Intermittent No Crank And/Or Discharged Battery - keywords charge dead draw fuse generator load low

The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in this PI.

Some owners may comment of an intermittent no crank and/or dead battery. This concern could be caused by a loose connection at the 175 Amp Mega Fuse located on the passenger side of the cowl, as shown below. A poor connection at this fuse can either cause the battery not to charge while the vehicle is running and/or no power to the UBEC when trying to crank the vehicle. In either case, the end result will likely be a no crank concern.

Check for proper torque of the 175 Amp mega fuse nuts. If either of the nuts is below spec, remove the nuts and inspect the fuse, cables, nuts and holder for corrosion, arcing, or signs of overheating. Replace any damaged components and retorque to spec.

Please follow this diagnostic or repair process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.