HVAC

All Component Locator

• HVAC Component Views
• HVAC Components

All Description and Operation

• Accumulator Description
• Air Conditioning (A/C) System Description
• Air Distribution System Description
• Compressor Description
• Condenser Description
• Control Assembly Description
• Evaporator Description
• Expansion (Orifice) Tube Description
• Handling of Refrigerant Lines and Fittings
• Handling Refrigerant R-134a
• Heater Core Description
• Heater System Description
• HVAC Air Delivery/Temperature Control Circuit Description
• HVAC Blower Controls Circuit Description
• HVAC Compressor Controls Circuit Description
• Maintaining Chemical Stability
• Refrigeration System Description
• Relays and Sensors Description
• Temperature Control Motor Circuit Description

All Special Tools and Equipment

• Special Tools

All Visual Identification

• HVAC Connector End Views

Cleaning, Inspection, and Adjustment

• Compressor Leak Testing

Diagnostic Procedures

• Blower Motor Always On
• Blower Motor High Speed Inoperative
• Blower Motor Inoperative at Any Speed
• Blower Motor Inoperative Med-1
• Blower Motor Inoperative Med-2
• Blower Motor Low Speed Inoperative
• Blower Motor Operates at High Speed Only
• Cold Drafts on Floor
• Defrosting Insufficient
• Heating Insufficient
• HVAC Blower Controls System Check
• Noise Diagnosis
• Temperature Control Inoperative

Disassembly, Overhaul, Repair, and Assembly

• Air Conditioning Clutch Coil Installation
• Air Conditioning Clutch Coil Removal
• Clutch Rotor and Bearing Removal
• Clutch Rotor and/or Bearing Install
• Compressor Clutch Plate and Hub Assembly Removal
• Compressor Clutch Plate/Hub Assembly Install
• Compressor Control Switches Install
• Compressor Control Switches Removal
• Compressor Control Valve Assembly Install
• Compressor Control Valve Assembly Removal
• Compressor Pressure Relief Valve Installation
• Compressor Pressure Relief Valve Removal
• Compressor Shaft Seal Install
• Compressor Shaft Seal Removal

Electrical/Electronic Schematic Diagrams

• HVAC Air Delivery/Temperature Control Schematics
• HVAC Blower Control Schematics
• HVAC Compressor Control Schematics
• HVAC Schematic Icons
• HVAC Schematic References

General Diagnostic Information

• CCOT Air Conditioning (A/C) System Diagnosis
• Cooling Insufficient - Air Conditioning (A/C) Inoperative
• Functional Check
• Leak Testing
• Odor Diagnosis
• Refrigerant System Checks
• System Performance Test
• Vacuum System

Mechanical Specifications

• Compressor Specifications
• Fastener Tightening Specifications
• Fitting and Line Tightening Specifications

Other Specifications

• GM SPO Group Numbers
• Refrigerant Oil Distribution Specifications
• System Capacities

Removal, Installation, and Replacement

• Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement
• Air Conditioning Accumulator Replacement
• Air Conditioning Compressor Hose Replacement
• Air Conditioning Compressor Replacement
• Air Conditioning Condenser Replacement
• Air Conditioning Evaporator Core Replacement
• Air Distributor Duct Replacement
• Air Inlet Assembly Replacement
• Blower Motor and Fan Replacement
• Blower Motor Resistor Replacement
• Compressor Relay Replacement
• Compressor Sealing Washers Replacement
• Control Assembly Replacement
• Defroster Air Outlet Replacement
• Defroster Valve Actuator Replacement
• Evaporator and Accumulator Hose Assembly
• Evaporator Tube Replacement
• Floor Air Outlet Replacement
• Heater Core Replacement
• Lap Air Outlet Replacement
• Mode Valve Actuator Replacement
• O-Ring Replacement
• Odor Correction
• Refrigerant Recovery and Recharging
• Temperature Actuator Replacement