Name | Location | Locator View | Connector End View |
|---|---|---|---|
A/C Compressor Clutch (C60) | On the upper right front of the engine, on the front of A/C compressor behind pulley, part of the A/C compressor | ||
A/C High Pressure Switch (C60) | At the right front, behind the front bumper, on the top of A/C condenser receiver/dryer | ||
A/C-Wiper Diode | In the lower I/P harness, behind the lower center of the I/P, part of splice pack SP201, taped to the harness between the windshield wiper motor breakout and the bulkhead connector C200, behind the radio, pins A2, B2 and C2 | ||
ABS Relay (JE4) | On the front chassis harness, behind the cab at the cab bridge, mounted to the bottom of the radiator surge tank | ||
Accelerator Pedal Position (APP) Sensor | Behind the left side of the I/P, right of the steering column, above the accelerator pedal | ||
Air Brake Dryer (JE4 and JTU) | On the left side of the frame in the component box | ||
Air Brake Pressure Gage Lamp (JE4) | On the left side of the I/P, left of the IPC and below the driver information center (DIC), in the air brake pressure gage | ||
Air Compressor (K16) | Behind the cab at the outboard left frame rail, inboard of and above the fuse block assembly enclosure | ||
Air Compressor Relay (K16) | Behind the cab at the outboard left frame rail, inboard of and above the fuse block assembly enclosure, in the air compressor harness | ||
Air Suspension Dump Indicator (G40/G45/GSJ) | In the top of the center console | ||
Air Suspension Dump Switch (G40/G45/GSJ) | In the top of the center console | ||
Air Suspension Dump Valve Solenoid (G40/G45/GSJ) | On the inboard right frame rail, rear of the axle, in the air suspension dump valve | ||
Air Temperature Actuator | Behind the lower right side of the I/P, near the blower motor, on the front of the HVAC module | ||
Antenna | On the exterior upper left A-pillar | -- | -- |
Auto Cruise Switch (K34) | Center of the I/P, in the switch panel | ||
Auto Cruise Switch/PTO Switch Diode | In the lower I/P harness, behind the lower center of the I/P, taped to the harness between the windshield wiper motor breakout and bulkhead connector C200, behind the radio | ||
Automatic Transmission Input Shaft Speed (AT ISS) Sensor (A/T) | On the upper left side of the transmission, on the transmission bell housing | ||
Automatic Transmission Input Shaft Speed (AT ISS) Sensor (A/T) | On the lower right side of the transmission, on the transmission bell housing | ||
Automatic Transmission Shift Lever Position Indicator (A/T) | In the center console, part of the automatic transmission shift lever | ||
Automatic Transmission Shift Selector (A/T) | On the left side of the center console housing, at the top | ||
Auxiliary Power Post (-) | In the center console | -- | |
Auxiliary Power Post (+) | In the center console | -- | |
Backup Alarm (UZF) | On the back of the rear crossmember, on a bracket | ||
Backup Lamp - Left | At the rear of the left frame rail, part of the tail lamp assembly - left | ||
Backup Lamp - Right | At the rear of the right frame rail, part of the tail lamp assembly - right | ||
Backup Lamp Switch (A/T) | On the lower left side of the transmission, part of the park/neutral position (PNP) switch | ||
Backup Lamp Switch (A/T) | Internal to the automatic transmission | ||
Backup Lamp Switch (M/T) | On the top forward right side of the transmission cover | ||
Battery - Inboard | On the outboard side of the right frame rail, in the battery box | -- | |
Battery - Outboard | On the outboard side of the right frame rail, in the battery box | -- | |
Blower Motor (C40/C60) | Behind the lower right side of the I/P | ||
Blower Motor Resistor Assembly (C40/C60) | Behind the lower right side of the I/P, on the front of the blower case, left of the blower motor | ||
Blower Motor Switch (C40/C60) | In the center of the I/P, above the radio, mounted in the HVAC control assembly | ||
Brake Fluid Level Switch (JE3) | At the front of the vehicle, behind the front bumper right side, on the front of the brake master cylinder reservoir | ||
Brake Pressure Modulator Valve (BPMV) - LF (JE4) | On the left rear side of the front crossmember | ||
Brake Pressure Modulator Valve (BPMV) - LR (JE4) | On the left side of the crossmember forward of the rear axle | ||
Brake Pressure Modulator Valve (BPMV) - RF (JE4) | On the right rear side of the front crossmember | ||
Brake Pressure Modulator Valve (BPMV) - RR (JE4) | On the right side of the crossmember forward of the rear axle | ||
Camshaft Position (CMP) Sensor | On the back end of the cylinder head | ||
Chime Module | Under the passenger seat, at the front, mounted on the back of the seat stand cover | ||
Cigar Lighter | In the center of the I/P, right of the radio | ||
Cigar Lighter Lamp | In the center of the I/P, left of the radio | ||
Clearance Lamp - Left | On top of the roof, on the forward left outboard side of the cab | ||
Clearance Lamp - Right | On top of the roof, on the forward right outboard side of the cab | ||
Clutch Pedal Position (CPP) Switch (M/T) | Behind the left side of the I/P, left of the steering column, on the clutch pedal support bracket, at the beginning of clutch pedal travel | ||
Clutch Start Switch (M/T) | Behind the left side of the I/P, left of the steering column, on the clutch pedal support bracket, at the end of clutch pedal travel | ||
Condenser Fan Motor | At the lower right front of the vehicle, in front of the tire, behind the A/C condenser | ||
Controller Area Network (CAN) Connector | On the lower left side of the I/P, left of the steering column, by the data link connector (DLC) | ||
Coolant Level Switch | Behind the cab at the cab bridge, on the bottom of the radiator surge tank | ||
Crankshaft Position (CKP) Sensor (A/T) | On the top center of the flywheel housing | ||
Crankshaft Position (CKP) Sensor (M/T) | On the lower left front of the flywheel housing | ||
Cruise Control Set/Coast Switch (K34) | On the left side of the steering column, controlled by the turn signal/multifunction lever, part of the turn signal/multifunction switch | ||
Data Link Resistor 1 | In the front chassis harness, taped to the harness, near the left inboard frame rail next to the radiator fan | ||
Data Link Resistor 2 | In the lower I/P harness, under the passenger seat, near the chime module, taped to the harness | ||
Data Link Resistor 3 | In the lower I/P harness, under left side of the I/P, taped to the harness | ||
Data Link Connector (DLC) | On the lower left side of the I/P, left of the steering column | ||
Data Recorded Module (LF8) | Under passenger seat, near CHIME module | ||
Diesel Particulate Filter (DPF) Exhaust Temperature Sensor 1 (LF8) | On the right side of the vehicle center in front of the catalytic converter | ||
Diesel Particulate Filter (DPF) Exhaust Temperature Sensor 2 (LF8) | On the right side of the vehicle center in front of the catalytic converter | ||
Diesel Particulate Filter (DPF) Pressure Sensor (LF8) | On the right side of vehicle center area | ||
Differential Lock Control Valve (HNB, HPL or HPN) | On the front of the crossmember in front of the rear axle | ||
Differential Lock Switch (HNB, HPL or HPN) | In the top of the center console | ||
Dome Lamp | In the interior center of the roof | ||
Dome Lamp Diode | In the lower I/P harness, behind the lower center of the I/P, part of splice pack SP201, taped to the harness between the windshield wiper motor breakout and bulkhead, pins G2, H2, J2 and K2 | ||
Door Jamb Switch - Driver | In the left front door frame, at the rear face of the opening | ||
Driver Information Center (DIC) | On the left side of the I/P, left of the IPC | ||
DRL Engine Run Diode | In the lower I/P harness, behind the lower center of the I/P, part of splice pack SP201, taped to the harness between the windshield wiper motor breakout and the bulkhead connector C200, behind the radio, pins G1, H1, J1 and K1 | ||
DRL Indicator Diode | In the lower I/P harness, taped to the harness, behind the lower center of the I/P, part of splice pack SP201, between the windshield wiper motor breakout and the bulkhead, pins D1, E1 and F1 | ||
DRL Indicator Relay | In the lower I/P harness, behind the lower right side of the I/P, near the blower motor, on the relay bracket, position 4 | ||
DRL Off Relay | In the lower I/P harness, behind the lower right side of the I/P, near the blower motor, on the relay bracket, position 3 | ||
DRL On Diode | In the lower I/P harness, behind the lower center of the I/P, part of splice pack SP201, taped to the harness between the windshield wiper motor breakout and bulkhead, pins A1, B1, and C1 | ||
DRL On Relay | In the lower I/P harness, behind the lower right side of the I/P, near the blower motor, on the relay bracket, position 2 | ||
DRL Resistor | In the lower I/P harness, at the data link connector (DLC) breakout, behind the IPC | ||
Electronic Brake Control Module (EBCM) (JE3) | Behind center of the front bumper | ||
Electronic Brake Control Module (EBCM) (JE4) | Behind center of the front bumper | ||
Engine Control Module (ECM) | On top of the left front frame rail, forward of the cab bridge, left of the engine | ||
Engine Coolant Temperature (ECT) Sensor | On the upper left side of the engine, in the cylinder head, below the coolant inlet | ||
Engine Oil Level Switch | On the lower left side of the engine, near the center, in the oil pan | ||
Engine Oil Pressure (EOP) Sensor | On the lower right side of the engine, toward the front | ||
Evaporator Temperature Sensor (C60) | At the front right of the exterior cab, behind the inspection panel, in the A/C evaporator housing | ||
Exhaust Brake Actuator Control Solenoid Valve (K40 or NPE) | On the inboard right frame rail, forward of the second crossmember, by the batteries | ||
Exhaust Brake Relay (K40 or NPE) | In the lower center of the I/P, behind the access panel, attached to the left side of relay block 2, in the center position | ||
Exhaust Brake Switch (K40) | On the center of the I/P, right of the IPC | ||
Exhaust Gas Recirculation (EGR) Valve | On the upper left side of the engine, center, on the intake manifold, behind secondary fuel filter | ||
Exhaust Gas Recirculation (EGR) Temperature Sensor (LF8) | On the left side of the engine, below the EGR valve, behind the secondary fuel filter | ||
Exhaust Temperature Sensor (LF8) | On the right side of top of the engine, behind A/C compressor, in the EGR inner cooler pipes. | ||
Fuel Heater (C30) | On the lower left side of the engine, part of the secondary fuel filter | ||
Fuel Heater Relay (C30) | In the lower I/P harness, behind the lower right side of the I/P, near the blower motor, on the relay bracket, position 5 | ||
Fuel Injector 1 | On the upper left side of the engine, in the cylinder head, under the valve cover, at cylinder 1 | -- | |
Fuel Injector 2 | On the upper left side of the engine, in the cylinder head, under the valve cover, at cylinder 2 | -- | |
Fuel Injector 3 | On the upper left side of the engine, in the cylinder head, under the valve cover, at cylinder 3 | -- | |
Fuel Injector 4 | On the upper left side of the engine, in the cylinder head, under the valve cover, at cylinder 4 | -- | |
Fuel Injector 5 | On the upper left side of the engine, in the cylinder head, under the valve cover, at cylinder 5 | -- | |
Fuel Injector 6 | On the upper left side of the engine, in the cylinder head, under the valve cover, at cylinder 6 | -- | |
Fuel Rail Pressure (FRP) Sensor | On the rear left side of the engine, on the injection pump | ||
Fuel Sender (NG7, NJ7, NK6, NJ8, NNQ or NNV) | On the outboard side of the left frame rail, in the top of the fuel tank | ||
Fuel Sender - Secondary (NG7, NJ7, NJ8 or NNQ) | On the outboard side of the right frame rail, in the top of the fuel tank | ||
Fuel Temperature Sensor | On the lower left side of the engine, at the rear, on the fuel injection pump | ||
Fuse Block - I/P - 1 | In the right top of the I/P, under the access panel | ||
Fuse Block - I/P - 2 | In the right top of the I/P, under the access panel | ||
Fuse Block - 1 | Behind the cab at the outboard left frame rail, under a cover, on top of the front chassis harness fuse block bracket, in the fuse box, rear | ||
Fuse Block - 2 | Behind the cab at the outboard left frame rail, under a cover, on top of the front chassis harness fuse block bracket, in the fuse box, front | ||
Fusible Link 1 | In the front chassis harness, from the positive battery ring terminal to C402 | -- | |
Fusible Link 2 | In the front chassis harness, from the positive battery ring terminal to C402 | -- | |
Fusible Link 3 | In the front chassis harness, from the positive battery ring terminal to C400 | -- | |
Fusible Link 4 | In the front chassis harness, from the positive battery ring terminal to C400 | -- | |
Generator | At the right side of the engine | ||
Glow Plug 1 | On the upper left side of the engine, in the cylinder head, at cylinder 1 | -- | |
Glow Plug 2 | On the upper left side of the engine, in the cylinder head, at cylinder 2 | -- | |
Glow Plug 3 | On the upper left side of the engine, in the cylinder head, at cylinder 3 | -- | |
Glow Plug 4 | On the upper left side of the engine, in the cylinder head, at cylinder 4 | -- | |
Glow Plug 5 | On the upper left side of the engine, in the cylinder head, at cylinder 5 | -- | |
Glow Plug 6 | On the upper left side of the engine, in the cylinder head, at cylinder 6 | -- | |
Glow Plug Bus 1 | On the upper left side of the engine, on the cylinder head, connects glow plugs 1, 2 and 3 to glow plug bus 2 | -- | -- |
Glow Plug Bus 2 | On the upper left side of the engine, on the cylinder head, connects glow plugs 4, 5 and 6 to glow plug bus 1 | -- | -- |
Glow Plug Control Module (GPCM) | On the left front side of engine, below EGR valve | ||
Glow Plug Relay | Behind the left side of the I/P, attached to the inspection panel release mounting bracket, above hood release lever | ||
Hazard Switch | On the right side of the steering column, controlled by the multifunction lever, part of the turn signal/multifunction switch | ||
Headlamp - High Beam - Left | On the left front of the cab | ||
Headlamp - High Beam - Right | On the right front of the cab | ||
Headlamp - Low Beam - Left | On the left front of the cab | ||
Headlamp - Low Beam - Right | On the right front of the cab | ||
Headlamp Dimmer Switch | On the left side of the steering column, controlled by the turn signal/multifunction lever, part of the turn signal/multifunction switch | ||
Headlamp Switch | On the left side of the steering column, controlled by the turn signal/multifunction lever, part of the turn signal/multifunction switch | ||
High Idle Switch (UF3) | On the center of the I/P, right of the IPC | ||
Horn (w/o U08) | On the front of the vehicle, behind the left side of the front bumper impact bar | ||
Horn, A-Note (U08) | On the front of the vehicle, behind the left side of the front bumper impact bar | ||
Horn, F-Note (U08) | On the front of the vehicle, behind the left side of the front bumper impact bar | ||
Horn Switch | In the steering column, under the steering wheel horn cap and cover assembly, part of the turn signal/multifunction switch | ||
HVAC Control Assembly | In the center of the I/P, above the radio | ||
Hydromax Fuse (JE3) | Above the left frame rail, on the cab bridge harness bracket, below the coolant reservoir | ||
I/P Dimmer Switch | On the left side of the I/P, in the instrument panel cluster (IPC) | ||
Identification (ID) Lamp - Center | On top of the roof, on the forward center of the cab | ||
Identification (ID) Lamp - Left | On top of the roof, on the forward left side of the cab, the inboard lamp | ||
Identification (ID) Lamp - Right | On top of the roof, on the forward right side of the cab, the inboard lamp | ||
Ignition Switch | On the right side of the steering column, behind the steering wheel assembly | ||
Instrument Panel Cluster (IPC) | On the left side of the I/P | ||
Intake Manifold Air (IMA) Temperature Sensor (LF8) | On the left side, in the center area of the engine | ||
Low Air Pressure Switch - Primary (JE4) | Inboard of the left frame rail, on the front end of the front axle (primary) service (air supply) reservoir | ||
Low Air Pressure Switch - Secondary (JE4) | On the left end of the rear axle (secondary) service (air supply) reservoir, inboard of the left frame rail | ||
Low Air Pressure Switch (JE3 and K16 or JE4 and KK3) | Inboard of the left frame rail, on the front end of the primary air supply reservoir | ||
Low Air Pressure Switch (JE3 and K16) | Inboard of the left frame rail, on the front end of the primary air supply reservoir | ||
Manifold Absolute Pressure (MAP) Sensor | On the upper left side of the engine, on the top rear of the intake manifold air inlet elbow | ||
Marker Lamp Switch (JE4 and RQ2 and U86 or JE4 and RQ3) | On the center of the I/P, right of the IPC | ||
Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor | By the outboard right frame rail, behind the air cleaner, on the upper front of the air intake elbow | ||
Mode Actuator | Behind the lower right side of the I/P, on the bottom of the blower case | ||
Neutral Relay (A/T) | In the transmission cab harness, under the passenger seat, on the top left front edge of the seat bracket, position 2 | ||
Oil Level Sensor (A/T) | Internal to the automatic transmission | -- | -- |
Outside Heated Mirror Switch (DNN) | On the center of the I/P, right of the IPC | ||
Outside Rearview Mirror - Driver (DNA) | On the exterior side of the left door | ||
Outside Rearview Mirror - Passenger (DNA) | On the exterior side of the right door | ||
Overdrive (OD) Defeat Switch (A/T) | On the center of the I/P, right of the IPC | ||
Overdrive Diode (A/T) | In the transmission cab harness, under the passenger seat, near the transmission control module (TCM), taped to the harness breakout near the TCM | ||
Park Brake Indicator/Park Brake Switch Diode (JE3) | In the lower I/P harness, behind the lower center of the I/P, taped to the harness between the windshield wiper motor breakout and bulkhead connector C200, behind the radio | ||
Park Brake Relay | In the lower I/P harness, behind the lower right side of the I/P, near the blower motor, on the relay bracket, position 1 | ||
Park Brake Switch (JE3) | In the center console, on the park brake lever bracket | ||
Park Brake Switch (JE4) | In the center of the I/P, below the radio | ||
Park/Turn Signal Lamp - LF | On the front of the vehicle, above the left front bumper, mounted to a bracket | ||
Park/Turn Signal Lamp - RF | On the front of the vehicle, above the right front bumper, mounted to a bracket | ||
Power Brake (P/B) Booster Fluid Flow Switch (JE3) | At the front of the vehicle, behind the bumper center of the vehicle | ||
Power Brake (P/B) Booster Pump Motor (JE3) | At the front of the vehicle, behind the center of the bumper, on the brake master cylinder | ||
Power Brake (P/B) Booster Pump Relay (JE3) | In the front chassis harness, above the left frame rail, on the cab bridge harness bracket, below the coolant reservoir | ||
Power Take-Off Switch (PTO) | On the center of the I/P, right of the IPC | ||
PTO Relay | In the lower center of the I/P, behind the access panel, attached to the left side of relay block 2, in the top position | ||
Pressure Control (PC) Solenoid 1 (A/T) | Internal to the automatic transmission | -- | |
Pressure Control (PC) Solenoid 2 (A/T) | Internal to the automatic transmission | -- | |
Pressure Control (PC) Solenoid 3 (MD) | Internal to the automatic transmission | -- | |
Pressure Switch 1 (LCT) | Internal to the automatic transmission, on the pressure switch manifold (PSM) | -- | -- |
Pressure Switch 2 (LCT) | Internal to the automatic transmission, on the pressure switch manifold (PSM) | -- | -- |
Pressure Switch 3 (LCT) | Internal to the automatic transmission, on the pressure switch manifold (PSM) | -- | -- |
Pressure Switch 4 Reverse (LCT) | Internal to the automatic transmission, on the pressure switch manifold (PSM) | -- | -- |
Pressure Switch Manifold (PSM) (LCT) | Internal to the automatic transmission | -- | |
Radio (UM6 or UM7) | In the center of the I/P, below the HVAC control assembly | ||
Rear Axle Driver Control Switch - Two Speed (HPZ and A/T) | On the center of the I/P, right of the IPC | ||
Rear Axle Driver Control Switch - Two Speed (HPZ and M/T) | In front of the center console on the transmission shift lever | ||
Rear Axle Shift Motor - Two Speed (HPZ) | On the front of the rear axle, on the differential | ||
Rear Axle Shift Relay - Two Speed (HPZ) | On the front of the crossmember in front of the rear axle | ||
Rear Compartment Lamp Relay (Z89) | In the lower center of the I/P, behind the access panel, attached to the left side of relay block 2, in the bottom position | ||
Rear Compartment Lamp Switch (Z89) | On the left side of the I/P, left of the IPC and below the driver information center (DIC) | ||
Recirculation Actuator | Behind the lower right side of the I/P, near the blower motor, on the right side of the HVAC module | ||
Relay Block 1 | In the right top of the I/P, under the access panel | ||
Relay Block 2 | In the lower center of the I/P, behind the access panel | ||
Relay Block 3 | In the right side of the I/P, next to the blower motor | ||
Reverse Relay (A/T) | In the transmission cab harness, under the passenger seat, on the top center of the seat bracket, position 1 | ||
Serial Data Gateway (SDG) Module (JE4 or JE3 w/A/T) | Under the passenger seat, near the front, mounted on the top of the transmission control module (TCM) mounting bracket | ||
Shift Solenoid 1 (SS1) (A/T) | Internal to the automatic transmission | -- | |
Shift Solenoid 2 (SS2) (A/T) | Internal to the automatic transmission | -- | |
Shift Solenoid 3 (SS3) (A/T) | Internal to the automatic transmission | -- | |
Speaker - Left | On the upper left front of the I/P | ||
Speaker - Right | On the upper right front of the I/P | ||
Starter | On the lower right side of the engine | -- | |
Starter Relay | Behind the cab at the outboard left frame rail, on the outboard rear of the front chassis harness fuse block bracket | ||
Starter Solenoid | On the lower right side of the engine, part of the starter | -- | |
Stop Lamp Relay | In the lower I/P harness, behind the lower right side of the I/P, near the blower motor, on the relay bracket, position 6 | ||
Stop Lamp Switch (JE3) | Behind the left side of the I/P, right of the steering column, at the top of the brake pedal support bracket | ||
Stop Lamp Switch (JE4) | On the left side of the exterior bulkhead, under the brake pedal, on the air brake application valve | ||
Suction Control Valve (SCV) | On the lower left side of the engine, at the rear, on the fuel injection pump | ||
Tail Lamp Assembly - Left | At the rear of the left frame rail | ||
Tail Lamp Assembly - Right | At the rear of the right frame rail | ||
Tail/Stop and Turn Signal Lamp - Left | At the rear of the left frame rail, part of the tail lamp assembly - left | ||
Tail/Stop and Turn Signal Lamp - Right | At the rear of the right frame rail, part of the tail lamp assembly - right | ||
Thermo Diode | In the lower I/P harness, behind the lower center of the I/P, part of splice pack SP201, taped to the harness between the windshield wiper motor breakout and bulkhead, pins D2, E2 and F2 | ||
Torque Converter Clutch Solenoid (TCC) (A/T) | Internal to the automatic transmission | -- | |
Traction Control Indicator Resistor (NW9) | In the lower I/P harness, taped to the C200 main bulkhead connector breakout, behind radio, taped to harness | Air Antilock Brake System Component Views for air brakes or Antilock Brake System Component Views for hydraulic brakes | Air Antilock Brake System Connector End Views for air brakes or Antilock Brake System Connector End Views for hydraulic brakes |
Traction Control Switch (NW9) | On the center of the I/P, right of the IPC | Air Antilock Brake System Component Views for air brakes or Antilock Brake System Component Views for hydraulic brakes | Air Antilock Brake System Connector End Views for air brakes or Antilock Brake System Connector End Views for hydraulic brakes |
Traction Control Valve (JE4 and NW9) | On the right side of the crossmember forward of the rear axle | ||
Tractor Receptacle (JE4 and RQ3) | Behind the cab, attached to the frame bracket and pogo stick | ||
Tractor/Trailer Plug (JE4 and RQ3 and JYV and VPG) | Behind the cab, attached to the frame bracket and pogo stick | ||
Trailer Receptacle (JE4 and RQ2 and U86 or JE4 and RQ3) | Attached to rear crossmember | ||
Trailer Stop Lamp Relay (JE4, RQ2 and U86 or JE4 and RQ3) | On the left side of the cab bridge, on the relay bracket on the front of the electronic brake control module (EBCM) | ||
Trailer Stop Lamp Switch (JE4 and RQ2 and U86 or JE4 and RQ3) | On the left side of the center console housing | ||
Transmission Control Module (TCM) (A/T) | Under the passenger seat, mounted under the TCM mounting bracket | ||
Transmission Fluid Temperature (TFT) Sensor (LCT) | Internal to the automatic transmission, on the pressure switch manifold (PSM) | -- | -- |
Transmission Fluid Temperature (TFT) Sensor (MD) | Internal to the automatic transmission | -- | -- |
Turbine Shaft Speed (TSS) Sensor (LCT) | On the upper left side of the transmission, in front of the transmission bell housing | ||
Turbine Shaft Speed (TSS) Sensor (MD) | Internal to the automatic transmission | -- | -- |
Turbocharger Vane Position (TVP) Control Solenoid Valve | At the right side of the engine, on the turbocharger behind the intake impeller housing | ||
Turbocharger Vane Position (TVP) Sensor | At the right side of the engine, on the top center of the turbocharger | ||
Turn Signal and Marker Lamp Assembly - Left | In the forward bottom edge of the left door | ||
Turn Signal and Marker Lamp Assembly - Right | In the forward bottom edge of the right door | ||
Turn Signal/Hazard Flasher Module | Behind the lower right side of the I/P, left of the blower motor | ||
Turn Signal/Multifunction Switch | In the steering column, behind the steering wheel assembly | ||
Vehicle Speed Sensor (VSS) | On the transmission tailshaft housing | Manual Transmission Component Views for the manual transmission or Automatic Transmission Electronic Component Views for the automatic transmission | Manual Transmission Connector End Views for the manual transmission or Automatic Transmission Related Connector End Views for the automatic transmission |
Water-In-Fuel Sensor (NWB) | Behind the cab at the outboard left frame rail and outboard of the fuse box, on the bottom of the fuel/water separator | ||
Wheel Speed Sensor (WSS) - LF (JE3) | At the top rear of the left front brake caliper mounting plate | ||
Wheel Speed Sensor (WSS) - LF (JE4) | At the top of the left front brake backing plate | ||
Wheel Speed Sensor (WSS) - LR (JE3) | At the top rear of the left rear brake caliper mounting plate | ||
Wheel Speed Sensor (WSS) - LR (JE4) | At the top of the left rear brake backing plate | ||
Wheel Speed Sensor (WSS) - LR Middle (JE4 and HPE) | At the top of the left rear middle brake backing plate | ||
Wheel Speed Sensor (WSS) - RF (JE3) | At the top rear of the right front brake caliper mounting plate | ||
Wheel Speed Sensor (WSS) - RF (JE4) | At the top of the right front brake backing plate | ||
Wheel Speed Sensor (WSS) - RR (JE3) | At the top rear of the right rear brake caliper mounting plate | ||
Wheel Speed Sensor (WSS) - RR (JE4) | At the top of the right rear brake backing plate | ||
Wheel Speed Sensor (WSS) - RR Middle (JE4 and HPE) | At the top of the right rear middle backing plate | ||
Window Motor | In the right door, on the window regulator | -- | |
Window Switch - Driver | On the top of the left door panel | -- | |
Window Switch - Passenger | On the top of the right door panel | -- | |
Windshield Washer Fluid Pump | At the front left of the exterior cab, behind the inspection panel on the windshield washer reservoir | ||
Windshield Washer Switch | On the right side of the steering column, the button at the end of the multifunction lever, part of the turn signal/multifunction switch | ||
Windshield Wiper Motor | At the front left center of the exterior cab, behind the inspection panel | ||
Windshield Wiper Switch | On the right side of the steering column, controlled by the multifunction lever, part of the turn signal/multifunction switch | ||
C100 (12 cavities) | Front chassis harness to the upfitter auxiliary wiring harness, taped to the harness, on the left inboard frame rail, forward of the second crossmember, behind cab left side | ||
C101 (2 cavities) (U08) | Turn signal harness to the horn harness, behind the left side of the front bumper impact bar | ||
C103 (10 cavities) | Front chassis harness to the upfitter remote transmission control harness, taped to the harness, on the left inboard frame rail, forward of the second crossmember | ||
C104 (10 cavities) | Front chassis harness to the upfitter remote PTO control harness, taped to the harness, on the left inboard frame rail, by the ECM | ||
C105 (10 cavities) | Turn signal harness to the front chassis harness, on the left top of the first crossmember, below the grille | ||
C106 (6 cavities - PTO) | Front chassis harness to the upfitter remote PTO harness, taped to the harness, on the left inboard frame rail, forward of the second crossmember | ||
C108 (16 cavities - A/T) | Transmission cab harness to the front chassis harness, behind the center of the front bumper, in the electrical connector box | ||
C109 (16 cavities - A/T) | Transmission cab harness to the front chassis harness, behind the center of the front bumper, in the electrical connector box | ||
C110 (6 cavities) (A/T) | Transmission cab harness to the front chassis harness, behind the center of the front bumper, in the electrical connector box | ||
C111 (6 cavities) | Front chassis harness to the engine harness, top of the left frame rail, by the ECM | ||
C115 (6 cavities) (A/T) | Engine chassis harness to the front chassis harness, on the front left side of the engine on the top of the harness connector bracket | ||
C115 (12 cavities) (A/T or M/T) | Engine chassis harness to the front chassis harness, on the front left side of the engine on the top of the harness connector bracket, under the air intake tube | ||
C116 (16 cavities) (A/T) | Engine chassis harness to the front chassis harness, on the front left side of the engine on the side of the harness connector bracket, under the air intake tube | ||
C117 (16 cavities) (A/T) | Engine chassis harness to the front chassis harness, on the front left side of the engine on the side of the harness connector bracket, under the air intake tube | ||
C118 (2 cavities) | Engine chassis harness to the front chassis harness, on the front left side of the engine on the top of the harness connector bracket, under the air intake tube | ||
C120 (4 cavities) | Front chassis harness to the upfitter PTO throttle position sensor harness, taped to the harness, taped to the harness, on the left inboard frame rail, by the left fuel tank | ||
C122 (8 cavities) | Engine harness to the engine/injector harness connector adapter 1 to injector harness 1, on the upper left side of the cylinder head between injector 2 and 3 | ||
C123 (8 cavities) | Engine harness to the engine/injector harness connector adapter 2 to injector harness 2, on the upper left side of the cylinder head between injector 4 and 5 | ||
C125 (1 cavity) | Engine chassis harness to the front chassis harness, on the front left side of the engine on the side of the harness connector bracket, between the air intake tube and left side of the engine | ||
C175 (20 cavities) (A/T) | Engine chassis harness to the automatic transmission, on the right rear end of the automatic transmission | ||
C175 (31 cavities) (A/T) | Engine chassis harness to the automatic transmission, on the right rear side of the automatic transmission | ||
C200 (56 cavities) | Lower I/P harness to the front chassis harness, at the front left center of the exterior cab, behind the inspection panel, in the left side of the cab interface electrical connector box | ||
C201 (6 cavities) | Lower I/P harness to upfitter harness, at the lower center of the I/P, on the floor, behind the access panel, below the radio | ||
C202 (56 cavities) | Lower I/P harness to the front chassis harness, at the front left center of the exterior cab, behind the inspection panel, in the right side of the cab interface electrical connector box | ||
C203 (1 cavity) (JE4) | Lower I/P harness to the lower I/P harness, in the right center of the I/P, under the access panel, taped to the harness near relay block 2, connected for truck service, not connected for tractor service. | ||
C204 (3 cavities) | Front chassis harness to the lower I/P harness, at the front left center of the exterior cab, behind the inspection panel, in the upper right corner of the cab interface electrical connector box | ||
C205 (1 cavity) | Front chassis harness to the lower I/P harness, at the front left center of the exterior cab, behind the inspection panel, in the lower left corner of the cab interface electrical connector box | ||
C206 (2 cavities) (LF8) | Front chassis harness to the lower I/P harness, under front hood in the electric center box | ||
C207 (1 cavity) | Front chassis harness to the lower I/P harness, at the front left center of the exterior cab, behind the inspection panel, in the upper left corner of the cab interface electrical connector box | ||
C208 (6 cavities) | Lower I/P harness to the roof harness, behind the right side of the I/P, next to the blower motor | ||
C209 (6 cavities) (Upfitter Connector) | Lower I/P harness to the upfitter harness, under the left side of the I/P, left of the steering column, taped to the harness by the data link connector (DLC) | ||
C210 (14 cavities) | Floor harness to the lower I/P harness, in the lower center of the I/P, below the access panel | ||
C211 (8 cavities) | Lower I/P harness to the dash harness, at the front right side of the exterior cab, behind the hood right side | ||
C212 (84 cavities) | Lower I/P harness to the upper I/P harness, at the left center of the I/P above the accelerator pedal, behind the knee bolster | ||
C213 (2 cavities) | Floor harness to the auxiliary power harness, under the left side of the center console housing, at the top | ||
C214 (2 cavities - JE4) | Upper I/P harness to the air brake pressure gage lamp harness, at the upper left side of the I/P | ||
C215 (22 cavities) | Lower I/P harness to the transmission cab harness, at the lower center of the I/P, on the floor, behind the access panel, on heat floor vent | ||
C216 (2 cavities) | Lower I/P harness to the C216 shunt (2 cavities - DNA), in the right center of the I/P, under the access panel, taped to the harness near relay block 2 | ||
C216 (2 cavities) (DNA) | Lower I/P harness, in the right center of the I/P, under the access panel, taped to the harness near relay block 2 | ||
C219 (6 cavities) (A/T) | Floor harness to the transmission cab harness, near the center console | ||
C221 (1 cavity) | Radio antenna coaxial cable to the antenna coaxial cable, below the left side of the I/P, at the kick panel | -- | |
C400 (2 cavities) | Battery fusible links to the front chassis harness, near the positive battery terminal | ||
C402 (2 cavities) | Battery fusible links to the front chassis harness, near the positive battery terminal | ||
C403 (16 cavities) | Rear chassis harness to the front chassis harness, at the inboard left frame rail, forward of the second crossmember, towards center rear section | ||
C404 (4 cavities) (HPZ) | Rear chassis harness to the two speed rear axle harness, inboard of the right frame rail, forward of the rear axle | ||
C405 (16 cavities) | Rear chassis harness to the front chassis harness, at the inboard left frame rail, forward of the second crossmember, toward center rear section | ||
C406 (8 cavities) (JE4 and RQ2 and U86 or JE4 and RQ3) | Tractor/trailer harness to the front chassis harness to the, at the right frame rail, inboard of the batteries | ||
C407 (6 cavities) (M/T) | Manual transmission harness to the engine chassis harness, at the right side of the transmission | ||
C411 (6 cavities) | Front chassis harness to the fuel tank harness, at the inboard left frame rail, forward of the second crossmember, near left fuel tank | ||
C421 (3 cavities) (K16) | Front chassis harness to the air compressor harness, behind the cab at the outboard left frame rail, inboard of and above the fuse block assembly enclosure, on the air compressor bracket | ||
C501 (8 cavities) | Lower I/P harness to the left door harness, forward of the door, on the body between door hinges | ||
C503 (2 cavities) (DNA/DNN) | Left outside rear view mirror connector to the left door harness, in the interior side of the left door, behind the door panel | ||
C601 (8 cavities) | Lower I/P harness to the right door harness, forward of the door, on the body between door hinges | ||
C603 (2 cavities) (DNA/DNN) | Right outside rear view mirror connector to the right door harness, in the interior side of the right door, behind the door panel | ||
G100 | On the outboard side of the right frame rail forward of the RF upper shock absorber mount, to the engine | -- | |
G101 | On the right side of the engine, lower front, to the outboard frame rail | -- | |
G102 (LG4) | In the engine harness, on the lower left side of the engine, forward of the oil filter, above the motor mount | -- | |
G103 (LG4) | In the fuel heater pigtail, on the left side of the engine, on the back of the fuel filter | -- | |
G107 | In the front chassis harness, on the right frame rail above the front spring perch | -- | |
G108 (JE3) | At the front of the vehicle, in the power brake booster pump pigtail, left of the brake master cylinder | -- | |
G114 | Ground wire, on the outboard right front frame rail to the right front of the cab | -- | |
G208 | In the lower I/P harness, upper right side of the I/P, on the I/P support bracket | -- | |
G209 | In the lower I/P harness, upper right side of the I/P, on the I/P support bracket | -- | |
G210 | In the lower I/P harness and in the right door harness, on the right lower exterior A-pillar behind the trim panel | -- | |
G214 | On the right front of the cab to the outboard right front frame rail | -- | |
G400 | On the outboard side of the right frame rail, from the negative battery cable and from the ground cable/ground block (SP400) | -- | |
G402 (JE4 and RQ2 and U86 or JE4 and RQ3) | At the rear inboard side of the right frame rail, from the tractor-trailer harness | -- | |
G410 (NJ7 or NJ8 or NK8) | At the outboard side of the right frame rail on top of the fuel tank | -- | |
G411 (NJ7 or NJ8 or w/o NK8) | At the outboard side of the left frame rail on top of the fuel tank | -- | |
G501 | In the left door harness, on the left lower exterior A-pillar behind the trim panel | -- | |
G502 | In the left door harness, in the left door | -- | |
G602 | In the right door harness, in the right door | -- | |
S100 (U08) | (CKT 29) In the horn harness | -- | -- |
S101 (U08) | (CKT 150) In the horn harness | -- | -- |
S102 | (CKT 5) In the turn signal harness | -- | -- |
S103 (JE3) | (CKT BT01) In the front chassis harness | -- | -- |
S103 (JE4) | (CKT ZZ02) In the front chassis harness | -- | -- |
S104 | (CKT CF04) In the front chassis harness | -- | -- |
S105 | (CKT 2) In the turn signal harness | -- | -- |
S106 | (CKT DF29) In the engine harness | -- | -- |
S107 | (CKT ZZ03) In the front chassis harness | -- | -- |
S108 | (CKT ZZ03) In the front chassis harness | -- | -- |
S109 | (CKT BX14) In the front chassis harness | -- | -- |
S110 | (CKT WB07) In the front chassis harness | -- | -- |
S111 (JE3) | In the front chassis harness | -- | -- |
S112 | In the front chassis harness | -- | -- |
S113 | In the front chassis harness | -- | -- |
S114 | In the front chassis harness | -- | -- |
S115 | In the front chassis harness | -- | -- |
S116 | In the front chassis harness | -- | -- |
S117 | In the lower I/P harness | -- | -- |
S118 | In the engine harness | -- | -- |
S119 | In the engine harness | -- | -- |
S120 | In the front chassis harness | -- | -- |
S121 | In the front chassis harness | -- | -- |
S122 | In the front chassis harness | -- | -- |
S123 | In the front chassis harness | -- | -- |
S125 | In the front chassis harness | -- | -- |
S126 | In the front chassis harness | -- | -- |
S127 | In the front chassis harness | -- | -- |
S128 | In the front chassis harness | -- | -- |
S129 (JE4) | In the front chassis harness | -- | -- |
S130 (A/T) | In the front chassis harness | -- | -- |
S131 | In the front chassis harness | -- | -- |
S132 | In the front chassis harness | -- | -- |
S133 | In the front chassis harness | -- | -- |
S151 (A/T) | In the front chassis harness | -- | -- |
S152 | In the front chassis harness | -- | -- |
S158 | In the front chassis harness | -- | -- |
S159 | In the front chassis harness | -- | -- |
S160 | In the engine chassis harness | -- | -- |
S167 | In the engine harness | -- | -- |
S168 | In the engine harness | -- | -- |
S174 (A/T) | In the internal transmission harness, approximately 19.5 cm (7.7 in) from C175 | -- | -- |
S175 (A/T) | In the internal transmission harness, approximately 10.5 cm (4.1 in) from C175 | -- | -- |
S176 (A/T) | In the front chassis harness | -- | -- |
S177 (A/T) | In the front chassis harness | -- | -- |
S182 | In the front chassis harness | -- | -- |
S184 | In the engine harness | -- | -- |
S185 | In the engine harness | -- | -- |
S186 | In the engine harness | -- | -- |
S191 | In the engine harness | -- | -- |
S192 | In the engine harness | -- | -- |
S193 | In the engine harness | -- | -- |
S194 | In the engine chassis harness | -- | -- |
S195 | In the engine harness | -- | -- |
S196 | In the engine chassis harness | -- | -- |
S197 | In the engine chassis harness | -- | -- |
S198 | In the engine harness | -- | -- |
S200 | In the lower I/P harness | -- | -- |
S201 | In the lower I/P harness | -- | -- |
S202 (A/T) | In the transmission cab harness | -- | -- |
S203 (A/T) | In the transmission cab harness | -- | -- |
S204 | In the lower I/P harness | -- | -- |
S205 | In the lower I/P harness | -- | -- |
S206 | In the lower I/P harness | -- | -- |
S207 | In the lower I/P harness | -- | -- |
S208 | In the lower I/P harness | -- | -- |
S209 | In the lower I/P harness | -- | -- |
S211 | In the upper I/P harness | -- | -- |
S212 | In the lower I/P harness | -- | -- |
S213 | In the lower I/P harness | -- | -- |
S214 | In the lower I/P harness | -- | -- |
S215 | In the lower I/P harness | -- | -- |
S216 | In the lower I/P harness | -- | -- |
S217 | In the lower I/P harness | -- | -- |
S218 | In the lower I/P harness | -- | -- |
S219 | In the lower I/P harness | -- | -- |
S220 | In the lower I/P harness | -- | -- |
S221 (A/T) | In the upper I/P harness | -- | -- |
S222 | In the lower I/P harness | -- | -- |
S223 | In the lower I/P harness | -- | -- |
S224 (A/T) | In the transmission cab harness | -- | -- |
S225 | In the lower I/P harness | -- | -- |
S228 | In the lower I/P harness | -- | -- |
S229 | In the lower I/P harness | -- | -- |
S230 | In the lower I/P harness | -- | -- |
S231 | In the lower I/P harness | -- | -- |
S232 | In the lower I/P harness | -- | -- |
S233 | In the lower I/P harness | -- | -- |
S235 | In the lower I/P harness | -- | -- |
S237 | In the lower I/P harness | -- | -- |
S239 | In the lower I/P harness | -- | -- |
S240 (HPZ) | In the lower I/P harness | -- | -- |
S242 | In the lower I/P harness | -- | -- |
S245 | In the lower I/P harness | -- | -- |
S246 | In the lower I/P harness | -- | -- |
S247 | In the lower I/P harness | -- | -- |
S248 | In the lower I/P harness | -- | -- |
S252 | In the lower I/P harness | -- | -- |
S254 | In the lower I/P harness | -- | -- |
S255 | In the upper I/P harness | -- | -- |
S256 | In the lower I/P harness | -- | -- |
S257 | In the lower I/P harness | -- | -- |
S263 | In the upper I/P harness | -- | -- |
S264 | In the lower I/P harness | -- | -- |
S268 | In the upper I/P harness | -- | -- |
S269 | In the lower I/P harness | -- | -- |
S270 | In the transmission cab harness | -- | -- |
S271 | In the transmission cab harness | -- | -- |
S272 | In the transmission cab harness | -- | -- |
S273 | In the transmission cab harness | -- | -- |
S274 | In the transmission cab harness | -- | -- |
S275 | In the transmission cab harness | -- | -- |
S276 (A/T) | In the transmission cab harness | -- | -- |
S277 (A/T) | In the transmission cab harness | -- | -- |
S278 | In the lower I/P harness | -- | -- |
S280 | In the lower I/P harness | -- | -- |
S283 (A/T) | In the transmission cab harness | -- | -- |
S284 | In the lower I/P harness | -- | -- |
S285 | In the lower I/P harness | -- | -- |
S286 | In the lower I/P harness | -- | -- |
S288 | In the lower I/P harness | -- | -- |
S295 | In the upper I/P harness | -- | -- |
S300 (A/T) | In the transmission cab harness | -- | -- |
S301 | In the upper I/P harness, behind the upper left side of the I/P, taped to the harness between the IPC and driver information center (DIC) breakouts | -- | -- |
S302 | In the upper I/P harness, behind the upper left side of the I/P, taped to the harness between the IPC and driver information center (DIC) breakouts | -- | -- |
S303 | In the upper I/P harness, behind the upper left side of the I/P, taped to the harness between the IPC and driver information center (DIC) breakouts | -- | -- |
S304 | In the lower I/P harness, behind the lower center of the I/P, taped to the harness by the radio breakout | -- | -- |
S305 | In the lower I/P harness, behind the lower left side of the I/P, taped to the harness between the data link connector (DLC) and the CAN connector | -- | |
S306 (C60) | In the lower I/P harness | -- | -- |
S307 (C60) | In the lower I/P harness | -- | -- |
S308 (C60) | In the lower I/P harness | -- | -- |
S310 | In the lower I/P harness, behind the lower right side of the I/P | -- | -- |
S312 | In the lower I/P harness | -- | -- |
S313 | In the lower I/P harness | -- | -- |
S318 | In the lower I/P harness | -- | -- |
S319 | In the lower I/P harness | -- | -- |
S321 | In the lower I/P harness | -- | -- |
S334 | In the lower I/P harness | -- | -- |
S335 | In the lower I/P harness | -- | -- |
S336 | In the lower I/P harness | -- | -- |
S344 | In the floor harness | -- | -- |
S345 | In the roof harness | -- | -- |
S348 | In the floor harness | -- | -- |
S349 | In the lower I/P harness | -- | -- |
S350 | In the lower I/P harness | -- | -- |
S358 | In the floor harness | -- | -- |
S359 | In the roof harness | -- | -- |
S360 | In the roof harness | -- | -- |
S365 | In the roof harness | -- | -- |
S366 | In the roof harness | -- | -- |
S367 | In the roof harness | -- | -- |
S368 | In the roof harness | -- | -- |
S378 | In the lower I/P harness | -- | -- |
S380 | In the upper I/P harness | -- | -- |
S386 | In the lower I/P harness | -- | -- |
S387 | In the upper I/P harness | -- | -- |
S402 | In the rear chassis harness | -- | -- |
S406 (JE4) | In the front chassis harness | -- | -- |
S411 (JE4) | In the front chassis harness | -- | -- |
S412 (JE4) | In the front chassis harness | -- | -- |
S413 (JE4) | In the rear chassis harness | -- | -- |
S414 (JE4) | In the rear chassis harness | -- | -- |
S416 | In the front chassis harness | -- | -- |
S418 (HPZ) | In the two speed rear axle harness | -- | -- |
S421 (K16) | In the air compressor harness | -- | -- |
S422 | In the front chassis harness | -- | -- |
S423 | In the front chassis harness | -- | -- |
S424 (JE4) | In the front chassis harness | -- | -- |
S500 | In the left door harness | -- | -- |
S600 | In the right door harness | -- | -- |
S900 | In the rear chassis harness | -- | -- |
S901 | In the rear chassis harness | -- | -- |
Splice Pack SP201 (33 cavities) | In the lower I/P harness, behind the lower center of the I/P, taped to the harness between the windshield wiper motor breakout and bulkhead connector C200, behind the radio | ||
Splice Pack SP204 (22 cavities) | In the lower I/P harness, behind the left side of the I/P, taped to the harness | ||
Splice Pack SP205 (10 cavities) | In the upper I/P harness, behind the radio, taped to the harness | ||
Splice Pack SP206 (12 cavities) | In the lower I/P harness, under the passenger seat, near the chime module, taped to the harness, on the chime module breakout | ||
Splice Pack SP209 (6 cavities) | In the lower I/P harness, under the passenger seat, near the chime module, taped to the harness, on the chime module breakout | ||
Splice Pack SP210 (6 cavities) | In the lower I/P harness, left side of the I/P, near CAN connector, taped to the harness | ||
Splice Pack SP211 (6 cavities) | In the lower I/P harness, under the passenger seat, near the chime module, taped to the harness, on the chime module breakout | ||
Splice Pack SP212 (10 cavities) | In the lower I/P harness, behind the lower center of the I/P, taped to the harness by the radio breakout | ||
Splice Pack SP219 (4 cavities) | In the lower I/P harness, under the passenger seat, near the chime module, taped to the harness, on the chime module breakout | ||
Splice Pack SP227 (10 cavities) | In the lower I/P harness, on the right side of the I/P, behind blower motor | ||
Splice Pack SP230 (6 cavities) (A/T) | In the transmission cab harness, under the passenger seat, behind the seat stand cover, near the transmission control module (TCM), taped to the harness breakouts to the TCM | ||
Splice Pack SP231 (6 cavities) (A/T) | In the transmission cab harness, under the passenger seat, behind the seat stand cover, near the transmission control module (TCM), taped to the harness breakouts to the TCM | ||
Splice Pack SP232 (6 cavities) (MD) | In the transmission cab harness, under the passenger seat, behind the seat stand cover, near the transmission control module (TCM), taped to the harness breakouts to the TCM | ||
Splice Pack SP233 (6 cavities) (MD) | In the transmission cab harness, under the passenger seat, behind the seat stand cover, near the transmission control module (TCM), taped to the harness breakouts to the TCM | ||
Splice Pack SP400 (6 cavities) | On the inboard side of the right frame rail, the ground block, part of the ground cable |
