GM Service Manual Online
For 1990-2009 cars only

Wet Headliner, Seat Belt, Front or Rear Floor/Sunroof Waterleak (Inspect Rear Drains and Correct Routing/Install Extensions)

Subject:Wet Headliner, Seat Belt, Front or Rear Floor/Sunroof Waterleak (Inspect Rear Drains and Correct Routing/Install Extensions)

Models:2006-2007 Pontiac G6 Coupe Only
with Standard Sunroof (RPO CF5)



This bulletin is being revised to change Step 2 in the Correction section and include the WPC Parts Request Form. Please discard Corporate Bulletin Number 06-08-57-004A (Section 08 - Body and Accessories).


Condition

Some customers may comment that the headliner, seat belt or the front or rear floor is wet.

Cause

The sun roof rear drain hose(s) may have become disconnected from the sunroof module.

Correction

  1. Partially lower the headliner and inspect the rear sunroof drains for proper routing.
  2. Incorrect Routing


    Object Number: 1872045  Size: SH

    Correct Routing


    Object Number: 1872047  Size: SH

    Important: Do not kink the hose when rerouting. Disconnect the hose from the two retaining clamps and carefully reroute correctly.

  3. If either of the rear drain hose have come loose or are routed incorrectly, reroute them correctly. The drain hose should be routed to the outside of the coat hook retainers. Install an extension hose (WPC #415, 2 per vehicle) onto the end of each green rubber coupling (located at the rear of the sun roof module, one per side - two total). Slide the rear drain hose into the other end of the new extension hose and secure the clamps to the drain hose.

  4. Object Number: 1879083  Size: SH
  5. Clamp the new extension hose by installing a tie strap around the green rubber couplings (both sides - rear).

Warranty Information

For vehicles under warranty, use:

Labor Operation

Description

Labor Time

C9779*

Lower Headliner, Inspect Drains and Install Tie Strap

0.8  hr

*This is a unique labor operation for bulletin use only. It will not be published in the Labor Time Guide.

IMPORTANT NOTE WHEN PRINTING THIS FORM: If the form prints out on two pages, make certain you fax BOTH pages so that the WPC receives all the needed information. Missing information will delay or prevent the part from being shipped.

Parts Request Form - Warranty Parts Center

To: Warranty Parts Center

 

e-mail: warrantypartscenterUSA@gm.com

 

or WPC Fax: 248-371-0192

 

Attn: Jeannette Dunn

 

Part Being Requested: WPC 415 (includes set of 2 extension hoses per vehicle)

 

Dealer BAC (U.S.) / Dealer Code (Canada):

 

Dealer Name:

 

Dealer Address:

 

 

Dealer Contact Person:

 

Dealer Phone Number:

 

Repair Order Number:

 

Vehicle VIN:

 

Important: If you do not receive the part within 2 business days after e-mailing or faxing your part request to the Warranty Parts Center, please call Customer Assistance at 248-371-9901/9902.

IMPORTANT NOTE WHEN PRINTING THIS FORM: If the form prints out on two pages, make certain you fax BOTH pages so that the WPC receives all the needed information. Missing information will delay or prevent the part from being shipped.