Technical Service Bulletins

2008-09-29: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement (02-07-30-029L)
2008-09-29: Eliminating Unwanted Odors in Vehicles (00-00-89-027E)
2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-26: Fluid Leak from Transmission Oil Cooler Lines due to Corrosion - keywords leak line loose rust tight (PIT4722)
2008-09-23: Special Coverage Adjustment - Analog OnStar Deactivation (08089B)
2008-09-19: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords blue button communication message no noconnect operation (PIC4600A)
2008-08-28: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) (08-08-44-028)
2008-08-27: New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-00-89-014E)
2008-08-26: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs) (08-08-44-015A)
2008-08-25: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006E)
2008-08-22: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process (For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB, Audio, Display, Map, Noise) (08-08-44-010B)
2008-08-11: Informaiton on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
2008-08-08: Information on Water or Ethylene Glycol in Transmission Oil (08-07-30-035)
2008-08-05: Question Regarding Installation Of Dealer Installed Accessories (PIT3099E)
2008-08-01: SWC Operation After OnStar ADT Upgrade - keywords call calling control inoperative steering wheel (PIC4820A)
2008-07-25: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 (05-03-08-002B)
2008-07-23: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information led no operation red (PIC3597F)
2008-07-23: OnStar Power Consumption - keywords battery digital discharge drain draw parasitic VCIM (PIC4935)
2008-07-21: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output (02-06-03-008D)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-27: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) (07-00-89-047B)
2008-06-27: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009B)
2008-06-24: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047H)
2008-06-24: GM Goodwrench Limited Lifetime Service Guarantee (03-00-89-003A)
2008-06-23: Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011)
2008-06-20: Information on Use of Customer Concern Verification Sheets, Comeback Prevention, GM Technical Assistance Information Form (TAC), Strategy Based Diagnostics (SBD), Intermittent Concerns, Diagnostics (01-00-89-010H)
2008-06-18: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement (08-08-44-023)
2008-06-18: OnStar Voice Recognition Operation Issues - keywords information intermittent microphone performance voice (PIC3011E)
2008-06-18: Unable To Connect To OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication droppedcall failedtovoice information intermittent OPC operation no noconnect performance region (PIC4310C)
2008-06-16: Questions Regarding Installation Of Dealer Installed Accessories (PIT3099D)
2008-06-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
2008-06-06: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002E)
2008-06-05: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors (07-08-64-022A)
2008-06-04: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
2008-05-30: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. Only) (07-03-10-016A)
2008-05-30: Intermittent, Current or History DTC B2476 in Onstar GEN 6 or 7 VCIM - keywords blue button call communication data digital information keypad led OPC operation red (PIC4574B)
2008-05-28: Gen III Or Gen IV V-8 Engine Misfire - keywords P0300 arm cam camshaft lifter wear worn engine L33 L59 L76 L92 LC9 LFA LH6 LH8 LM7 LMG LR4 LS2 LS4 LQ4 LQ9 LY2 LY5 LY6 miss rocker roller rough valve (PIP4138E)
2008-05-22: GEN III or IV V-8 Engine Misfire - keywords p0300 arm cam camshaft lifter wear worn engine l33 l59 l76 l93 lc9 lfa lh6 lm7 lmg lr4 ls3 ls4 lq4 lq9 ly2 ly5 miss rocker roller rough valve (PIP4138D)
2008-05-16: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
2008-05-12: Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
2008-05-12: Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036G)
2008-05-12: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
2008-05-08: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036E)
2008-05-07: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Intrument Panel Clusters (IPC) (08-08-44-015)
2008-05-06: Disc Brake Warranty Service and Procedures (00-05-22-002K)
2008-05-05: Engagement Time of Electronically Controlled Transmissions in General Motors Vehicles (Garage Shifts, Park to Reverse, Neutral to Drive, Neutral to Reverse, Park to Drive, Delayed Engagement) (03-07-30-007E)
2008-05-02: Manual Transmission Operating Characteristics (03-07-29-004E)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005)
2008-05-01: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) (08-03-10-006)
2008-05-01: Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
2008-04-30: ACDelco Replacement Battery Warranty Procedures (03-06-03-003B)
2008-04-29: Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
2008-04-18: Information for Dealers on How to Submit a Field Product Report (02-00-89-002G)
2008-04-17: Key Code Information (99-00-89-011C)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-16: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines (05-08-44-024A)
2008-04-14: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information LED no operation red (PIC3597E)
2008-04-14: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts (00-06-01-012C)
2008-04-14: Unnecessary Leaf Spring Clip Replacement (04-03-08-011D)
2008-04-10: Midtronics Code Generated by J 42000 or J 42000EU Battery Tester Required for Claim Processing On Labor Operation N0110 (03-06-03-004C)
2008-04-10: Handsfree Calling Inop With Demo Message On OnStar Keypress - keywords 05-08-46-006N blue button communication digital disabled message no OPC operation vs3bgen6 vs3bgen7 (PIC4564A)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-01: Warranty Claims Submission - Importance of GM Part Numbers and Parts with Date Codes (06-00-89-054B)
2008-03-31: Escalation Process for Critical Orders for Electronic Service Center (ESC) Parts (06-00-89-032A)
2008-03-27: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-25: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories (08-03-10-004)
2008-03-19: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication failedtovoice information intermittent OPC operation no noconnect performance (PIC4310B)
2008-03-19: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001G)
2008-03-14: SWC Operation After OnStar ADT Upgrade - keywords call calling control inoperative operation onstar steering wheel (PIC4820)
2008-03-12: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation (08-08-51-002)
2008-03-11: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006D)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-25: General Motors Position Statement on Installation of Used, Salvaged or Imitation Air Bag System Components (08-09-41-003)
2008-02-19: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001F)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-06: GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078B)
2008-02-05: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
2008-02-05: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience (04-06-01-029B)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-02-04: Driveline Characteristics for All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
2008-02-01: Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
2008-02-01: Distortion in Outer Surface of Vehicle Glass (00-08-48-005C)
2008-02-01: Information on Eliminating Noise in Audio System When Using Portable Playback Device (06-08-44-015A)
2008-01-31: 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
2008-01-31: Vibration Analysis Worksheet (03-00-91-001D)
2008-01-30: Remote Keyless Entry Operational Characteristics (99-08-52-005C)
2008-01-25: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006B)
2008-01-25: Information on New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
2008-01-23: 18 Digit Snapshot/Charge Summary Code No Longer Required for A/C Refrigerant System repairs Submitted for Warranty Reimbursement (05-01-38-008B)
2008-01-18: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
2008-01-18: Warranty Administration - Repair Order (RO) Documentation (00-00-89-015B)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-17: Engineering Information (EI) Process (04-00-89-053B)
2008-01-17: Re-establishing Communications with OnStar Center After Battery Disconnect (00-08-46-004C)
2008-01-17: Tire Slowly Goes Flat and/or Excessive Wheel Vibration Caused by Bead Splits (Replace Wheels with New Heavy Duty Rim Version) (03-03-10-001D)
2008-01-16: 4L80E, MT1 and 4L85E, MN8 Simplified Valve Body Reconditioning Instructions, DTC P0741, P0742, P0751, P0752, P0756, P0757, P0894, Harsh or Delayed Shifts, Slips, No Drive, No Reverse (08-07-30-001)
2008-01-15: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003C)
2008-01-15: GM Technical Assistance Information Form (TAC) and Service Strategy Process Utilizing Customer Service Comeback Prevention, Strategy Based Diagnostics (SBD) and Intermittent Concern Diagnosis (01-00-89-011g)
2008-01-09: Availability of GM OnStar Vehicle Diagnostics and GM Goodwrench Remote Diagnostic Services (06-08-46-002B)
2008-01-09: Seat Belt Extender Availability (99-09-40-005E)
2008-01-09: Information on Tire Radial Force Variation (RFV) (00-03-10-006C)
2008-01-09: OnStar Labor Operation Codes (05-08-46-005B)
2008-01-08: OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System (05-08-46-004B)
2008-01-08: Incorrect OnStar Global Positioning System (GPS) Location Reported During OnStar Call (02-08-46-006C)
2008-01-07: Tire Puncture Repair Procedures for All Cars and Light Duty Trucks (04-03-10-001D)
2008-01-04: Information on The Use of Bonded Valve Body Spacer Plate and Gaskets - keywords part shift (PIP4309)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2007-12-17: Warranty Parts Center/Corporate Parts Return Program (99-00-89-019E)
2007-12-10: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT - CH-47976) (03-06-04-030F)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-21: Release of DEXRON-VI Automatic Transmission Fluid (ATF) (04-07-30-037D)
2007-11-14: Whine Noise In First And Second Gear - keywords acceleration case clash filter fluid oil (PIP3259H)
2007-11-12: Customer Concern Not Duplicated/Verified Labor Operations (06-00-89-026A)
2007-11-09: Underbody Corrosion - keywords appearance body frame rust (PIT3749B)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Corrosion Protection for Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008D)
2007-10-29: Revised General Motors New Vehicle Tire Warranty Program (00-03-10-003M)
2007-10-23: Information on Proper Tire Pressure (00-00-90-002I)
2007-10-08: GEN III Or GEN IV V-8 Engine Misfire - keywords P0300 arm cam camshaft lifter wear worn engine L33 L59 L76 LC9 LH6 LM7 LMG LR4 LS2 LQ4 LQ9 LY5 LY6 misfire miss rocker roller rough valve (PIP4138B)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-09-28: Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
2007-09-27: Information on 4L60-E M30 Rear Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0756, P0894, Harsh 1-2 Shift (07-07-30-024)
2007-09-21: Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires (03-03-10-007C)
2007-09-17: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016A)
2007-09-05: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
2007-08-23: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors (07-00-89-043)
2007-08-16: Warranty Admin. - Courtesy Transportation and Roadside Assistance Programs (07-00-89-037)
2007-08-14: Gen III Or Gen IV V-8 Engine Misfire - keywords P0300 arm cam camshaft lifter wear worn engine L33 L59 L76 LC9 LH6 LM7 LMG LR4 LS2 LQ4 LQ9 LY5 LY6 misfire miss rocker roller rough valve (PIP4138A)
2007-08-14: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016)
2007-08-06: Guidelines for Usage of Transmission K Labor Operation Recondition Add Time (07-07-30-020)
2007-08-02: Warranty Admin. - GM Dealer Empowerment Program and Goodwill Procedures (05-00-89-055B)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-07-26: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022D)
2007-07-23: Warranty Administration - Required Operating Procedures (04-00-89-015A)
2007-07-19: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) (06-08-50-009B)
2007-06-27: ABS Light On DTC C0055 C0235 C0236 Or C0237 Stored In The EBCM - keywords brake lamp light sensor speedometer VSS (PIT3521E)
2007-06-27: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 (07-01-38-004)
2007-06-27: GM Training:May 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-028)
2007-06-26: GM Training:Number of Technicians Required Reduced for Two Categories (U.S. Dealers) (07-00-89-016)
2007-06-26: GM Training:Three Technology Close-Up IDL Seminars as New 2007 Service Training Standard (STS) Requirements (U.S. Dealers) (07-00-89-014)
2007-06-26: GM Training:March 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-013)
2007-06-26: GM Training:Course Information (For U.S. Dealers and Aftermarket) (07-00-89-011)
2007-06-26: GM Training:January 2007 GM Service Know-How Emerging Issues Seminar (#10207.01D) (For U.S. Dealers Only) (07-00-89-007)
2007-06-26: GM Training:Maintaining GM STC Master Technician Certification (MTC) (For U.S. Dealers Only) (07-00-89-005)
2007-06-26: GM Training:HVAC Systems and Operation Stage 2 WBT and IDL (11044.03) (For U.S. Dealers Only) (07-01-38-001)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-22: Use of Silicone for Weatherstrip Maintenance (99-08-64-016B)
2007-06-21: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage (00-06-01-026B)
2007-06-14: Communication Strategy of Service Information/Strategy Based Diagnostics (05-00-89-067B)
2007-06-13: Goodwrench Replacement Engines With Rear Main Seal Oil Leak - keywords crank crankshaft engine leak oil main rear replace replacement seal shaft (PIP4155)
2007-06-12: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT - CH-47976) (03-06-04-030E)
2007-06-08: Windshield Wiper Performance, Cleaning Instructions and Maintenance (06-08-43-003A)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-24: Corrosion Protection for Metal Panels with Dealer Installed Accessories Fastened by Drilled Holes (03-00-89-008C)
2007-05-23: Whine Noise In First And Second Gear - keywords acceleration case clash filter fluid oil (PIP3259G)
2007-05-21: Information on 2-3 Upshift or 3-2 Downshift Clunk Noise (01-07-30-042E)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-18: Special Coverage (Policy) Adjustment - Electronic Diesel-Fuel Injection Pump Failure-Repair/Replace (00064G)
2007-04-17: Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-04-02: Info - Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair (07-08-98-001)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-05: Information on Revised Connecting Rod Bolt Torque for Small Block GEN III and GEN IV Vortec V8 Engines (07-06-01-002)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-20: Information on Diesel Fuel Additives (03-06-04-017D)
2007-02-15: Info - New Bulletin Category: Technical Training (U.S. Only) (07-00-89-003)
2007-02-07: Cold Engine Idle Misfire Or DTCs P0171 P0174 - keywords 4.8 5.3 6.0 air cold crack hesitate idle intermittent internal intake leak lean misfire miss P0171 P0174 P0300 power rough surge vacuum (PIP3232B)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2007-01-03: Information on Low Fuel Lubricity and Fuel System Metal Contamination (99-06-04-047C)
2006-12-22: L59, LR4, LM4, LM7, LQ4, LQ9, LS1, LS6 New Exhaust Manifold Bolts and Torque Specifications for GEN III Vortec Engine (06-06-01-026)
2006-12-13: Information on OnStar Analog-Only Systems (06-08-46-007)
2006-12-07: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001E)
2006-11-29: OnStar Vehicles - Voice Recognition Inoperative - keywords analog celleular communication digital intermittent UE1 vs3bcu vs3bgen2 vs3bgen3 vs3bgen4 vs3bgen5 vs3bgen6 vs3bgen7 (PIC3011D)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-27: No Start With DTC P1626 Or P1631 - keywords crank deterrent no nostart stall theft theftdeterrent (PIT4001A)
2006-11-20: Side Cargo Door is Hard to Open (Install New Hinge Pins) (06-08-64-032A)
2006-11-09: Crank No Start When Cold Due To Compression Loss - keywords cylinder cylinderhead extended hard head lifter loss (PIP3146B)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-24: Warranty Admin. - Revised Mass Air Flow Core Return Requirements (06-06-04-057)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-13: Odometer And PRNDL Light Up With Key Out Of The Ignition And Door Open - keywords cluster DIC display indicator IPC (PIT3238A)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-10: Info - Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-28: Service VME - Additional Information About Passenger Presence Systems (PPS) - keywords bladder information passenger PPS presence restraint seat sensor SIR system weight (PIT4138)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-26: P0300 Cylinder 7 Misfire Due To Fuel System Contamination - keywords CEL contaminated DTC engine gas L59 L76 L92 LC9 LMG LR4 LM7 LY2 LY5 LY6 LQ4 LQ9 miss P0302 P0307 P0308 SES tank water (PIP3055A)
2006-09-22: Info - Pitting and Brake Dust on Chrome Wheels (04-03-10-012A)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Information on Engine Misfire MIL/SES Light Illuminated or Flashing DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, P0420 or P0430 (06-06-04-046)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-12: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
2006-09-08: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (06-08-111-004)
2006-09-07: Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010)
2006-08-30: Rattle Noise In Engine (Install Timing Tensioner Kit) (03-06-01-024C)
2006-08-30: Engine/Balance Shaft Rattle Noise (00-06-01-023C)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-17: 4T65E Whine Noise Park/Neutral - keywords bearing drive sprocket support (PIP3894)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-14: Loss of Power Hesitates on Acceleration - keywords 2.8 3.5 4.2 4.3 4.8 4L60E 4L65E 5.3 5.7 6.0 accelerate cold L35LK5 LL8 LM7 loss LQ4 LQ9 LS1 LS6 LU3 M30 M32 miss misfire neutral no performance power (PIP3796A)
2006-08-11: 4L60E/4L65E/4L70E Snap Noise 2-1 Downshift - keywords clunk (PIP3106B)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: SES Light After Installing A goodwrench Engine Due To A P1345 DTC - keywords cam chain CKP CMP correlation crank crankshaft distributor reman repeat replace replacement since timing (PIP3858A)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-01: No Start or Rough Running After Engine Replacement - keywords 7.4L crank crankshaft DTC Goodwrench L19 L29 nostart SES stall (PIP3877)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-07-10: Gen III V8 Piston or Crankshaft Repairs - keywords crank cylinder engine knock L59 LM4 LM7 LQ4 LQ9 LR4 LS1 LS6 noise pin rod tick (PIP3691D)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-16: Rear Differential Side Gear Kit, Case and Starter Shim Usage - keywords axle differential gear shim (PIP3840)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-08: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002D)
2006-05-30: GM Product Recall Campaign Follow Up Post Card (06-00-89-019A)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-17: Info - Instructions to be Followed to Aid in Obtaining Root cause Analysis on Both OEM and Goodwrench Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
2006-05-02: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Intermittent Neutral from a Stop or 2-3 Shift - keywords 4L60E 4L65E flare launch slip (PIP3002D)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-11: Info - Cellular Error Messages Received when Trying to Connect to OnStar (02-08-46-004A)
2006-04-06: Discontinuation of the Field Product Reminder Bulletin/Bulletin Subscription Information (06-00-89-018)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-29: Info - Vibration Analysis Worksheet (03-00-91-001C)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-02: Warranty Admin. - Labor Operation Assignments for All Control Module Reprogramming (02-06-04-057E)
2006-03-01: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
2006-02-24: Service VME - Underbody Corrosion - keywords appearance body frame rust (PIT3749A)
2006-02-24: Questions Regarding Installation of Dealer Installed Accessories - keywords 2.8 3.5 4.2 4.8 5.3 6.0 8.1 accessory part Partech (PIT3099C)
2006-02-17: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance (06-08-45-001)
2006-02-14: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004b)
2006-02-14: Info - Diagnostic Tips For Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036F)
2006-02-09: Diagnostic Information for Front Wheel Drive Transaxle/Transmission Final Drive and/or Front Hub Bearing Hum and/or Grind Noise (06-07-30-006)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-24: Info - Expediting Warranty Parts (99-00-89-021E)
2006-01-18: Info - New Product Feedback Form and Process for Automatic Transmission Core Returns (01-07-30-029A)
2006-01-12: 4T65-E Automatic Transmission Fluid Leak from Reverse Servo Cover (Replace Reverse Servo Cover Seal) (04-07-30-028A)
2006-01-04: Info - Maintenance Cleaning of Fuel Injectors (04-06-04-051B)
2005-12-22: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
2005-11-21: Info - Paint-less Dent Repair Process (99-08-51-001A)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-11-04: Light Duty Truck, Van, Utility Rear Axle Lubrication Service Interval - keywords differential fluid housing label oil (PIP3001A)
2005-11-02: Info - Use of Correct Installation Procedure for Loose Hubcap Assembly (03-03-10-002B)
2005-10-06: Info - Transmission Fluid Leak Diagnosis (01-07-30-041B)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-08-18: Info - Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
2005-08-17: Info - Release of GM Tool Organizaiton DVD Version 8.0 (J-43921-G) (05-00-89-056)
2005-08-10: Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inop I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
2005-08-05: Info - SPAC Case Escalation Process (05-00-89-050)
2005-08-03: Info - First and Second Design Clutch Hub and Apply Plate for NV246 Transfer Case (05-04-21-005)
2005-08-02: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case (05-04-21-004)
2005-07-21: Hydro-Boost Brake Pedal Moves or Self Applies at Full Turns - keywords booster hydroboost press steering turn wheel (PIT3665)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-27: Warranty Admin. - Out-Of-Warranty Parts for Engineering Analysis (05-00-89-037)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-16: Light Throttle Hesitation or Misfire - keywords 4.3 5.0 5.7 accelerate backfire buck chuggle code decelerate detonation DTC hard harsh hot injector L30 L31 L35 launch miss noise surge (PIP3470)
2005-06-08: Info - On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
2005-06-03: Goodwrench Powertrain Wholesale Program (U.S. Only) (05-06-01-017)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-29: SMU - Revised DTC P0236 (05-06-04-031)
2005-04-12: Info - Top Tether Hardware Package for Child Restraint Seats (99-09-40-004a)
2005-04-12: Info - OnStar System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
2005-03-24: Info - Revised Front Caster and Camber Adjustment Procedure (02-03-07-002A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-17: Info - GM Parts Ordering System (05-00-89-018)
2005-03-10: Info - Guidelines for Replacement of Transfer Case Control Module (TCCM) (05-04-21-002)
2005-03-08: Info - Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
2005-03-08: Info - OnStar Kit Part Numbers and Compatibility (99-08-46-001A)
2005-03-08: Information on Excessive Use of RTV Silicone Sealant on New Venture Gear (NVG) and Borg Warner Transfer Cases During Service (05-04-21-001)
2005-03-08: 1999-2005 Chevrolet/GMC/Cadillac All Full Size Trucks and Utilities Freon Leak Low Refrigerant Charge - keywords blows cap cooling cold compressor freon hose hvac leak line r134a (PIT3476)
2005-03-08: 1999-2005 Light Duty Trucks and Utilities - 8.625 Rear Axle Pinion Head Bearing and Race Design Change - keywords differential drive information noise part performance overheat (PIP3360)
2005-03-07: Info - Required Reconfiguration on OnStar Modules After Replacement (01-08-46-001A)
2005-02-10: 96-02 Chevrolet Express and GMC Savana Power Window Inoperative After Express Down - kw glass channel dome dim DRL electrical ground power short wire (PIT3428)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-09: Info - Proper Air Bag System Diagnosis and Service (03-09-41-003A)
2005-02-07: Customer Satisfaction - Hydraulic Steering Pump Shaft Fracture (05001)
2005-01-31: Warranty Admin. - Guidelines for Claiming C0034 - Windshield Replacement (05-08-48-001)
2005-01-31: 4L60E, 4L65E Replacement Valve Body Gaskets Does Not Seem to Fit - kw chatter clutch repair second shift shudder slip (PI00773)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-14: Info - OnStar Proactive Parts Shipment Process (02-08-46-013A)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2005-01-06: 1996 - 2002 Chevrolet Express Cutaway and GMC Savana Cutaway Turn Signal Flash Too Fast, Opposite Side Dim- kw flasher connector dim electrical ground hazard lamp left indicator (PIT3356)
2005-01-05: Cranks But No Start, Stall, Inaccurate/Incorrect Fuel Gauge Reading, No Fuel, Vehicle is Out of Fuel and Fuel Gauge Reads Above Empty (Replace Fuel Level Sensor) (04-08-49-018E)
2005-01-03: 96 - 05 Light Duty Trucks and Utilities with 4L80E Output Carrier Thrust Washer Changes - kw automatic bearing MT1 overhaul noise part repair transmission shift slip washer (PIP3276)
2004-12-13: Info - Battery Specification Label (04-06-03-016)
2004-12-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022C)
2004-11-18: Info - Shipping Enhancements for Owners Manuals and Service Manuals Ordered from Helm, Inc. (04-00-89-057)
2004-11-18: Warranty Admin. - Warranty Return Parts (04-00-89-051)
2004-11-11: 6.5L Diesel Cylinder Head Cracks Between the Valve Seats - kw L56 L57 L65 diesel leak coolant (PIP3218)
2004-10-28: Use of Red Diesel Fuel in 6.5L or 6.6L Diesel Engines - kw dye hard INJ INT LB7 LLY L49 L56 L57 L65 miss P3 pump stall start (PIP3207)
2004-10-20: Info - Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
2004-10-11: Info - Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002A)
2004-10-08: Information on Error Codes on Radio Display - Their Cause and Corrective Action (01-08-44-005A)
2004-09-16: 00-01 4L80-E Harsh TCC Apply/DTC P1870 or P0741 - kw 4L80E apply automatic converter DTC hard harsh shift TCC torque transmission (PIP3047A)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-14: Info - Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (01-01-38-006D)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-09-01: 98-05 All General Motors Light Duty Trucks and Hummer H2 Bridgestone Dueler A/T Tires Size LT285/75R16 Load Range D (PIT3146)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-03: Warranty Admin. - Dealer Installed Regular Production Options (RPO) and Regular Production Accessories (RPA) (01-00-89-015A)
2004-08-02: Info - Repair Procedure for Service Sheet Metal, Craters in ELPO Surface (04-08-98-002)
2004-07-27: Warranty Admin. - Changes to General Motors Vehicle Inquiry System (GMVIS) (04-00-89-029)
2004-07-23: Info - Application of Anti-Corrosion Materials (01-08-51-003A)
2004-07-23: SES Light and P0300 When Towing , Cruising Uphill or on Hard Acceleration - kw 4.3 5.0 5.7 accelerate cruise cylinderhead DTC L30 L31 L35 LF6 LU3 P0300 P0301 P0302 P0303 P0304 P0305 P0306 P0307 P0308 (PIP3081)
2004-07-02: Info - Battery Parasitic Drain (02-06-03-010A)
2004-06-22: Info - J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
2004-06-22: Info - New Owner Orientation Clinic Materials Now Available Online (03-00-89-002A)
2004-05-26: Info - Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
2004-05-20: AAM 10.5 and 11.5 Repeat Rear Axle Hub Seal Leak - kw differential drive GMT600 GMT800 oil (PI01222B)
2004-05-10: No Start with DTC P1626 or P1631 - kw 2.8 3.5 4.2 4.8 5.3 6.0 8.1 crank fuel information stall theftdeterrent theft (PI02068)
2004-04-29: Information on Serpentine Belt Wear (04-06-01-013)
2004-04-22: Red OnStar LED , No Keypad Response When Pushed DTC B2476 - kw inoperative UE1 (PI02018)
2004-03-29: Warranty Administration - Part and Accessory Replacement Policy (04-00-89-011)
2004-03-23: Adm Msg - Wheel Alignment Questionnaire (Fax Number Change) (VSS20040057-01)
2004-02-20: 4.3L L35 Engine Wide Open Throttle DTC P0335 P0336 P0339 - kw crank crankshaft DTC data LU3 miss misfire sensor speed stall tachometer (PI00700B)
2004-02-20: 4L60E , 4L65E No 2nd , No 4th and No Reverse - automatic fourth second shift transmission (PI00822C)
2004-02-11: Info - 4L65-E, 4L60-E, 4L60 and 200-4R Automatic Transmission Oil Pump Spring First and Second Design Identification (04-07-30-006)
2004-02-05: Warranty Admin. - Dealer Disclosure Requirements (02-00-89-005A)
2004-01-14: SMU - Revised DTC P1217 (04-06-04-004)
2004-01-06: Vibration or Rattle Type Noise in Exhaust System at Idle (Install Exhaust System Dampener Assembly) (01-06-05-003A)
2004-01-06: Info - HVAC Control Knob Replacement (04-01-37-001)
2003-12-23: 4L60E, 4L65E Forward and Low Reverse Waved Steel Clutch Plate Appearance Change - kw appearance chatter first fourth PQC second shift shudder slip third transmission valve (PI01599)
2003-12-22: 4.3 L35 , LU3 5.0 L30 , 5.7 L31 Engine Coolant Leak at Intake Gasket - kw consumption smoke white (PI01225A)
2003-11-11: Info - Search Tips for Locating Preliminary Information (PI) Documents in Service Information (03-00-89-039)
2003-11-05: Special Policy Adjustment-Sequential Central Port Fuel Injection (SCPI) Failures in California Only (YF5 Emission Equipped) (99066G)
2003-11-05: Info - 4L60-E Automatic Transmission Oil Pump First and Second Design Identification (03-07-30-056)
2003-10-29: Diagnostic Information to Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
2003-10-06: Info - VCM/PCM Replacement Due to Corrosion and/or Water Intrusion (02-06-04-020B)
2003-10-02: Per Bulletin 02-06-04-020A: PCM Will Not Fit in New Tray - corrosion fender fit left module mount no PCM position water (PI01404)
2003-09-19: Warranty Admin. - Sublet Administrative Allowance (Coverage: S) Labor Operations (03-00-89-027)
2003-08-19: Info - Higher Than Expected Oil Consumption (Greater Than 8500 GVW) (03-06-01-023)
2003-07-14: Info - J 44551 A/C Suction Screen Kit Repair Recommendations and Procedures After Catastrophic Compressor Failures (01-01-39-003A)
2003-07-14: Info - HomeLink Transceiver/Garage Door Opener Transmitter Test Kit Available As Essential Tool (01-08-97-001B)
2003-06-25: Info - Most Frequently Asked Questions and Answers for J 45096 TransFlow Transmission Oil Cooling System Flushing Machine (03-07-30-027)
2003-06-10: Service VME - Transflow Transmission Cooling System Service Tool J45096 Optional Heater Blanket - 3T40 372LE 3L30 3T40 4L30E 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60E 4T65E 4T80E 5L40E automatic fluid (PI01163)
2003-06-05: Side Cargo Door Binds (Replace Hinge Pins and Bushings) (02-08-64-012A)
2003-06-05: Info - Shift Stabilization and Tow/haul Mode Feature for Hydra-Matic 4L60-E/4L65-E and 4L80-E/4L85-E Transmissions (99-07-30-022A)
2003-04-29: Warranty Admin. - Courtesy Transportation Program (02-00-89-004B)
2003-04-24: Info - Bulletins Released Week of April 14, 2003 and Car and Truck Fix It Right the First Time Issues (03-00-89-010)
2003-03-14: Info - Automatic Air Conditioning Control Operation (99-01-39-007B)
2003-03-07: Info - A/C Refrigerant System Sealer and A/C System Leak Detection Guidelines (03-01-38-001)
2003-03-07: Info - Changes to Essential and Available Tool Numbering System (03-00-89-005)
2003-02-27: Info - Powertrain Quality Center for Performance Parts Engine Replacements (03-06-01-006)
2003-02-06: Adm Msg - OnStar Service Modules with Deactivated Settings (ONG20030007)
2003-02-04: Outside Rearview Mirror Shake or Vibration (Replace Outside Rearview Mirrors) (03-08-64-003)
2003-01-30: Rough Idle After Start, And/Or A Service Engine Soon (SES) Light (Unstick And Clean Central Sequential Fuel Injection (CSFI) Poppet Valves or Convert to MFI) (00-06-04-003B)
2003-01-29: Info - Automatic Transmission Oil Cooler Flushing and Flow Check Procedures (99-07-30-017A)
2002-12-16: Adm Msg - New Labor Time Guide Available Effective February 1, 2003 (WIW20020026)
2002-10-25: Proper Diagnostic Procedures for No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, SIR, Brake, Security, Theft, ABS, Hot, DIC Messages, Lamp, Light, Battery and Generator Diag. Testing (02-06-03-012)
2002-10-14: Diagnostic Information for Intermittent Transmission Downshift, Slip, Busy/Cycling TCC or Noisy Cooling Fan (99-07-30-016B)
2002-09-27: Rear Seat Rattle (Install Hold Down Pin Retainer Clips) (02-08-50-008)
2002-09-23: Adm Msg - Important Programming/TIS Information for Technicians (Admin Number 20020120 - 9/10/02) (VSS20020120)
2002-09-04: When Using OnStar Personal Calling Feature,the Caller Cannot Be Heard on Outbound Call Only (PI00436)
2002-08-09: Info - Engine Crankcase Flush (02-06-01-028)
2002-08-07: 6.5L L65 Diesel Engine Idle Surge, Rough Idle, or Idle Flare No DTCs (PI00140A)
2002-07-24: Warranty Admin. - Claim Procedures for Warrantable Electronic Failures on Vehicles Sold As Certified Used Vehicles or Certified Pre-Owned Vehicles (02-00-89-013)
2002-07-19: Warranty Admin. - Revised Empowerment Level-Authorization Code E (02-00-89-009)
2002-07-19: Info - Preliminary Information (PI) Text Available in Service Information (SI) (02-00-89-008)
2002-07-18: SMU - Revised DTCs B1000, B1004, B1007, B1009, B1013 (02-08-47-001)
2002-06-21: Info - Expandable Acoustic Foam (Two Component Sound Dampener) Usage with Collision Damage Repairs (02-08-98-003)
2002-06-13: Info - Automatic Transmission Serial Number and Site Code Locations (02-07-30-028)
2002-06-13: Info - Engine Identification Information (02-06-01-026)
2002-05-30: Technical-Engine Oil Leak (Replace Engine Oil Cooler Lines) (02-06-02-003)
2002-05-24: Info - DTCs B1001, B1271 or B1780 Set When Replacing/Reprogramming Other Modules (02-09-41-001)
2002-02-27: Information on a New Engine Preluber Tool (02-06-01-008)
2002-01-11: Info - Engineering Changes to Reaction Shell Thrust Washer and use of New Service Kit (02-07-30-003)
2002-01-02: SMU - Revised Ignition Lock Cylinder Replacement (02-02-35-001)
2001-12-19: SMU - Revised Engine Cranks But Does Not Run Diagnostic Table (01-06-04-057)
2001-12-18: Info - Tire Sidewall Damage (01-03-10-011)
2001-11-14: Info - Test Guidelines for Use of Essential Tool J41413-200 Evaporative System Tester (01-06-04-044)
2001-11-14: Info - Programming the HomeLink Transmitter (01-08-97-002)
2001-11-02: Exhaust System Rumble/Rattle Noise (Replace Exhaust Pipe Seals and Modify Exhaust Pipe Ring Flanges) (01-06-05-006)
2001-10-19: Security Lamp Illuminated on the IP, Engine Stalls, No Start, DTC B2960 (Security System Sensor Data Incorrect but Valid) Set (Inspect and Repair Cause of DTC B2960) (01-08-56-006)
2001-10-19: Info - 2-Cut vs. 5-Cut Rear Axle Ring and Pinion Gearsets (00-04-20-001A)
2001-10-04: Info - Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
2001-09-25: Information on Lowering Spare Tires Stored Under Vehicle (01-03-10-007)
2001-09-17: Warranty Admin. - Correct Use of Labor Operation R4490, RKE Transmitter, Replace (01-00-89-013)
2001-09-13: SMU - Revised Diagnostic Trouble Codes (DTCs) P0404, P0405, P1404 (01-06-04-043)
2001-06-25: Info - Cleaning the Cassette Tape Player and Clearing the CLN Message from the Radio Display (01-08-44-006A)
2001-06-21: Info - Seat Belt System Replacement Guidelines for Vehicles Involved in Collisions (01-09-40-002)
2001-05-08: Info - Replacement of Keys, Key Numbers and/or Security Chips (01-00-89-009)
2001-05-02: Park/Neutral Position Switch Connector Cannot Be Removed (Replace Switch and Connectors) (01-07-30-021)
2001-04-09: Info - Guidelines for Use of Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
2001-04-06: Info - Current CIPS Campaign Number to Previous DIvisional Campaign Number (01-00-89-008)
2001-04-05: Info - Release of New Power Steering Cooler Assembly (01-02-32-003)
2001-03-29: Info - New Control Valve Body, Spacer Plate and Gaskets for 4L60-E Automatic Transmission (01-07-30-012)
2001-03-02: Info - February, 2001 Bulletin Summary (01-00-89-006)
2001-02-08: Info - Recommended Rear Axle Lubricant (01-00-90-001A)
2001-02-02: Info - January, 2001 Bulletin Summary (01-00-89-005)
2001-01-03: Info - December, 2000 Bulletin Summary (01-00-89-001)
2000-12-18: Warranty Admin. - January 1, 2001 Labor Time Guide Updates (00-00-89-031)
2000-12-13: Info - New Rear Door Outside Handle/License Plate Housing (00-08-64-019)
2000-12-04: Info - November, 2000 Bulletin Summary (00-00-89-030)
2000-11-29: High Opening/Closing Effort or Misalignment of Sliding Side Door (Replace Roller Bracket) (00-08-64-010A)
2000-11-13: Warranty Admin. - December, 2000 Labor TIme Guide Updates (00-00-89-029)
2000-11-02: Info - October. 2000 Bulletin Summary (00-00-89-028)
2000-10-24: Info - The Importance of Chassis Lubrication (00-00-90-001)
2000-10-17: Warranty Admin. - November, 2000 Labor Time Guide Updates (00-00-89-025)
2000-10-06: Info - September, 2000 Bulletin Summary (00-00-89-024)
2000-09-21: Info - Correct Diagnostic Procedure When Reviewing A/C Performance/Leak Suspected (00-01-38-007)
2000-09-19: Warranty Admin. - October, 2000 Labor Time Guide Updates (00-00-89-023)
2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
2000-08-17: Air/Windnoise Around Front Door (Use All Service Procedures) (00-08-64-009)
2000-08-17: Warranty Admin. - Cross-line Warranty (00-00-89-021)
2000-08-14: Warranty Admin. - September, 2000 Labor Time Guide Updates (00-00-89-020)
2000-08-10: Warranty Admin. - New Electrical Relay Labor Operation Numbers (00-00-89-019)
2000-08-08: Info - July, 2000 Bulletin Summary (00-00-89-018)
2000-08-03: Info - Essential Tool J 43600 ACR 2000 (00-01-38-006)
2000-08-01: SMU - Revised DTC Tables for P0716 and P0717 (Section 7 - Auto Trans) (00-07-30-015)
2000-07-21: Power Antenna Not Working Properly/Inop (Replace Antenna O-Ring Assembly) (00-08-44-006A)
2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
2000-06-19: Warranty Admin. - July, 2000 Labor Time Guide Updates (00-00-89-014)
2000-06-19: Warranty Admin.- PCM Product Feedback Program (00-06-04-026)
2000-06-08: Info - California Consent Order on Settlement of Lawsuit on Batteries (Prop 65) (00-06-03-006)
2000-06-06: Info - May, 2000 Bulletin Summary (00-00-89-013)
2000-05-15: Info - Proper Service of Quick Connect EVAP System Connectors (00-06-04-021)
2000-05-12: Warranty Admin. - June, 2000 Labor TIme Guide Updates (00-00-89-012)
2000-05-11: Front Disc Brake Squeal (Install New Front Disc Brake Pads) (00-05-23-003)
2000-05-08: Info - Brake Fluid Level and Filling Recommendations (00-05-22-004)
2000-05-03: Stall/Surge at Stop or Shifting to Drive/Reverse (Install Updated Calibration) (00-07-30-006)
2000-05-03: Info - April, 2000 Bulletin Summary (00-00-89-011)
2000-05-02: Rough Idle/Hard/No Start (Replace Fuel Tank Fill Pipe Assm/Clean Poppet Valves) (00-06-04-018)
2000-04-14: Warranty Admin. - May, 2000 Labor Time Guide Updates (00-00-89-010)
2000-04-04: Info - March, 2000 Bulletin Summary (00-00-89-007)
2000-04-04: Product Safety 00028 - Power Steering Cooler Hose Separation (00028)
2000-03-21: Info - Essential Tool J 43690 - Rod Bearing Clearance Checking Tool (00-06-01-007)
2000-03-14: Info - February, 2000 Bulletin Summary (00-00-89-006)
2000-01-19: February, 2000 Labor Time Guide Updates (00-00-89-001)
2000-01-13: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
2000-01-05: Engine Runs Hot, Overheats, Loss of Coolant (Polish Filler Neck/Replace Radiator Cap) (00-06-02-001)
2000-01-04: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (99-09-41-004)
1999-12-22: Information on 2000 bill 101 French Label Installation Procedure (99-00-89-024)
1999-12-10: Warranty Admin. - January, 2000 Labor Time Guide Updates (99-00-89-023)
1999-12-06: Info - The Year 2000 (Y2K) and Vehicle Electronics (99-00-89-022)
1999-11-08: Accessory Receptacle is Inoperative (Check Aftermarket Device Plug) (99-08-45-005)
1999-10-26: Info - PCM Reprogramming (99-06-04-053)
1999-10-26: Info-Proper Setting of IP Dimmer to View PRNDL w/Auto Headlamp Control (99-08-42-009)
1999-10-22: Informational - CS-144 Generator Replacement (99-06-03-011)
1999-10-20: Info - Radiator Repair/Replacement Guidelines (99-06-02-017)
1999-10-14: November, 1999 Labor Time Guide Updates (99-00-89-020)
1999-10-08: Warranty Administration - October, 1999 Labor Time Guide Updates (99-00-89-017)
1999-10-06: Info - Cassette Player Cleaning and Maintenance (99-08-44-008)
1999-10-04: Info -6.5L Diesel Product Changes for the 2000 Model Year (99-06-04-044)
1999-09-24: Info - Changes in GM Service Information for the 2000 Model Year (99-00-89-018)
1999-09-02: Tech - Brake Lead/Pull and Frt Brake Wear (Repl. Frt Brake Pads, Rr Brake Shoes) (99-05-24-001A)
1999-08-10: Warranty Admin - September, 1999 Labor Time Guide Updates (99-00-89-016)
1999-08-06: Info - Fixed Mast Antenna Installation Torque Requirements (99-08-44-007)
1999-08-04: Info - Location of Diagnosis in the Service Manuals (99-00-89-014)
1999-07-29: Info - Compact Disc (CD) Players and Compatible CDs (99-08-44-006)
1999-07-28: Warranty Admin - August, 1999 Labor Time Guide Updates (99-00-89-012)
1999-06-25: Warranty Admin - July 1999 Labor Time Guide Updates (99-00-89-010)
1999-05-19: June 1999 Labor Time Guide Updates (99-00-89-008)
1999-04-06: Labor Time Guide Updates - April 1999 (99-00-89-004)
1999-03-09: Labor Time Guide Updates (99-00-89-003)