A battery is not designed to last forever. With proper care, however, the battery
will provide years of good service. If the battery tests good but still
fails to perform well, the following are some of the more common causes:
| • | A vehicle accessory was left on overnight. |
| • | The driving speeds have been slow with frequent stops, stop-and-go driving,
with many electrical accessories in use, particularly air conditioning,
headlights, wipers, heated rear window, cellular telephone, etc. |
| • | The electrical load has exceeded the generator output, particularly with
the addition of aftermarket equipment. |
| • | Existing conditions in the charging system, including the following possibilities: |
| • | The battery has not been properly maintained, including a loose battery
hold down or missing battery insulator if used. |
| • | There are mechanical conditions in the electrical system, such as a short
or a pinched wire, attributing to power failure. Refer to
General Electrical Diagnosis
in Wiring Systems. |
Electrolyte Freezing
The freezing point of electrolyte depends on its specific gravity. A fully charged
battery will not freeze until the ambient temperature gets below -54°C
(-65°F). However, a battery with a low state of charge may
freeze at temperatures as high as -7°C (20°F). Since freezing
may ruin a battery, the battery should be protected against freezing
by keeping it properly charged. As long as the green eye is visible
in the hydrometer, the freezing point of the battery will be somewhere
below -32°C (-25°F).
Battery Protection During Vehicle Storage
Certain devices on the vehicle maintain a small continuous current drain, parasitic
load, on the battery. A battery that is not used for an extended period
of time will discharge. Eventually permanent damage will result. Discharged
batteries will also freeze in cold weather. Refer to
Battery Inspection/Test
.
In order to maintain the battery state of charge while storing the vehicle for
more than 30 days:
- Ensure that the green dot is visible in the built-in hydrometer.
Caution: Unless directed otherwise, the ignition and start switch must be in the OFF or LOCK position, and all electrical loads must be OFF before servicing
any electrical component. Disconnect the negative battery cable to prevent an electrical spark should a tool or equipment come in contact with an exposed electrical terminal. Failure to follow these precautions may result in personal injury and/or damage to
the vehicle or its components.
- Disconnect the battery ground cable to protect the battery from
discharge by parasitic current drains.
When the battery cannot be disconnected:
- Maintain a high state of charge.
- Establish a regular schedule for recharging the battery every 20-45 days.
A battery that has remained in a discharged state for a long period of time
is difficult to recharge or may be permanently damaged.
