Maintenance Schedule - Short Trip/City. Generic Unit Repair 2004

For 1990-2009 cars only

Makes 🢒 Generic 🢒 2004 🢒 Unit Repair 🢒 General Information 🢒 Maintenance and Lubrication 🢒 Maintenance Schedule - Short Trip/City

Maintenance Schedule - Short Trip/City Example

Important: Additional maintenance recommendations are in this subsection. Also refer to Owner Checks and Services , Periodic Maintenance Inspection .

The services shown in this schedule up to 166 000 km (100,000 mi) should be performed after 166 000 km (100,000 mi) at the same intervals. The services shown at 240 000 km (150,000 mi) should be performed at the same interval after 240 000 km (150,000 mi).

Footnotes

[Dagger] The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the useful life of the vehicle. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

If your vehicle has a GM Oil Life System, a computer system that lets you know when to change the engine oil and filter. This is based on engine revolutions and engine temperature and not on mileage. Based on driving conditions, the mileage at which an oil change will be indicated can vary considerably. For the oil life system to work properly, you must reset the system every time the oil is changed.

When the system has calculated that oil life has been diminished, it will indicate that an oil change is necessary. A CHANGE ENGINE OIL message will come on. Change your oil as soon as possible within the next two times you stop for fuel. It is possible that, if you are driving under the best conditions, the oil life system may not indicate that an oil change is necessary for over a year. However, your engine oil and filter must be changed at least once a year and at this time the system must be reset. It is also important to check your oil regularly and keep it at the proper level.

If the system is ever reset accidentally, you must change your oil at 5,000 km (3,000 mi) since your last oil change. Remember to reset the oil life system whenever the oil is changed. Refer to GM Oil Life System Resetting .

Whenever the tires are rotated, the Check Tire Pressure System, if equipped must be reset. Refer to Tire Pressure Monitor Procedure in Tire Pressure Monitoring.

+ A good time to check the brakes is during tire rotation. Refer to Brake Pad Inspection in Disc Brakes.

5 000 km (3,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

10 500 km (6,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

15 000 km (9,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

20 500 km (12,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

25 000 km (15,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Inspect engine air cleaner filter. If necessary, replace the filter. If vehicle is driven in dusty/dirty conditions, inspect filter at every engine oil change. Refer to Air Cleaner Element Replacement in Engine Controls.

•	Replace passenger compartment air filter. If you drive regularly under dusty conditions, the filter may require replacement more often. Refer to Passenger Compartment Air Filter Replacement in Heating, Ventilation and Air Conditioning.

30 000 km (18,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

35 000 km (21,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

40 000 km (24,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

45 000 km (27,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

50 000 km (30,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Replace passenger compartment air filter. If you drive regularly under dusty conditions, the filter may require replacement more often. Refer to Passenger Compartment Air Filter Replacement in Heating, Ventilation and Air Conditioning.

•	Inspect engine air cleaner filter. If necessary, replace the filter. If vehicle is driven in dusty/dirty conditions, inspect filter at every engine oil change. Refer to Air Cleaner Element Replacement in Engine Controls.

•	For supercharged engine only: Check the supercharger oil level and add the proper supercharger oil as needed or every 36 months, whichever occurs first. Refer to Supercharger Oil Level Inspection in Engine Mechanical.

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

55 000 km (33,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

60 000 km (36,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

65 000 km (39,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

70 000 km (42,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

75 000 km (45,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Replace passenger compartment air filter. If you drive regularly under dusty conditions, the filter may require replacement more often. Refer to Passenger Compartment Air Filter Replacement in Heating, Ventilation and Air Conditioning.

•	Inspect engine air cleaner filter. If necessary, replace the filter. If vehicle is driven in dusty/dirty conditions, inspect filter at every engine oil change. Refer to Air Cleaner Element Replacement in Engine Controls.

80 000 km (48,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

83 000 km (50,000 mi)

•	Change the automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions:

-	In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher

-	In hilly or mountainous terrain

-	When doing frequent trailer towing

-	Uses such as found in taxi, police or delivery service

•	If the vehicle is not used under any of these conditions, change the automatic transaxle fluid and filter at 166 000 km (100,000 mi).

85 000 km (51,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

90 000 km (54,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

95 000 km (57,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first. An Emission Control Service *.

100 000 km (60,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Replace passenger compartment air filter. If you drive regularly under dusty conditions, the filter may require replacement more often. Refer to Passenger Compartment Air Filter Replacement in Heating, Ventilation and Air Conditioning.

•	Inspect engine accessory drive belt. Replace if needed. Refer to Drive Belt Replacement in Engine Mechanical.

•	Inspect engine air cleaner filter. If necessary, replace the filter. If vehicle is driven in dusty/dirty conditions, inspect filter at every engine oil change. Refer to Air Cleaner Element Replacement in Engine Controls.

•	For supercharged engine only: Check the supercharger oil level and add the proper supercharger oil as needed or every 36 months, whichever occurs first. Refer to Supercharger Oil Level Inspection in Engine Mechanical.

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

105 000 km (63,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

110 000 km (66,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

115 000 km (69,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

120 000 km (72,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

125 000 km (75,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Inspect engine air cleaner filter. If necessary, replace the filter. If vehicle is driven in dusty/dirty conditions, inspect filter at every engine oil change. Refer to Air Cleaner Element Replacement in Engine Controls.

•	Replace passenger compartment air filter. If you drive regularly under dusty conditions, the filter may require replacement more often. Refer to Passenger Compartment Air Filter Replacement in Heating, Ventilation and Air Conditioning.

130 000 km (78,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

135 000 km (81,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

140 000 km (84,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

145 000 km (87,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

150 000 km (90,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Replace passenger compartment air filter. If you drive regularly under dusty conditions, the filter may require replacement more often. Refer to Passenger Compartment Air Filter Replacement in Heating, Ventilation and Air Conditioning.

•	Inspect engine air cleaner filter. If necessary, replace the filter. If vehicle is driven in dusty/dirty conditions, inspect filter at every engine oil change. Refer to Air Cleaner Element Replacement in Engine Controls.

•	For supercharged engine only: Check the supercharger oil level and add the proper supercharger oil as needed or every 36 months, whichever occurs first. Refer to Supercharger Oil Level Inspection in Engine Mechanical.

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

155 000 km (93,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

160 000 km (96,000 mi)

•	Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

•	Rotate tires. Refer to Tire Rotation in Tires and Wheels.

An Emission Control Service +.

165 000 km (99,000 mi)

Change engine oil and filter or every 3 months, whichever occurs first.

An Emission Control Service [Dagger].

166 000 km (100,000 mi)

•	Inspect spark plug wires.

An Emission Control Service +.

•	Replace spark plugs. Refer to Spark Plug Replacement in Engine Controls.

•	Change the automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions:

-	In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher

-	In hilly or mountainous terrain

-	When doing frequent trailer towing

-	Uses such as found in taxi, police or delivery service

•	If you have not used the vehicle under severe service conditions listed previously, and therefore haven`t changed the automatic transaxle fluid, change both the fluid and filter.

240 000 km (150,000 mi)

•	Drain, flush and refill cooling system or every 60 months since last service, whichever occurs first. Refer to Cooling System Draining and Filling in Engine Cooling. For information on the proper coolant to use, refer to Fluid and Lubricant Recommendations .

•	Inspect the hoses.

•	Clean radiator, condenser, pressure cap and neck. If there is a loss of coolant, refer to Loss of Coolant in Engine Cooling.

•	Inspect engine accessory drive belt. Replace if needed. Refer to Drive Belt Replacement in Engine Mechanical.