GM Service Manual Online
For 1990-2009 cars only
Makes 🢒 Saturn 🢒 1998 🢒 SL2/SC2/SW2 🢒 Bulletins 🢒 Rattle, Buzz and/or Clunk From the Front Door over Rough Road and/or with the Radio On

Rattle, Buzz and/or Clunk From the Front Door over Rough Road and/or with the Radio On

Subject:Rattle, Buzz and/or Clunk from the Front Door over Rough Road and/or with the Radio On -- Install Foam Block, Spacer or New Fastener. -- Due to the addition of the break point for condition 1, this bulletin supersedes Bulletin 98-T-03, which should be discarded.

Models:For condition 1: 1996-1999 Saturn Sedans and Wagons built before and including VIN XZ124694. For condition 2: 1997 Saturn Coupes equipped with manual windows built before and including VIN VZ335593. For condition 3: 1996-1999 Saturns


Condition:

Customers may comment on one or more of the following conditions:

  1. Rattle or buzz noise from the lower front door trim panel when driving over rough roads or when playing the radio at higher volumes.
  2. Rattle or buzz noise from the plastic washer behind the crank handle on Coupes with manual windows when driving over rough roads.
  3. Clunk or rattle type noise while driving over rough road.

Cause:

These conditions may be caused by one of the following conditions:

    • Condition 1 may be caused by excessive movement at the front lower corner of the front door trim panel.
    • Condition 2 may be caused by excessive movement of the plastic washer behind the window crank handle.
    • Condition 3 may be caused by inadequate retention of the speaker push-pin type fasteners.

Correction:

Refer to the procedures in this bulletin.

Procedures:

Condition 1- 1996 and 1999 Sedans and Wagons

  1. Remove the interior front side door trim panel on the side of the vehicle making the noise. Refer to Front Door Trim Panel in the Doors section of the appropriate year Body/Repair Service Manual.

    2. Object Number: 878792 Size: SH
  2. Install a front side door deadener assembly P/N 21110766 on the backside of the front door trim panel.

    3. Position the front side door deadener assembly so that an edge is located between the bottom outside of the door speaker and the front side door trim panel as shown in the illustration.

  3. Install the interior front side door trim panel. Refer to Front Door Trim Panel in the Doors section of the appropriate tear Body/Repair Service Manual.
  4. Verify that the condition has been repaired.

Condition 2 -- 1997 Coupes with Manual Windows built before and including VIN VZ335593

  1. Remove the interior front side door trim panel on the side of the vehicle making the noise. Refer to Front Door Trim Panel in the Doors section of the 1997 Body/Repair Service Manual.

    2. Object Number: 879686 Size: SH
  2. Install the front door window regulator handle spacer P/N 21059859 behind the front side door trim panel as shown in the illustration.
  3. Install the interior front side door trim panel. Refer to Front Door Trim Panel in the Doors section of the appropriate tear Body/Repair Service Manual.
  4. Verify that the condition has been repaired.

Condition 3 -- 1996-1999 Saturns

  1. Remove the interior front side door trim panel on the side of the vehicle making the noise. Refer to Front Door Trim Panel in the Doors section of the 1997 Body/Repair Service Manual.
  2. Remove the speaker push-pin fasteners, then remove the speaker.

    3. Object Number: 867694 Size: SH
  3. Install the J-clip P/N 21093771 to the door where the speaker push-pins were removed at the 11:00 and 5:00 o'clock positions as shown in the illustration.
  4. Install the speaker using screw P/N 11504056 in the positions where the J-clips were installed and tighten the screws.

    5. Tighten
    Tighten the screws to 2.5 N·m (22 lb in).

  5. Install the push-pin fasteners in the remaining 2 locations.
  6. Verify that the condition has been repaired.

Parts Requirements:

Part Number

Description

21110766

Deadener Asm -- Frt S/D (2 per part number 1 required for each door)

21059859

Spacer -- Frt S/D Wdo Reg Hdl (1 required for each door)

21093771

J-clip (4 required for each door)

11504056

Screw (4 required for each door)

Claim Information:

To receive credit for this repair during the warranty coverage period, submit a claim through the Saturn Dealer System as follows:

--

Case Type

Description

Labor Operation Code

Time

--

VW

Remove and Replace Inner Trim Panel -- Right Front Door

T9767

0.40 hrs

--

VW

Remove and Replace Inner Trim Panel -- Left Front Door

T9768

0.40 hrs

--

ADD:

To Install front Side Door Deadener

--

0.10 hrs

--

ADD:

To Install J-Clips and Screws on Speaker

--

0.10 hrs

--

ADD:

To Install Window Regulator Handle Spacer (Coupe Only)

--

0.10 hrs