GM Service Manual Online
For 1990-2009 cars only
Makes 🢒 HUMMER 🢒 2004 🢒 H2 🢒 Bulletins 🢒 2003-2005 Hummer H2 Vehicle Sits Low or the Suspension Sags Overnight - keywords AIR control DTC ECAS ELC electronic height inoperative leak MIL module rear spring trim

2003-2005 Hummer H2 Vehicle Sits Low or the Suspension Sags Overnight - keywords AIR control DTC ECAS ELC electronic height inoperative leak MIL module rear spring trim

Subject:2003-2005 H2 Hummer Vehicle Sits Low or the Suspension Sags Overnight

Models:


The following diagnosis might be helpful if the vehicle exhibits the symptom(s) described in the PI.

Condition/Concern:

Some customers may comment that the rear of the vehicle sits low and/or the suspension sags overnight.

Recommendation/Instructions:

Check the following locations for a leak using a soap and water solution in a spray bottle.

  1. Left and Right Inlet Valves.
  2. Exhaust Valve.
  3. Suspension Air Supply Lines that run from the Inlet Valves to the Right and Left Air Springs (Airbags).
  4. Air Spring fittings and the Air Spring itself.

Leakage can produce big bubbles or just some beer like foam appearance. If the leak is isolated to the valve block assembly, do not replace the entire compressor assembly. The valve block can be obtained separately by ordering part number 88982408 for the single stage compressor or part number 89060584 for the dual stage compressor.

Please follow this diagnosis process thoroughly and complete each step. If the condition exhibited is resolved without completing every step, the remaining steps do not need to be performed.

Models:

(2003-2005 Hummer H2)