteners and other components are
tight. Also inspect to be sure that the air cleaner housing is properly seated and
the cover fits tightly. Tighten connections and fasteners or replace damaged parts
as necessary. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect all
hoses and ducts for proper hook-up (or every 12 months, whichever occurs first). Be
sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold in
the United States. |
162 500 km (97,500 mi)
| • | Change engine oil and filter (or every 12 months, whichever occurs
first). This is an Emission Control Service. |
| • | Lubricate chassis components (or every 12 months, whichever occurs
first). (See footnote #.) |
| • | Inspect rear axle fluid level and add fluid as needed. |
| • | Rotate tires. (See footnote +.) |
167 000 km (100,000 mi)
| • | Change automatic transmission fluid and filter. |
| • | Manual transmission fluid does not require changing. |
240 000 km (150,000 mi)
| • | Drain, flush and refill the cooling system (or every 60 months since the
last service, whichever comes first). |
| • | Clean the following components: |
| • | Pressure test the cooling system and the pressure cap. |
| | This is an Emission Control Service. |
