FRONT SEAT BELT WEBBING TWISTS SEAT BELT DOES NOT RETRACT
REVISION: 10/04/96
THIS BULLETIN IS BEING REVISED TO CLARIFY REPLACEMENT OF SEAT BELT ASSEMBLY IN THE CORRECTION PROCEDURE. PLEASE DISCARD CORPORATE BULLETIN NUMBER 63-16-05 (GROUP REF. 10 - BODY) ----------------------------------------------------------------------
SUBJECT: FRONT SEAT BELT WEBBING TWISTS, SEAT BELT DOES NOT RETRACT BACK COMPLETELY (REPLACE SEAT BELT ASSEMBLY)
MODELS: 1996 BUICK SKYLARK 1996 OLDSMOBILE ACHIEVA 1996 PONTIAC GRAND AM
CONDITION:
SOME OWNERS MAY COMMENT ON A TWIST IN THE FRONT SEAT BELT WEBBING BETWEEN THE PILLAR GUIDE LOOP AND THE RETRACTOR OR THAT THE SEAT BELT IS NOT RETRACTING FREELY AND COMPLETELY BACK INTO THE RETRACTOR.
CAUSE:
THIS CONDITION MAY BE CAUSED BY A WEAK RETRACTOR.
CORRECTION:
TO CORRECT THIS CONDITION, CHECK SEAT BELT ASSEMBLY PART NUMBER.
- IF THE SEAT BELT ASSEMBLY IS THE NEW PART NUMBER AS LISTED BELOW:
1. THERE SHOULD BE NO TWIST BETWEEN THE RETRACTOR AND THE GUIDE LOOP.
2. THERE SHOULD BE A 180 DEGREE CLOCKWISE TWIST BETWEEN THE GUIDE LOOP AND THE ROCKER ON THE DRIVER'S SIDE. REFER TO FIGURE 1 AND 2.
3. THERE SHOULD BE A 180 DEGREE COUNTER CLOCKWISE TWIST BETWEEN THE GUIDE LOOP AND THE ROCKER ON THE PASSENGER SIDE. REFER TO FIGURES 1 AND 2.
4. THE LATCH PLATE SHOULD FACE TO THE OUTSIDE OF THE VEHICLE IF THE BELT IS HELD WITHOUT A TWIST FROM THE GUIDE LOOP TO THE LATCH.
5. IF THE BELT OR THE LATCH ARE NOT POSITIONED AS DESCRIBED IN STEPS 1 THROUGH 4, CORRECTIONS SHOULD BE MADE WITHOUT REMOVING ANY PART OF THE SEAT BELT SYSTEM.
- IF THE SEAT BELT ASSEMBLY IS THE OLD PART NUMBER AS LISTED BELOW, REPLACE BOTH THE RIGHT AND LEFT SEAT BELT ASSEMBLY WITH THE NEW PART NUMBER. REFER TO SECTION 10-11 IN THE SERVICE MANUAL FOR REMOVE AND INSTALL PROCEDURES.
PARTS INFORMATION:
OLD P/N NEW P/N DESCRIPTION COLOR ======= ======= =========== =====
22651604 12533333 BELT ASM, PASS. SEAT GRAPHITE RETRACTOR, COUPE
22651606 12533334 BELT ASM, PASS. SEAT GARNET RETRACTOR, COUPE
22651608 12533335 BELT ASM, PASS. SEAT TEAL RETRACTOR, COUPE
22651610 12533336 BELT ASM, PASS. SEAT NEUTRAL RETRACTOR, COUPE
22651605 12533337 BELT ASM., DRIVER SEAT GRAPHITE RETRACTOR, COUPE
22651607 12533338 BELT ASM, DRIVER SEAT GARNET RETRACTOR, COUPE
22651609 12533339 BELT ASM, DRIVER SEAT TEAL RETRACTOR, COUPE
22651611 12533340 BELT ASM, DRIVER SEAT NEUTRAL RETRACTOR, COUPE
22651614 12533341 BELT ASM, PASS. SEAT GRAPHITE RETRACTOR, SEDAN
22651616 12533342 BELT ASM, PASS. SEAT GARNET RETRACTOR, SEDAN
22651618 12533343 BELT ASM, PASS. SEAT TEAL RETRACTOR, SEDAN
22651620 12533344 BELT ASM, PASS. SEAT NEUTRAL RETRACTOR, SEDAN
22651615 12533345 BELT ASM, DRIVER SEAT GRAPHITE RETRACTOR, SEDAN
22651617 12533346 BELT ASM, DRIVER SEAT GARNET RETRACTOR, SEDAN
22651619 12533347 BELT ASM, DRIVER SEAT TEAL RETRACTOR, SEDAN
22651621 12533348 BELT ASM, DRIVER SEAT NEUTRAL RETRACTOR, SEDAN
PARTS ARE EXPECTED TO BE AVAILABLE ON MAY 13, 1996.
WARRANTY INFORMATION:
FOR VEHICLES REPAIRED UNDER WARRANTY, USE:
LABOR OPERATION NUMBER DESCRIPTION LABOR TIME =============== =========== ==========
C9040 RIGHT SIDE 0.4 HR
C9041 LEFT SIDE 0.4 HR
C9047 BOTH 0.7 HR
FIGURES: 02 ATTACHMENTS: 00
FIGURE 1: 1. COVER 2. BOLT 3. SLEEVE PLUG 4. BOLT 5. BOLT
FIGURE 2: 1. COVER 2. GUIDE 3. SLEEVE PLUG 4. BOLT 5. BOLT 6. BOLT 7. BELT GUIDE TRACK 8. BOLT
GENERAL MOTORS BULLETINS ARE INTENDED FOR USE BY PROFESSIONAL TECHNICIANS, NOT A "DO-IT-YOURSELFER". THEY ARE WRITTEN TO INFORM THOSE TECHNICIANS OF CONDITIONS THAT MAY OCCUR ON SOME VEHICLES, OR TO PROVIDE INFORMATION THAT COULD ASSIST IN THE PROPER SERVICE OF A VEHICLE. PROPERLY TRAINED TECHNICIANS HAVE THE EQUIPMENT, TOOLS, SAFETY INSTRUCTIONS AND KNOW-HOW TO DO A JOB PROPERLY AND SAFELY. IF A CONDITION IS DESCRIBED, DO NOT ASSUME THAT THE BULLETIN APPLIES TO YOUR VEHICLE, OR THAT YOUR VEHICLE WILL HAVE THAT CONDITION. SEE A GENERAL MOTORS DEALER SERVICING YOUR BRAND OF GENERAL MOTORS VEHICLE FOR INFORMATION ON WHETHER YOUR VEHICLE MAY BENEFIT FROM THE INFORMATION.
COPYRIGHT 1996 GENERAL MOTORS CORPORATION. ALL RIGHTS RESERVED.
