Technical Service Bulletins

2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-23: Special Coverage Adjustment - Analog OnStar Deactivation (08089B)
2008-09-22: Information on OnStar Analog-Only Systems (06-08-64-007A)
2008-09-05: Information on Speedometer Accuracy (08-08-49-011B)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
2008-06-04: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-01-31: 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
2008-01-30: Remote Keyless Entry Operational Characteristics (99-08-52-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-04: Information on The Use of Bonded Valve Body Spacer Plate and Gaskets - keywords part shift (PIP4309)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2007-12-13: 4WD Models With Noise Vibration On Dry Pavement - keywords grind growl moan rattle (PIP3300B)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-28: Procedure To Unlock Family Radio With Theftlock - keywords audio deterrent display entertainment inoperative loc lock theft theftdeterrent theftloc theftlock (PIC4696)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-10-29: Revised General Motors New Vehicle Tire Warranty Program (00-03-10-003M)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-09-27: Information on 4L60-E M30 Rear Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0756, P0894, Harsh 1-2 Shift (07-07-30-024)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-07-13: Product Emission - Ignition Coil Wire Arcing (98007)
2007-06-27: ABS Light On DTC C0055 C0235 C0236 Or C0237 Stored In The EBCM - keywords brake lamp light sensor speedometer VSS (PIT3521E)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-21: 1998-2007 Cars And Light Duty Trucks TCC Operation - keywords shudder slip surge speed (PIP4001A)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-21: Information on 2-3 Upshift or 3-2 Downshift Clunk Noise (01-07-30-042E)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-17: Improved Oil Fluid Wear Pump Clip - keywords 136 149 246 246EAU 261 263 263EAU housing leak case transfer transfercase (PIP4118)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-27: Reduced Steering Effort (Diagnose/Replace Steering Wheel Position Sensor) (07-02-32-001)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2007-01-03: Information on Low Fuel Lubricity and Fuel System Metal Contamination (99-06-04-047C)
2006-12-13: Information on OnStar Analog-Only Systems (06-08-46-007)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-27: No Start With DTC P1626 Or P1631 - keywords crank deterrent no nostart stall theft theftdeterrent (PIT4001A)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-10: Info - Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-22: Info - Pitting and Brake Dust on Chrome Wheels (04-03-10-012A)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-12: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
2006-08-30: Rattle Noise In Engine (Install Timing Tensioner Kit) (03-06-01-024C)
2006-08-30: Engine/Balance Shaft Rattle Noise (00-06-01-023C)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: SES Light After Installing A goodwrench Engine Due To A P1345 DTC - keywords cam chain CKP CMP correlation crank crankshaft distributor reman repeat replace replacement since timing (PIP3858A)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-08: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002D)
2006-05-30: GM Product Recall Campaign Follow Up Post Card (06-00-89-019A)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-17: Info - Instructions to be Followed to Aid in Obtaining Root cause Analysis on Both OEM and Goodwrench Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
2006-05-17: Info - Updated Transfer Case Connector Service Kit Now Available for Transfer Case Speed Sensor Wire Harness Connector that Comes Loose or Connector Retainer Clip Breaks (06-04-21-001)
2006-05-02: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-06: Discontinuation of the Field Product Reminder Bulletin/Bulletin Subscription Information (06-00-89-018)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-29: Info - Vibration Analysis Worksheet (03-00-91-001C)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-02: Warranty Admin. - Labor Operation Assignments for All Control Module Reprogramming (02-06-04-057E)
2006-03-01: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
2006-02-17: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance (06-08-45-001)
2006-02-14: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004b)
2006-02-14: Info - Diagnostic Tips For Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036F)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-24: Info - Expediting Warranty Parts (99-00-89-021E)
2006-01-19: 4WD Models with Noise, Vibration on Dry Pavement - keywords 04-04-18-001D 226 233E 236 241 243E 246 246EAU axle bearing bind case chatter chuggle decelerate differential front grab high HI4 (PIP3300A)
2006-01-18: Info - New Product Feedback Form and Process for Automatic Transmission Core Returns (01-07-30-029A)
2006-01-12: 4T65-E Automatic Transmission Fluid Leak from Reverse Servo Cover (Replace Reverse Servo Cover Seal) (04-07-30-028A)
2006-01-05: Antilock Brake (ABS) Activation at Low Speeds (Clean Wheel Speed Sensor Mounting Surface) (02-05-25-006B)
2006-01-04: Info - Maintenance Cleaning of Fuel Injectors (04-06-04-051B)
2005-12-22: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
2005-11-21: Info - Paint-less Dent Repair Process (99-08-51-001A)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-10-06: Info - Transmission Fluid Leak Diagnosis (01-07-30-041B)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-08-18: Info - Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
2005-08-17: Info - Release of GM Tool Organizaiton DVD Version 8.0 (J-43921-G) (05-00-89-056)
2005-08-10: Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inop I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
2005-08-05: Info - SPAC Case Escalation Process (05-00-89-050)
2005-08-02: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case (05-04-21-004)
2005-07-22: New Window Regulator Motor Does Not Fit - keywords connector door glass inoperative power wire (PIT3667)
2005-07-21: Hydro-Boost Brake Pedal Moves or Self Applies at Full Turns - keywords booster hydroboost press steering turn wheel (PIT3665)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-27: Warranty Admin. - Out-Of-Warranty Parts for Engineering Analysis (05-00-89-037)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-16: Light Throttle Hesitation or Misfire - keywords 4.3 5.0 5.7 accelerate backfire buck chuggle code decelerate detonation DTC hard harsh hot injector L30 L31 L35 launch miss noise surge (PIP3470)
2005-06-08: Info - On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
2005-06-03: Goodwrench Powertrain Wholesale Program (U.S. Only) (05-06-01-017)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-12: Info - Top Tether Hardware Package for Child Restraint Seats (99-09-40-004a)
2005-04-12: Info - OnStar System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-17: Info - GM Parts Ordering System (05-00-89-018)
2005-03-10: Info - Guidelines for Replacement of Transfer Case Control Module (TCCM) (05-04-21-002)
2005-03-08: Info - Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
2005-03-08: Info - OnStar Kit Part Numbers and Compatibility (99-08-46-001A)
2005-03-08: Information on Excessive Use of RTV Silicone Sealant on New Venture Gear (NVG) and Borg Warner Transfer Cases During Service (05-04-21-001)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-09: Info - Proper Air Bag System Diagnosis and Service (03-09-41-003A)
2005-01-31: Warranty Admin. - Guidelines for Claiming C0034 - Windshield Replacement (05-08-48-001)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-14: Info - OnStar Proactive Parts Shipment Process (02-08-46-013A)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2004-12-13: Info - Battery Specification Label (04-06-03-016)
2004-12-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022C)
2004-11-18: Info - Shipping Enhancements for Owners Manuals and Service Manuals Ordered from Helm, Inc. (04-00-89-057)
2004-11-18: Warranty Admin. - Warranty Return Parts (04-00-89-051)
2004-10-20: Info - Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
2004-10-19: Rolling Boom Noise Inside Vehicle (Install Pinion Nose Damper and/or New Rear Leaf Spring Dampers) (00-03-09-001B)
2004-10-11: Info - Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002A)
2004-10-08: Information on Error Codes on Radio Display - Their Cause and Corrective Action (01-08-44-005A)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-14: Info - Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (01-01-38-006D)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-09-01: 98-05 All General Motors Light Duty Trucks and Hummer H2 Bridgestone Dueler A/T Tires Size LT285/75R16 Load Range D (PIT3146)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-03: Warranty Admin. - Dealer Installed Regular Production Options (RPO) and Regular Production Accessories (RPA) (01-00-89-015A)
2004-08-02: Info - Repair Procedure for Service Sheet Metal, Craters in ELPO Surface (04-08-98-002)
2004-07-27: Warranty Admin. - Changes to General Motors Vehicle Inquiry System (GMVIS) (04-00-89-029)
2004-07-23: Info - Application of Anti-Corrosion Materials (01-08-51-003A)
2004-07-23: SES Light and P0300 When Towing , Cruising Uphill or on Hard Acceleration - kw 4.3 5.0 5.7 accelerate cruise cylinderhead DTC L30 L31 L35 LF6 LU3 P0300 P0301 P0302 P0303 P0304 P0305 P0306 P0307 P0308 (PIP3081)
2004-07-02: Info - Battery Parasitic Drain (02-06-03-010A)
2004-06-29: Driver Information Center ( DIC ) Stays in Bulb Check -kw compass gauge temperature GMT325 GMT330 (PIT3031A)
2004-06-22: Info - J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
2004-06-22: Info - New Owner Orientation Clinic Materials Now Available Online (03-00-89-002A)
2004-06-14: Boom Type Noise During Engine Warm-Up (Install Exhaust Dampener Assembly) (00-06-05-001B)
2004-05-26: Info - Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
2004-05-20: Supplement to TSB 00-03-09-001A Parts Availability - kw boom rear spring vibration (PI02115)
2004-05-10: No Start with DTC P1626 or P1631 - kw 2.8 3.5 4.2 4.8 5.3 6.0 8.1 crank fuel information stall theftdeterrent theft (PI02068)
2004-04-29: Information on Serpentine Belt Wear (04-06-01-013)
2004-04-22: Red OnStar LED , No Keypad Response When Pushed DTC B2476 - kw inoperative UE1 (PI02018)
2004-03-29: Warranty Administration - Part and Accessory Replacement Policy (04-00-89-011)
2004-02-11: Info - 4L65-E, 4L60-E, 4L60 and 200-4R Automatic Transmission Oil Pump Spring First and Second Design Identification (04-07-30-006)
2004-02-05: Warranty Admin. - Dealer Disclosure Requirements (02-00-89-005A)
2003-12-23: 4L60E, 4L65E Forward and Low Reverse Waved Steel Clutch Plate Appearance Change - kw appearance chatter first fourth PQC second shift shudder slip third transmission valve (PI01599)
2003-12-22: 4.3 L35 , LU3 5.0 L30 , 5.7 L31 Engine Coolant Leak at Intake Gasket - kw consumption smoke white (PI01225A)
2003-11-11: Info - Search Tips for Locating Preliminary Information (PI) Documents in Service Information (03-00-89-039)
2003-11-05: Special Policy Adjustment-Sequential Central Port Fuel Injection (SCPI) Failures in California Only (YF5 Emission Equipped) (99066G)
2003-11-05: Info - 4L60-E Automatic Transmission Oil Pump First and Second Design Identification (03-07-30-056)
2003-10-29: Diagnostic Information to Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
2003-09-19: Warranty Admin. - Sublet Administrative Allowance (Coverage: S) Labor Operations (03-00-89-027)
2003-07-14: Info - J 44551 A/C Suction Screen Kit Repair Recommendations and Procedures After Catastrophic Compressor Failures (01-01-39-003A)
2003-07-14: Info - HomeLink Transceiver/Garage Door Opener Transmitter Test Kit Available As Essential Tool (01-08-97-001B)
2003-06-25: Info - Most Frequently Asked Questions and Answers for J 45096 TransFlow Transmission Oil Cooling System Flushing Machine (03-07-30-027)
2003-06-10: Service VME - Transflow Transmission Cooling System Service Tool J45096 Optional Heater Blanket - 3T40 372LE 3L30 3T40 4L30E 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60E 4T65E 4T80E 5L40E automatic fluid (PI01163)
2003-05-13: Product Safety - Electric Outside Rearview Mirror Switch Short Circuit (03006A)
2003-04-29: Warranty Admin. - Courtesy Transportation Program (02-00-89-004B)
2003-04-29: SMU - Revised Transfer Case Disassemble and Transfer Case Assemble Procedures (03-04-21-003)
2003-04-24: Info - Bulletins Released Week of April 14, 2003 and Car and Truck Fix It Right the First Time Issues (03-00-89-010)
2003-03-14: Info - Automatic Air Conditioning Control Operation (99-01-39-007B)
2003-03-07: Info - A/C Refrigerant System Sealer and A/C System Leak Detection Guidelines (03-01-38-001)
2003-03-07: Info - Changes to Essential and Available Tool Numbering System (03-00-89-005)
2003-02-27: Info - Powertrain Quality Center for Performance Parts Engine Replacements (03-06-01-006)
2003-01-30: Rough Idle After Start, And/Or A Service Engine Soon (SES) Light (Unstick And Clean Central Sequential Fuel Injection (CSFI) Poppet Valves or Convert to MFI) (00-06-04-003B)
2003-01-29: Info - Automatic Transmission Oil Cooler Flushing and Flow Check Procedures (99-07-30-017A)
2002-12-16: Adm Msg - New Labor Time Guide Available Effective February 1, 2003 (WIW20020026)
2002-10-25: Proper Diagnostic Procedures for No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, SIR, Brake, Security, Theft, ABS, Hot, DIC Messages, Lamp, Light, Battery and Generator Diag. Testing (02-06-03-012)
2002-10-14: Diagnostic Information for Intermittent Transmission Downshift, Slip, Busy/Cycling TCC or Noisy Cooling Fan (99-07-30-016B)
2002-09-23: Adm Msg - Important Programming/TIS Information for Technicians (Admin Number 20020120 - 9/10/02) (VSS20020120)
2002-09-11: Info - Release of New Tool J 45380 - Rear Output Shaft Bushing Remover and Installer (02-04-21-007)
2002-08-09: Info - Engine Crankcase Flush (02-06-01-028)
2002-07-24: Warranty Admin. - Claim Procedures for Warrantable Electronic Failures on Vehicles Sold As Certified Used Vehicles or Certified Pre-Owned Vehicles (02-00-89-013)
2002-07-19: Warranty Admin. - Revised Empowerment Level-Authorization Code E (02-00-89-009)
2002-07-19: Info - Preliminary Information (PI) Text Available in Service Information (SI) (02-00-89-008)
2002-06-21: Info - Expandable Acoustic Foam (Two Component Sound Dampener) Usage with Collision Damage Repairs (02-08-98-003)
2002-06-13: Info - Automatic Transmission Serial Number and Site Code Locations (02-07-30-028)
2002-06-13: Info - Engine Identification Information (02-06-01-026)
2002-05-22: Right Rear Cargo Door Handle Breaks (Replace Handle) (02-08-64-013)
2002-02-27: Information on a New Engine Preluber Tool (02-06-01-008)
2002-01-11: Info - Engineering Changes to Reaction Shell Thrust Washer and use of New Service Kit (02-07-30-003)
2002-01-08: SMU - Revised Evaporator Core Replacement Procedure (02-01-37-001)
2002-01-02: SMU - Revised Ignition Lock Cylinder Replacement (02-02-35-001)
2001-12-18: Info - Tire Sidewall Damage (01-03-10-011)
2001-11-14: Info - Test Guidelines for Use of Essential Tool J41413-200 Evaporative System Tester (01-06-04-044)
2001-11-02: Exhaust System Rumble/Rattle Noise (Replace Exhaust Pipe Seals and Modify Exhaust Pipe Ring Flanges) (01-06-05-006)
2001-10-19: Info - 2-Cut vs. 5-Cut Rear Axle Ring and Pinion Gearsets (00-04-20-001A)
2001-10-04: Info - Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
2001-09-25: Information on Lowering Spare Tires Stored Under Vehicle (01-03-10-007)
2001-09-17: Warranty Admin. - Correct Use of Labor Operation R4490, RKE Transmitter, Replace (01-00-89-013)
2001-09-13: SMU - Revised Diagnostic Trouble Codes (DTCs) P0404, P0405, P1404 (01-06-04-043)
2001-06-25: Info - Cleaning the Cassette Tape Player and Clearing the CLN Message from the Radio Display (01-08-44-006A)
2001-06-21: F/CMVSS Noncompliance - Fasten Seat Belt Warning Audible Signal (01036)
2001-06-21: Info - Seat Belt System Replacement Guidelines for Vehicles Involved in Collisions (01-09-40-002)
2001-05-08: Info - Replacement of Keys, Key Numbers and/or Security Chips (01-00-89-009)
2001-05-02: Park/Neutral Position Switch Connector Cannot Be Removed (Replace Switch and Connectors) (01-07-30-021)
2001-04-09: Info - Guidelines for Use of Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
2001-04-06: Info - Current CIPS Campaign Number to Previous DIvisional Campaign Number (01-00-89-008)
2001-03-29: Info - New Control Valve Body, Spacer Plate and Gaskets for 4L60-E Automatic Transmission (01-07-30-012)
2001-03-02: Info - February, 2001 Bulletin Summary (01-00-89-006)
2001-02-09: Poor Heat Distribution in Drivers Area of Vehicle (Install New Heat Diverter Ductsj) (01-01-38-003)
2001-02-02: Info - January, 2001 Bulletin Summary (01-00-89-005)
2001-01-03: Info - December, 2000 Bulletin Summary (01-00-89-001)
2000-12-18: Warranty Admin. - January 1, 2001 Labor Time Guide Updates (00-00-89-031)
2000-12-04: Info - November, 2000 Bulletin Summary (00-00-89-030)
2000-11-29: Front Disc Brake Squeal (Install New Front Disc Brake Pads) (00-05-23-007)
2000-11-13: Warranty Admin. - December, 2000 Labor TIme Guide Updates (00-00-89-029)
2000-11-02: Info - October. 2000 Bulletin Summary (00-00-89-028)
2000-10-24: Info - The Importance of Chassis Lubrication (00-00-90-001)
2000-10-17: Warranty Admin. - November, 2000 Labor Time Guide Updates (00-00-89-025)
2000-10-06: Info - September, 2000 Bulletin Summary (00-00-89-024)
2000-09-21: Info - Correct Diagnostic Procedure When Reviewing A/C Performance/Leak Suspected (00-01-38-007)
2000-09-19: Warranty Admin. - October, 2000 Labor Time Guide Updates (00-00-89-023)
2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
2000-08-25: Outside Rear View Mirror Housing Turns Chalky/Dull (Color/Clear Coat Mirror) (00-08-51-001)
2000-08-17: Warranty Admin. - Cross-line Warranty (00-00-89-021)
2000-08-14: Warranty Admin. - September, 2000 Labor Time Guide Updates (00-00-89-020)
2000-08-10: Warranty Admin. - New Electrical Relay Labor Operation Numbers (00-00-89-019)
2000-08-08: Info - July, 2000 Bulletin Summary (00-00-89-018)
2000-08-03: Info - Essential Tool J 43600 ACR 2000 (00-01-38-006)
2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
2000-06-19: Warranty Admin. - July, 2000 Labor Time Guide Updates (00-00-89-014)
2000-06-19: Warranty Admin.- PCM Product Feedback Program (00-06-04-026)
2000-06-08: Info - California Consent Order on Settlement of Lawsuit on Batteries (Prop 65) (00-06-03-006)
2000-06-06: Info - May, 2000 Bulletin Summary (00-00-89-013)
2000-05-15: Info - Proper Service of Quick Connect EVAP System Connectors (00-06-04-021)
2000-05-12: Warranty Admin. - June, 2000 Labor TIme Guide Updates (00-00-89-012)
2000-05-08: Info - Brake Fluid Level and Filling Recommendations (00-05-22-004)
2000-05-03: Info - April, 2000 Bulletin Summary (00-00-89-011)
2000-05-02: Rough Idle/Hard/No Start (Replace Fuel Tank Fill Pipe Assm/Clean Poppet Valves) (00-06-04-018)
2000-04-14: Warranty Admin. - May, 2000 Labor Time Guide Updates (00-00-89-010)
2000-04-04: Info - March, 2000 Bulletin Summary (00-00-89-007)
2000-03-30: Vehicle Pulls/Leads Left or Right (replace Strg Idler Arms/Reset Alignment) (00-03-07-003)
2000-03-28: No/Hard/Slow Start, Backfire/Kickback (Replace Crankshaft Position Sensor) (00-06-04-014)
2000-03-21: Info - Essential Tool J 43690 - Rod Bearing Clearance Checking Tool (00-06-01-007)
2000-02-23: Informational - January, 2000 Bulletin Summary (00-00-89-003)
2000-01-13: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
2000-01-04: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (99-09-41-004)
1999-12-10: Warranty Admin. - January, 2000 Labor Time Guide Updates (99-00-89-023)
1999-12-06: Info - The Year 2000 (Y2K) and Vehicle Electronics (99-00-89-022)
1999-12-03: Child Seat Restraint (98071)
1999-11-08: Accessory Receptacle is Inoperative (Check Aftermarket Device Plug) (99-08-45-005)
1999-10-26: Info - PCM Reprogramming (99-06-04-053)
1999-10-22: Informational - CS-144 Generator Replacement (99-06-03-011)
1999-10-20: Info - Radiator Repair/Replacement Guidelines (99-06-02-017)
1999-10-14: November, 1999 Labor Time Guide Updates (99-00-89-020)
1999-10-08: Warranty Administration - October, 1999 Labor Time Guide Updates (99-00-89-017)
1999-10-06: Info - Cassette Player Cleaning and Maintenance (99-08-44-008)
1999-10-06: Info - New Tech 2 TCC Test/Component Slipping/DTC P1870 (99-07-30-023)
1999-09-02: Tech - On Board Diagnostic (OBD) System Improvements (Reprogram PCM) (99-06-04-037)
1999-08-10: Warranty Admin - September, 1999 Labor Time Guide Updates (99-00-89-016)
1999-08-10: Insufficient A/C Cooling (Replace A/C Compressor and Condenser Hose Assm) (99-01-38-002)
1999-07-29: Info - Compact Disc (CD) Players and Compatible CDs (99-08-44-006)
1999-07-28: Warranty Admin - August, 1999 Labor Time Guide Updates (99-00-89-012)
1999-07-27: Tech - Service Engine Soon (SES) Light Illuminates (Repl Switch Assy) (99-07-30-013)
1999-06-25: Warranty Admin - July 1999 Labor Time Guide Updates (99-00-89-010)
1999-05-25: Information - Original Equipment Chrome Plated Aluminum Wheel Identification (99-03-10-102)
1999-05-19: June 1999 Labor Time Guide Updates (99-00-89-008)
1999-04-20: Warranty Admin. - May, 1999 Labor Time Guide Update (99-00-89-006)
1999-04-20: Squeak Noise in Steering Column (Replace Steering Wheel SIR Module Coil Assem) (99-02-35-001)
1999-04-06: Labor Time Guide Updates - April 1999 (99-00-89-004)
1999-04-01: Info - 1998 Bill 101 French Label Installation Instructions (99-00-89-005)
1999-03-31: Info - Cleaning of Upper Instrument Panel Surfac (99-08-49-006)
1999-03-18: Info - Component Slipping/DTC P1870 - Diagnosis (99-07-30-005)
1999-03-09: Labor Time Guide Updates (99-00-89-003)
1999-03-04: Battery Insulator Replacement (99-06-03-002)
1999-03-02: Info - Instrument Cluster Identification (99-08-49-002)
1999-02-26: Essential Tool J 42000 Battery Tester (99-06-03-001)
1999-02-19: Warranty Parts Center/Corporate Parts Return Program (40-05-01C)
1999-02-19: 1-2 Accumulator Piston and Outer Spring Replacement (87-74-74)
1999-02-16: Warranty Administration - Labor Time Updates (99-00-89-001)
1999-02-12: Correct Solvent for SCPI Poppet Cleaning Procedure (99-06-04-006)
1998-11-16: INFO - ESSENTIAL TOOL J43435 ADJUSTER LOCKNUT (83-32-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-10-20: INFO - ESSENTIAL TOOL J43485 POWER STEERING BLEEDER ADAPTER (83-32-09)
1998-10-19: LEAK FROM TRANSFER CASE REAR EXTENSION, VIBRATION/NOISE (86-74-05)
1998-10-19: INFO. ON 1999 GEN 1E SMALL BLOCK V6/V8 NEW PRODUCT (87-61-32)
1998-10-08: WARRANTY ADMIN - LTG UPDATES (83-05-09)
1998-10-07: INFO - ALIGNMENT SPECIFICATIONS (83-31-09)
1998-10-01: SMU - SEC. 0/0C - VIBRATION DIAGNOSIS - REVISED PROPELLER (86-01-24)
1998-10-01: INFO - NEW WINDSHIELD AND STATIONATY GLASS URETHANE (83-15-16)
1998-10-01: INFO - REDUCED RANGE/OPERATION OF RKE (86-90-06)
1998-09-30: FRONT PROPELLER SHAFT CV BOOT TORN OR CRACKED (46-41-02A)
1998-09-29: INFO ON RECOMMENDED AXLE LUBRICANT (76-02-02A)
1998-09-17: WARRANTY ADMIN. - LTG UPDATES (83-05-08)
1998-09-16: SMU - SEC. 4A - PROPELLER SHAFT - REV. PROPELLER SHAFT (86-41-01)
1998-09-16: INFO - NEW PCM CONNECTOR SERVICE KITS (83-81-32)
1998-09-16: SMU - SEC. 0B - CORRECTED CRANKCASE VENTILATION SYSTEM (83-02-01)
1998-09-03: OBD II DTC P1404 (REFLASH VCM) (86-65-03A)
1998-08-21: WARRANTY ADMIN - LTG UPDATES (83-05-07)
1998-08-21: INFO - TOWING (16-01-01B)
1998-08-20: INFO - ESSENTIAL TOOL J-43241 REMOTE KEYLESS ENTRY AND (83-90-12)
1998-08-17: FLUID LEAK NEAR FRONT WHEELS OR FRONT ENGINE (86-43-06A)
1998-08-14: INFO - CORRECT LABOR CODE USAGE FOR ENTERTAINMENT SYS. (84-96-01)
1998-08-12: WARRANTY ADMIN. - REDEFINED USE OF PARTS WARRANTY SPECIAL (80-05-03)
1998-07-17: ROUGH IDLE AFTER START WHEN VEH. HAS SAT OVERNIGHT (87-65-07A)
1998-07-17: SPECIAL POLICY - SAFETY BELT GUIDE COVER (98030)
1998-07-17: SPECIAL POLICY - SAFETY BELT GUIDE COVER (98030)
1998-07-16: SMU - SEC. 6 - ENGINE - REVISED SCHEMATICS (86-65-02)
1998-07-15: WARRANTY ADMIN. - LTG UPDATES (83-05-06)
1998-07-15: SMU - SEC. 8A-14 - GROUND DISTRIBUTION REV. SCHEMATICS (86-81-05)
1998-06-26: INFO ON NEW TRANS. CALIBRATIONS (87-71-69)
1998-06-11: WARRANTY ADMIN. - LTG UPDATES (83-05-05)
1998-06-03: INFO - NEW TOOL J-42958, REV. CHARTS AND SCHEM. FOR CRUISE (83-90-08)
1998-05-22: INFO - 1998-99 DELCO RADIO EXCHANGE REFERENCE (83-96-04)
1998-05-18: ACCESSORY DRIVE BELT NOISE DUE TO STEERING PUMP PULLEY (77-60-02)
1998-05-18: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-04)
1998-04-24: GENERAL MOTORS WARRANTY INQUIRY SYSTEM (82-05-05)
1998-04-21: WARRANTY ADMIN - REQ. FOR WHOLESALE AUTH. OR WARRANTY (82-05-02)
1998-04-16: WARRANTY ADMIN. - LTG UPDATES (83-05-03)
1998-04-16: INFORMATION - 1998-99 GM SOUND SELLING RADIO PROGRAM (83-96-03)
1998-04-02: INFO. USE OF'SURFACE CONDITIONING DISCS' (87-61-24)
1998-03-16: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-02)
1998-03-10: EXCESSIVE TICKING NOISE IN AMBIENT TEMP. (DIAG REPL. (87-63-02)
1998-03-10: INFO. NEW TOOL J-41450-B RELEASED FOR CS GEN DIAG. (83-64-09)
1998-03-02: INFO - FUEL LEVEL SENSOR REPLACEMENT PROC (83-83-07)
1998-02-25: INFO - INSTRUMENT CLUSTER ID. (83-83-09)
1998-02-24: INFO - PREMATURE MAIN BEARING FAILURE (87-61-22)
1998-02-20: WARRANTY ADMIN - LABOR TIME GUIDE UPDATES (83-05-01)
1998-02-18: TEXT CHANGES IN 'UNIFORM' TIRE QUALITY GRADING (86-35-04)
1998-02-13: SMU - SEC. 9D - THEFT DETER. SYS. (PASSLOCK) REV. (86-90-02)
1998-02-13: INFO. ON VIN PLATE REPLACEMENT (83-01-14)
1998-02-05: REAR WINDOW WASHER FLUID SPRAY PATTERN (76-82-11)
1998-01-27: SMU - SEC. 2F - STEERING WHEEL & COLUMN ON VEH. (76-32-09)
1998-01-14: INFO. - DIAG PROC. WHEN A/C DIAG INFO LEAK (73-12-12A)
1998-01-12: INFO. FRONT. SUPP. INFLAT. RESTRAINTS (SIR) ON-OFF SWITCH (73-90-23)
1997-12-18: WARRANTY ADMIN. - REPAIR/ REPLACE POLICIES & PROC. (72-05-13)
1997-12-18: WARRANTY ADMIN. - ENHANCED SUBLET REPAIR POLICY (72-05-14)
1997-12-16: WARR. ADMIN - LABOR TIME GUIDE UPDATES (73-05-09)
1997-12-15: INFO ON NEW PRODUCT INFOR FOR 4L60-E TRANS (77-71-75)
1997-11-28: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (73-05-07)
1997-11-26: INFO. ON TECHNICAL ASSISTANCE CALL PREPARATION (73-01-10)
1997-11-20: CLARIFICATION OF RAIL DUST REM (A5575-A5580) (72-05-11)
1997-11-12: INFORMATION - PUREGUARD 2 OPERATING ALERT (73-12-13)
1997-11-01: WARRANTY ADMIN. - LABOR OPERATION CODE Z1241 (62-05-02A)
1997-10-24: WARR. ADMIN-LTG UPDATES 1989-98 PASS. CAR & TRUCK (73-05-06)
1997-10-23: WARRANTY ADMIN: 1998 G.S.A. FUEL EXPL FUEL PRICE CHANGE (72-05-10)
1997-09-25: INFO - DIAG. HINTS FOR 'ROLLING CODE' REMOTE FUNC. (73-90-18)
1997-09-11: WARRANTY: TIRE REPLACEMENT DURING BUMPER TO BUMPER (70-05-01)
1997-08-21: WARRANTY ADMIN - GUIDELINES FOR USING E0420 WHEEL (72-05-05)
1997-08-21: WARRANTY ADMIN- GUIDELINES FOR USING I/M 240 LABOR OP (72-05-06)
1997-08-14: ENGINE ROUGH, MISS AND OXYGEN SENSOR DTCS (76-65-05)
1997-08-12: WARRRANTY ADMIN - LABOR TIME GUIDE UPDATES (73-05-05)
1997-07-22: INFO. ON HEATED OXYGEN SENSOR (77-65-18)