General Motors of Canada Limited, on behalf of Saab Automobile, A.B., warrants to owners of Saab vehicles sold in Canada, that the vehicle (1) was designed, built and equipped so as to conform at the time of sale with the Emission Regulations under the Canadian Environmental Protection Act and (2) is free from defects in materials and workmanship which cause the vehicle to fail to conform with those regulations for a period of 4 years or 80 000 kilometres, whichever occurs first. Specified Major Emission Components that are defective are warranted for 8 years or 130 000 kilometres, whichever comes first. The Emission Control Systems Warranty period shall begin on the date the vehicle is delivered to the first retail purchaser or, if the vehicle is first placed in service as a demonstrator, or company vehicle prior to sale at retail, on the date the vehicle is first placed in such service. Emission related defects in the genuine Saab components listed below, including related diagnostic costs, parts and labour, are covered by this warranty.
Emission Performance
Some provinces and local jurisdictions have established periodic vehicle Inspection and Maintenance (I/M) programs to encourage proper maintenance of your vehicle. If a provincial I/M program is enforced in your area you may also be eligible for Emission Performance coverage when all of the following three conditions are met:
- the vehicle has been maintained and operated in accordance with the instructions for proper maintenance and use set forth in the Owner's Manual, New Vehicle Warranty, or Maintenance Schedule supplied with your vehicle;
- the vehicle fails a provincial I/M test during the emission warranty period indicated above; and
- the failure results, or will result, in the owner of the vehicle having to bear a penalty or other sanctions (including the denial of the right to use the vehicle) under local, provincial, or federal law.
Claims Procedure
Make your vehicle available to any authorized Saab retailer as soon as possible after failing a provincial I/M test or at any time you suspect a defect in a part. If all the above conditions are met, GM warrants that your retailer will replace, repair, or adjust to GM specifications, at no charge to you, any of the parts listed under "Emission Control Systems Warranty Parts List" which may be necessary to cause your vehicle to conform to the applicable emission standards.
Repairs which do not qualify will be charged to you.
In the event a warranty matter is not handled to your satisfaction, refer to the Customer Satisfaction Procedure in this booklet under Owner Assistance .
Emission Control Systems Warranty Parts List
Listed below are most of the systems that affect emissions of your vehicle. Emission control components of these systems are covered by the Emission Control Systems Warranty as applicable. Items that require replacement as scheduled maintenance are covered by the Emission Control Systems Warranty, or up to the replacement interval specified in your Maintenance Schedule, whichever comes first. |
Powertrain Control System | |
|---|---|
ABS Control Module (CTS manual transmission, CTS-V manual transmission, G6 manual transaxle, Corvette, XLR, LS2 TrailBlazer, LS2 Envoy, LU3 and L18 Suburban, Avalanche, Savana, and Express, Yukon, Denali, Tahoe, Hummer H2 and Hybrid vehicles only) | Intake Air Temperature Sensor |
Malfunction Indicator Lamp | |
Manifold Absolute Pressure Sensor | |
Mass Air Flow Sensor | |
Coolant Level Sensor | Oil Pressure Sensor (DOD™ only) |
Data Link Connector | Oxygen Sensors |
Electronic Throttle Control (ETC) Motor | Powertrain Control Module (PCM) * |
Engine Control Module (ECM) * | Programmable Read Only Memory (PROM) |
Engine Coolant Temp. Sensor | Throttle Position Sensor/Switch |
Fast Idle Solenoid | Vehicle Control Module (VCM) * |
Flexible Fuel Sensor | Vehicle Speed Sensor |
Fuel Management System | |
|---|---|
Common Rail Assembly (6.6L DURAMAX® Diesel) | Function Block (6.6L DURAMAX® Diesel) |
Diesel Fuel Injection Pump | Fuel Injectors |
Diesel Fuel Injection Pump Timing Adjust | Fuel Pressure Regulator |
Diesel Fuel Injector Control Module - EDU (6.6L DURAMAX® Diesel) | Fuel Rail Assembly |
Diesel Fuel Temperature Sensor | Fuel Rail Pressure Sensor (6.6L DURAMAX® Diesel) |
Direct Fuel Injector Assembly (6.6L DURAMAX® Diesel) |
|
Catalytic Converter System | |
|---|---|
Catalytic Converter(s) and Muffler if attached as assembly* | Exhaust Manifold with Catalytic Converter attached as assembly* |
Exhaust Manifold | Exhaust pipes and/or mufflers (when located between converter and exhaust manifold |
Exhaust Manifold Gasket |
|
Transmission Controls and Torque Management | |
|---|---|
Manual Transmission Clutch Switch | Transmission Gear Selection Switch (Diesel) |
Park/Neutral Switch | Transmission Internal Mode Switch |
Torque Converter Clutch Switch | Transmission Pressure Switches |
Torque Converter Clutch Solenoids | Transmission Shift Solenoids A & B |
Transmission Control Module* | Transmission Speed Sensors |
Transmission Fluid Temperature Sensor |
|
Air Management System | |
|---|---|
Air Cleaner | Intake Manifold Gasket (Terraza, Uplander, Montana SV6, RELAY and DURAMAX® Diesel) |
Air Cleaner Diaphragm Motor | Intake Manifold Tuning Valve |
Air Cleaner Resonator | Intake Manifold Tuning Valve Relay |
Air Cleaner Temp. Compensator Valve | Supercharger Assembly |
Air Intake Ducts | Throttle Body (Replacement only) |
Charge Air Control Actuator | Throttle Body Heater |
Charge Air Control Solenoid Valve | Throttle Closing Dashpot |
Charge Air Control Valve | Turbocharger Assembly |
Charge Air Cooler (6.6L DURAMAX® Diesel) | Turbocharger Boost Sensor (6.6L DURAMAX® Diesel) |
Charge Air Cooler Fan | Turbocharger Oil Separator |
Idle Air Control Valve | Turbocharger Thermo Purge Switch |
Idle Speed Control Motor | Vacuum Pump (6.6L Diesel) |
Intake Manifold | |
Ignition System | |
|---|---|
Camshaft Position Sensor(s) | Glow Plug Relay (Diesel) |
Crankshaft Position Sensor(s) | Ignition Coil(s) |
Distributor | Ignition Control Module |
Distributor Cap | Ignition Timing Adjustment |
Distributor Pickup Coil | Knock Sensor |
Distributor Rotor | Spark Plug Wires |
Glow Plug(s) (Diesel) | Spark Plugs |
Glow Plug Controller (Diesel) |
|
Evaporative Emission Control System (Gasoline Engines) | |
|---|---|
Canister | Fuel Level Sensor |
Canister Vent Solenoid | Fuel Limiter Vent Valve |
Canister Purge Solenoid Valve | Fuel Tank Filler Pipe (with Restrictor) |
Fuel Feed/Return Pipes and Hoses | Fuel Tank Vacuum Sensor or Pressure Sensor |
Fuel Filler Cap | Fuel Tanks |
Positive Crankcase Ventilation System | |
|---|---|
Oil Filler Cap | PCV Oil Separator |
PCV Filter | PCV Valve |
Exhaust Gas Recirculation System | |
|---|---|
EGR Feed and Delivery Pipes or Cast-In Passages | EGR Valve Cooler (6.6L DURAMAX® Diesel) |
EGR Valve | EGR Vacuum Pump Assembly (6.6L DURAMAX® Diesel) |
Secondary Air Injection System | |
|---|---|
Air Pump | Check Valves |
Hybrid | |
|---|---|
Auxiliary Transmission Pump, Relay, and Circuit | Hood Ajar Switch and Circuit |
Battery Pack Current Sensor and Circuit | Hybrid Control Module * |
Battery Pack 12V Modules (3) | SGCM Coolant Circuit (fan and fan relay and pump) |
Brake Pedal Switch (PCM ZAB Switch) | Starter Generator Control Module* |
Energy Storage Control Module * | Wheel Speed Sensor and Circuits (left and right front) |
GMLAN (CAN) Communications Circuit | |
Miscellaneous Items Used in Above Components are Covered | |
|---|---|
Belts | Housings |
Boots | Mounting Hardware |
Clamps | Pipes |
Connectors | Pulleys |
Ducts | Sealing Devices |
Fittings | Springs |
Gaskets | Tubes |
Grommets | Wiring |
Hoses | |
If failure of one of the above parts results in failure of another part under the Emission Control Systems Warranty, both will be covered by this warranty. For detailed information concerning specific parts covered by the Emission Control Systems Warranty, ask your retailer. | |
* Specified Major Emission Components: 8 years/130 000 kilometres, whichever comes first. | |
What Is Not Covered
The Emission Control Systems Warranty obligations DO NOT apply to conditions resulting from tampering abuse, neglect, or improper maintenance. Items listed under "What Is Not Covered" in the Saab New Vehicle Limited Warranty also DO NOT apply to the Emission systems related warranties. Parts specified in your maintenance schedule as requiring scheduled replacement are covered up to their first replacement interval or the applicable emission warranty coverage period, whichever comes first. There is no coverage under this warranty for the failure of parts which are not replaced as required. If failure of one of these parts results in failure of another part, both will not be covered under the Emission Control System Warranty. For detailed information concerning specific parts covered by these emission control systems warranties, ask your retailer. THE "OTHER TERMS" PRESENTED IN THE SAAB NEW VEHICLE LIMITED WARRANTY ALSO APPLY TO THIS WARRANTY. |
