Fluid Leak From The Extension Housing Seal On 4L80E/4L85E Transmission - keywords engineering investigate prop shaft yoke
| Subject: | Fluid Leak From The Extension Housing Seal On 4L80E/4L85E Transmission |
| Models: | 2007 Chevrolet Express Van 2500/3500, Silverado Classic 2500 |
| 2007 GMC Savana Van 2500/3500, Sierra Classic 2500 |
| Equipped With a 4L80E/4L85E Transmission RPO MT1 or MN8 and Two Wheel Drive |
The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.
Condition/Concern:
Transmission fluid coming out of the transmission extension housing seal on either the 4L80E or 4L85E transmissions.
Recommendation/Instructions:
Until September 30, 2007, GM Powertrain Division is requesting that additional parts be replaced and returned for analysis of extension housing seal leaks. If a fluid leak is diagnosed as coming from the transmission extension housing seal (use fluid dye if necessary), please replace the extension housing and seal together, without removing the seal from the housing. Also replace the slip yoke to facilitate analysis of the yoke and seal inner diameter.
Use Labor Operation K6390: Housing and/or Housing to Case O-Ring Seal or Gasket, Extension - Replace.
After September 30, 2007, please disregard this request and repair the fluid leak condition in the normal manner.
Please follow this diagnostic or repair process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.
