CAMPAIGN: REAR BRAKE HOSE CONTACT. Pontiac Grand Prix 1995

SUBJECT: REAR BRAKE HOSE CONTACT

MODELS: 1995 Chevrolet Lumina SEO Vehicles (Police SEO 9C3 and Taxi SEO 9C6)

TO: ALL GENERAL MOTORS DEALERS

General Motors of Canada Limited has determined that CERTAIN 1995 Chevrolet Lumina Police and Taxi vehicles may experience excessive tension of the rear brake hose. This tension condition may potentially adversely affect long term durability of the rear brake hose.

To correct this condition, dealers are to install new designed rear brake hoses.

VEHICLES INVOLVED:

Involved are CERTAIN 1995 Chevrolet Lumina Police Cars (SEO 9C3) and Taxi Vehicles (SEO 9C6) built within the following VIN breakpoints:

Year Model Plant Plant Code From Through

1995 Chevrolet Lumina Oshawa 1 9 S9128876 S9360000

NOTE: PLEASE CHECK DCS SCREEN 45 OR YOUR V.I.N. LISTING BEFORE PERFORMING CAMPAIGN TO ENSURE THAT THE VEHICLE IS AFFECTED. ONLY AFFECTED VIN'S WILL BE PAID.

All affected vehicles have been identified by the VIN listing provided to involved dealers with this bulletin. Any dealer not receiving a listing was not shipped any of the affected vehicles.

DEALER CAMPAIGN RESPONSIBILITY:

All unsold new vehicles in dealer's possession and subject to this campaign MUST be held and inspected/repaired per the Service Procedure of this Campaign Bulletin before owners take possession of these vehicles.

Dealers are to perform this campaign on all involved vehicles at no charge to owners, regardless of kilometers traveled, age of vehicle, or ownership, from this time forward.

Owners of vehicles recently sold from your new vehicle inventory with no owner information indicated on the dealer listing, are to be contacted by the dealer, and arrangements made to make the required correction according to instructions contained in this bulletin. This could be done by mailing to such owners a copy of the owner letter accompanying this bulletin. Campaign follow- up cards should not be used for this purpose, since the owner may not as yet have received the notification letter

In summary, whenever a vehicle subject to this campaign is taken into your new or used vehicle inventory, or is in your dealership for service in the future, please take the steps necessary to be sure the campaign correction has been made before selling or releasing the vehicle.

CAMPAIGN PROCEDURE

Refer to Section 4 of the Service Policies and Procedures Manual for the detailed procedure on handling Product Campaigns. Dealers are requested to complete the campaign on all transfers as soon as possible.

OWNER NOTIFICATION

All owners of record at the time of campaign release are shown on the attached computer listing and have been notified by first class mail from General Motors (see copy of owner letter included with this bulletin). The listings provided are for campaign activity only and should not be used for any other purpose.

PARTS INFORMATION

Parts required to complete this campaign should be ordered through regular channels, as follows:

Part Number Description Quantity/Vehicle ----------------------------------------------------------------------------- 22163457 Left Rear Brake Hose 1 22163458 Right Rear Brake Hose 1 10139097 Rear Brake Hose Fitting Washer (2 per hose) 992667 Brake Fluid As Required

PARTS AND LABOR CLAIM INFORMATION:

Credit for the campaign work performed will be paid upon receipt of a properly completed campaign claim card or DCS transmission in accordance with the following:

Repair Code Description Time Allowance

2A Replace Both Rear Brake Hoses 1.1

Time allowance includes 0.1 hour for dealer administrative detail associated with this campaign. Parts credit will be based on dealer net plus 40% to cover parts handling.

SERVICE PROCEDURE

1. Remove rear wheel assembly.

2. Disconnect brake pipe from brake hose.

3. Remove bracket from body frame.

4. Remove brake hose from caliper (washers NOT to be reused).

5. Remove retainer from bracket and remove brake hose.

6. Install NEW brake hose to bracket with retainer.

7. Install bracket to body frame. Tighten bolt to 25 N.m (18 lb. ft.).

8. Install NEW brake hose and NEW washers to caliper (routing should be the same as in Figure 2). Tighten fitting to 44 N.m (32 lb. ft.).

9. Install NEW brake hose to pipe. Tighten fitting to 15 N.m (11 lb. ft.).

10. Bleed brake hydraulic system following the applicable service manual procedures, Section 5, Brakes.

11. Install wheel assembly.

12. Repeat process on other side.

13. Install Campaign Identification Label.

INSTALLATION OF CAMPAIGN IDENTIFICATION LABEL

Clean surface of radiator upper mounting panel and apply a Campaign Identification Label. Make sure the correct campaign number is inserted on the label. This will indicate that the campaign has been completed.

Dear General Motors Customer

To correct this condition, your dealer will install new designed rear brake hoses.

This service will be provided for you at no charge.

Please contact your GM dealer as soon as possible to arrange a service date.

If parts are required, ask your dealer for details regarding their availability. If parts are not in stock, they can be ordered before scheduling your service date.

This letter identifies your vehicle. Presentation of this letter to your dealer will assist their Service personnel in completing the necessary correction to your vehicle in the shortest possible time.

We are sorry to cause you this inconvenience; however, we have taken this action in the interest of your continued satisfaction with our products.

Customer Support Department General Motors of Canada Limited

General Motors bulletins are intended for use by professional technicians, not a "do-it-yourselfer". They are written to inform those technicians of conditions that may occur on some vehicles, or to provide information that could assist in the proper service of a vehicle. Properly trained technicians have the equipment, tools, safety instructions and know-how to do a job properly and safely. If a condition is described, do not assume that the bulletin applies to your vehicle, or that your vehicle will have that condition. See a General Motors dealer servicing your brand of General Motors vehicle for information on whether your vehicle may benefit from the information.