Technical Service Bulletins

2008-09-29: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement (02-07-30-029L)
2008-09-29: Eliminating Unwanted Odors in Vehicles (00-00-89-027E)
2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-25: Updated Warranty and Goodwill Exchange Program for Electronic Products (08-08-44-029)
2008-09-23: Special Coverage Adjustment - Analog OnStar Deactivation (08089B)
2008-09-19: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords blue button communication message no noconnect operation (PIC4600A)
2008-09-05: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses (02-08-42-001C)
2008-08-29: Car and Truck Fix It Right the First Time Issues (08-00-89-029A)
2008-08-28: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) (08-08-44-028)
2008-08-26: Radio Unlock Code Process for 1991-05 Saturn Models - keywords accessory activation body code disabled delco information inoperative lock number panasonic phone program theft radio security support (PIC4837B)
2008-08-26: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs) (08-08-44-015A)
2008-08-25: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006E)
2008-08-22: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process (For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB, Audio, Display, Map, Noise) (08-08-44-010B)
2008-08-14: Information on Aftermarket Device Interference with OnStar Diagnostic Services (08-08-46-004)
2008-08-13: Radio Unlock Code Process For 1991-2005 Saturn Models - keywords accessory activation body disabled delco information inoperative lock number panasonic phone program theft radio security support (PIC4837A)
2008-08-11: Informaiton on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
2008-08-08: Information on Water or Ethylene Glycol in Transmission Oil (08-07-30-035)
2008-08-06: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022E)
2008-08-05: Question Regarding Installation Of Dealer Installed Accessories (PIT3099E)
2008-08-01: SWC Operation After OnStar ADT Upgrade - keywords call calling control inoperative steering wheel (PIC4820A)
2008-07-25: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 (05-03-08-002B)
2008-07-23: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information led no operation red (PIC3597F)
2008-07-23: OnStar Power Consumption - keywords battery digital discharge drain draw parasitic VCIM (PIC4935)
2008-07-21: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output (02-06-03-008D)
2008-07-17: Essential Service Tool update #4 (U.S. Retailers Only) (08-00-89-025)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-27: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) (07-00-89-047B)
2008-06-27: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009B)
2008-06-24: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047H)
2008-06-23: Essential Service Tool Update #3 (U.S. Retailers Only) (08-00-89-023)
2008-06-23: Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011)
2008-06-20: Information on Use of Customer Concern Verification Sheets, Comeback Prevention, GM Technical Assistance Information Form (TAC), Strategy Based Diagnostics (SBD), Intermittent Concerns, Diagnostics (01-00-89-010H)
2008-06-18: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement (08-08-44-023)
2008-06-18: OnStar Voice Recognition Operation Issues - keywords information intermittent microphone performance voice (PIC3011E)
2008-06-18: Unable To Connect To OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication droppedcall failedtovoice information intermittent OPC operation no noconnect performance region (PIC4310C)
2008-06-17: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy (05-00-89-072B)
2008-06-17: Disc Brake Warranty Service and Procedures - LRO, Lateral Runout, Rotor, Corrosion, Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Squeak, Grind, Groan (05-05-22-002D)
2008-06-16: Questions Regarding Installation Of Dealer Installed Accessories (PIT3099D)
2008-06-11: Unwanted Repeated Calls to OnStar / Replace VCIM - keywords call letter mail phantomcall phone repeat (PIC4893)
2008-06-06: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002E)
2008-06-05: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors (07-08-64-022A)
2008-05-30: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. Only) (07-03-10-016A)
2008-05-30: Intermittent, Current or History DTC B2476 in Onstar GEN 6 or 7 VCIM - keywords blue button call communication data digital information keypad led OPC operation red (PIC4574B)
2008-05-29: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory (08-06-03-005)
2008-05-16: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
2008-05-15: Essential Service Tool Update #2 (U.S. Retailers Only) (08-00-89-020)
2008-05-12: Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
2008-05-12: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
2008-05-08: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036E)
2008-05-07: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Intrument Panel Clusters (IPC) (08-08-44-015)
2008-05-06: Disc Brake Warranty Service and Procedures (00-05-22-002K)
2008-05-02: Manual Transmission Operating Characteristics (03-07-29-004E)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005)
2008-05-01: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) (08-03-10-006)
2008-05-01: Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
2008-04-24: Parts Restriction on Ordering XM Digital Radio Receiver (03-08-44-022E)
2008-04-18: Information for Dealers on How to Submit a Field Product Report (02-00-89-002G)
2008-04-17: Being Prepared for TAC, Caller Preparedness - Contacting U.S. Technical Assistance (TAC) and Use of Strategy Based Diagnostics (08-00-89-014)
2008-04-17: Electronic Exchange Program Goodwill Procedures (05-00-89-045A)
2008-04-16: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines (05-08-44-024A)
2008-04-14: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information LED no operation red (PIC3597E)
2008-04-14: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts (00-06-01-012C)
2008-04-10: Handsfree Calling Inop With Demo Message On OnStar Keypress - keywords 05-08-46-006N blue button communication digital disabled message no OPC operation vs3bgen6 vs3bgen7 (PIC4564A)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-04: Battery Electrical Drain / Parasitic Load Test - keywords 8 ab astra aura dead drain draw drop electrical gmt201 gmt960 gmx001 gmx002 ion outlook pic4790 pic4790a pic4798 resistor saturn voltage vue (PIC4790A)
2008-04-01: Warranty Claims Submission - Importance of GM Part Numbers and Parts with Date Codes (06-00-89-054B)
2008-03-31: Radio Unlock Code Procedure - keywords accessory activation body code disabled delco information inoperative number panasonic phone program security support theft theftloc (PIC4837)
2008-03-31: Escalation Process for Critical Orders for Electronic Service Center (ESC) Parts (06-00-89-032A)
2008-03-27: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-25: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories (08-03-10-004)
2008-03-25: Essential Service Tool Update #1 (U.S. Retailers Only) (08-00-89-011)
2008-03-19: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication failedtovoice information intermittent OPC operation no noconnect performance (PIC4310B)
2008-03-14: SWC Operation After OnStar ADT Upgrade - keywords call calling control inoperative operation onstar steering wheel (PIC4820)
2008-03-11: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006D)
2008-03-05: Unable To Receive Incoming OnStar Or HFC (Hands Free Calling) Calls - keywords blue button call cellular communication data digital incoming noconnect operation program tech2 UE1 vs3bgen6 vs3bgen7 (PIC4393G)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-28: Battery Electrical Drain / Parasitic Load Test - keywords dead draw drop resistor voltage (PIC4790)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-25: General Motors Position Statement on Installation of Used, Salvaged or Imitation Air Bag System Components (08-09-41-003)
2008-02-19: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-006)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-06: GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078B)
2008-02-05: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
2008-02-05: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience (04-06-01-029B)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-02-01: Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
2008-02-01: Distortion in Outer Surface of Vehicle Glass (00-08-48-005C)
2008-02-01: Information on Eliminating Noise in Audio System When Using Portable Playback Device (06-08-44-015A)
2008-01-31: Vibration Analysis Worksheet (03-00-91-001D)
2008-01-25: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006B)
2008-01-25: Information on New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
2008-01-23: 18 Digit Snapshot/Charge Summary Code No Longer Required for A/C Refrigerant System repairs Submitted for Warranty Reimbursement (05-01-38-008B)
2008-01-18: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-17: Engineering Information (EI) Process (04-00-89-053B)
2008-01-17: Re-establishing Communications with OnStar Center After Battery Disconnect (00-08-46-004C)
2008-01-17: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007D)
2008-01-15: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003C)
2008-01-15: GM Technical Assistance Information Form (TAC) and Service Strategy Process Utilizing Customer Service Comeback Prevention, Strategy Based Diagnostics (SBD) and Intermittent Concern Diagnosis (01-00-89-011g)
2008-01-09: Availability of GM OnStar Vehicle Diagnostics and GM Goodwrench Remote Diagnostic Services (06-08-46-002B)
2008-01-09: Seat Belt Extender Availability (99-09-40-005E)
2008-01-09: OnStar Labor Operation Codes (05-08-46-005B)
2008-01-08: Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems (02-08-44-007C)
2008-01-08: Incorrect OnStar Global Positioning System (GPS) Location Reported During OnStar Call (02-08-46-006C)
2008-01-07: Tire Puncture Repair Procedures for All Cars and Light Duty Trucks (04-03-10-001D)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2007-12-17: Warranty Parts Center/Corporate Parts Return Program (99-00-89-019E)
2007-12-13: Essential Service Tool Update #8 (U.S. Retailers Only) (07-00-89-061)
2007-12-10: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT - CH-47976) (03-06-04-030F)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-29: GWM Warranty Parts Center Return Program (05-00-89-042C)
2007-11-19: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007C)
2007-11-12: Customer Concern Not Duplicated/Verified Labor Operations (06-00-89-026A)
2007-11-09: Underbody Corrosion - keywords appearance body frame rust (PIT3749B)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Corrosion Protection for Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008D)
2007-10-24: Essential Service Tool Update #7 (U.S. Retailers Only) (07-00-89-053)
2007-10-23: Information on Proper Tire Pressure (00-00-90-002I)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-09-28: Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
2007-09-21: Essential Service Tool Update #6 (U.S. Retailers Only) (07-00-89-049)
2007-09-21: Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires (03-03-10-007C)
2007-09-17: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016A)
2007-09-05: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
2007-08-29: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords B1000 blue button communication DTC information message no noconnect OnStar operation (PIC4600)
2007-08-23: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors (07-00-89-043)
2007-08-16: Warranty Admin. - Courtesy Transportation and Roadside Assistance Programs (07-00-89-037)
2007-08-14: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016)
2007-08-02: Warranty Admin. - GM Dealer Empowerment Program and Goodwill Procedures (05-00-89-055B)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-07-26: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022D)
2007-07-19: Essential Service Tool Update #5 (U.S. Retailers Only) (07-00-89-032)
2007-07-19: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) (06-08-50-009B)
2007-07-19: Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
2007-06-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for June, 2007 (06-00-89-041G)
2007-06-27: GM Training:Introducing 2007 Saturn Training Bonus (U.S. Dealers) (07-00-89-029)
2007-06-27: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 (07-01-38-004)
2007-06-27: GM Training:May 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-028)
2007-06-26: GM Training:Saturn Report Changes (U.S. Dealers) (07-00-89-017)
2007-06-26: GM Training:Announcing the 2008 Body Structural and Painting Service Training Standards (STS) Requirements for Saturn Dealers (U.S. Dealers) (07-08-51-002)
2007-06-26: GM Training:Number of Technicians Required Reduced for Two Categories (U.S. Dealers) (07-00-89-016)
2007-06-26: GM Training:Three Technology Close-Up IDL Seminars as New 2007 Service Training Standard (STS) Requirements (U.S. Dealers) (07-00-89-014)
2007-06-26: GM Training:March 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-013)
2007-06-26: GM Training:Course Information (For U.S. Dealers and Aftermarket) (07-00-89-011)
2007-06-26: GM Training:January 2007 GM Service Know-How Emerging Issues Seminar (#10207.01D) (For U.S. Dealers Only) (07-00-89-007)
2007-06-26: GM Training:Maintaining GM STC Master Technician Certification (MTC) (For U.S. Dealers Only) (07-00-89-005)
2007-06-26: GM Training:HVAC Systems and Operation Stage 2 WBT and IDL (11044.03) (For U.S. Dealers Only) (07-01-38-001)
2007-06-26: GM Training:Saturn Person Types Renamed on the GM Training Website (For U.S. Dealers Only) (07-00-89-006)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-22: Use of Silicone for Weatherstrip Maintenance (99-08-64-016B)
2007-06-21: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage (00-06-01-026B)
2007-06-18: Essential Service Tool Update #4 (U.S. Retailers Only) (07-00-89-026)
2007-06-14: Communication Strategy of Service Information/Strategy Based Diagnostics (05-00-89-067B)
2007-06-12: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT - CH-47976) (03-06-04-030E)
2007-06-08: Windshield Wiper Performance, Cleaning Instructions and Maintenance (06-08-43-003A)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-24: Corrosion Protection for Metal Panels with Dealer Installed Accessories Fastened by Drilled Holes (03-00-89-008C)
2007-05-23: Disc Brake Warranty Service and Procedures - LRO, Lateral Runout, Rotor, Corrosion, Pulsation, Pads, Wear, Noise, Refinish, Clean-up, Squeak, Grind, Groan (05-05-22-002C)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-17: Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-04-02: Info - Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair (07-08-98-001)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-13: Information on OnStar System - Possible Loss of GPS and/or Unable to Replenish Hands-Free Calling Minutes (02-08-46-007B)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-15: Info - New Bulletin Category: Technical Training (U.S. Only) (07-00-89-003)
2007-02-01: Incorrect Mileage After BCM Programming - keywords BCM incorrect mileage odometer program s saturn sl series (PIC4403)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-23: Info - Unnecessary Engine Crankcase and Subsystems Flushing Services and Proper Utilization of Saturn Simplified Maintenance Schedule to Enhance Customer Service Experience (04-00-90-004A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2006-12-14: Info - Essential Service Tool Update #9 (U.S. Retailers Only) (06-00-89-056)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-27: Info - New Bulletin Categories (05-00-89-005A)
2006-11-17: Info - Essential Service Tool Update Number 8 (U.S. Retailers Only) (06-00-89-049)
2006-11-09: Crank No Start When Cold Due To Compression Loss - keywords cylinder cylinderhead extended hard head lifter loss (PIP3146B)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-15: Information Regarding Updated PC Grade Specifications and Techline Support (U.S. Only) (06-00-89-045)
2006-09-14: Information for Diagnosing and Servicing Customer Concerns of Vehicle Creeping Forward in Neutral, binding in Reverse and/or Clicking or Whining in All Forward Gears After Transaxle Service (06-07-30-024)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-08: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (06-08-111-004)
2006-09-07: Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-17: 4T65E Whine Noise Park/Neutral - keywords bearing drive sprocket support (PIP3894)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-07-20: Information on Servicing Saturn S-Series Lock Cylinder Components (06-00-89-035)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-05: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for May, 2006 (06-00-89-028)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for April, 2006 (06-00-89-023)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Intermittent Neutral from a Stop or 2-3 Shift - keywords 4L60E 4L65E flare launch slip (PIP3002D)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-31: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for March, 2006 (06-00-89-017)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-07: Intermittent No Crank, No Start (Clean Battery Side Terminal Stripped Threads, Replace Battery Cable Bolt) (02-06-04-015A)
2006-03-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for February, 2006 (06-00-89-012)
2006-02-24: Service VME - Underbody Corrosion - keywords appearance body frame rust (PIT3749A)
2006-02-24: Questions Regarding Installation of Dealer Installed Accessories - keywords 2.8 3.5 4.2 4.8 5.3 6.0 8.1 accessory part Partech (PIT3099C)
2006-02-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for December, 2005 and January, 2006 (06-00-89-007)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-27: Info - Essetnial Service Tool Update No. 1 (U.S. Retailers Only) (06-00-89-005)
2006-01-04: Unable to Connect to OnStar or OnStar Personal Calling Inoperative in Alaska Only (Cancel Corporate Bulletin Number 05-08-46-002A) (05-08-46-002B)
2005-12-21: Info - Essential Service Tool Update No. 7 (U.S. Retailers Only) (05-00-89-087)
2005-12-09: Info - Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems (02-08-44-007B)
2005-12-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for November, 2005 (05-00-89-085)
2005-11-23: Info - Essential Service Tool Update Number 6 (U.S. Retailers Only) (05-00-89-081)
2005-11-18: Warranty Admin. - Warranty Parts Center/Saturn Parts Return Program Concerns (05-00-89-080)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-11-04: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for October, 2005 (05-00-89-077)
2005-10-27: Radio Displays XM Error or DTC U1137 - keywords communication digital loss nocomm operation performance tech2 U2K (PIC3303A)
2005-10-26: Info - Transition of Saturn Technical Training to GM Service Technical College (STC) Training Program (U.S. Only) (05-00-89-073)
2005-10-03: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues and Parts Restriction Information for September, 2005 (05-00-89-064)
2005-09-23: Info - Essential Service Tool Update Number 5 (U.S. Retailers Only) (05-00-89-063)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-09-09: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in July and August, 2005 (05-00-89-061)
2005-08-26: Info - Essential Service Tool Update #4 (U.S. Retailers Only) (05-00-89-058)
2005-08-22: Warranty Admin. - Restriction on Battery Warranty Claims (05-06-03-006)
2005-08-11: Info - Pinstripe/Vinyl Graphic Installation Tips and Techniques (04-08-51-004A)
2005-07-21: Enhancement to Saturn Goodwill Rental Car Program (U.S. Only) (05-00-89-044)
2005-07-01: Info - Essential Service Tool Update Number 3 (U.S. Retailers Only) (05-00-89-040)
2005-07-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in June, 2005 (05-00-89-039)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-23: Warranty Admin. - GM New Vehicle Tire Warranty Program (U.S. Only) (05-03-10-009)
2005-06-02: Saturn Field Product Reminder-Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Service Bulletins Released in May, 2005 (05-00-89-033)
2005-05-25: Compact Disc (CD) Player Inoperative - Will Not Load, Will Not Eject or Will Not Play (Remove Both Radio Fuses to Reset Radio) (04-08-44-018A)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-12: Information on Service Support and Technical Assistance for OnStar (U.S. Only) (05-08-46-003A)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in April, 2005 (05-00-89-028)
2005-04-27: Info - Labor Time Guide Requests for Review (U.S. Retailers Only) (05-00-89-026)
2005-04-26: Info - XM Radio Labor Operation Codes (03-08-44-001A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-15: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in February and March, 2005 (05-00-89-016)
2005-03-10: Warranty Admin. - New Definition for Parts Warranty Case Type (05-00-89-015)
2005-02-23: Info - Extended Warranty Available for Saturn Tech 2 Scan Tools (05-00-89-010)
2005-02-11: Quick Tips for Warranty Administration (05-00-89-007)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-02: Power Steering System Noise and/or Leak Diagnosis (02-02-32-009A)
2005-01-31: Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Bulletins Released in December 2004 and January 2005 (05-00-89-004)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2004-12-21: Delay and/or Harsh into Drive, or Harsh into Reverse or 2nd / 3rd / 4th After Trans Repair - kw bump clunk hesitation upshift shift MP6 MP7 transmission transaxle automatic (PIP3175A)
2004-11-29: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in November 2004 (04-00-89-058)
2004-11-11: Coolant Temperature Telltale Inoperative and/or Coolant Gauge Inoperative - kw light lamp hot instrument cluster IP IPC (PIC3237)
2004-10-26: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in October, 2004 (04-00-89-048)
2004-10-22: Hesitation or Stumble During Tip-In Launch After Spark Plug Wires Were Reinstalled or Replaced - kw 1.9 L24 LL0 SOHC DOHC accelerate throttle (PIP3199)
2004-10-20: Info - New Measuring Wheel Alignment Procedure for Labor Operation Numbers E2020 and E2000 (04-03-07-003)
2004-10-07: Cruise Control Is Inoperative or Will Not Set / Engage after the Manual Transaxle Has Been Replaced - kw MP2 MP3 transmission module (PIP3178)
2004-10-01: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in September 2004 (04-00-89-044)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-09-03: Odor from A/C at Vehicle Start-Up (Remove Debris from Evaporator Case, Disinfect Evaporator or Apply Cooling Coil Coating and/or Enable Afterblow Function) (99-01-37-009B)
2004-08-30: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in August, 2004 (04-00-89-037)
2004-08-26: Replacement Sunroof Module Motor Harness Connection Changes - kw plug terminal (PIC3116)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-17: Popping/Crackling Noise or Distorted Sound from Speakers at Low Volume When a Compact Disc (CD) is Played (Replace RPO U1C CD Player/Radio with New Design CD Player/Radio) (04-08-44-016)
2004-08-16: 2002 Saturn S-Series Sedans (02-C-05)
2004-08-16: 2002 Saturn S-Series Vehicles (All Models) (02-C-01)
2004-08-16: 2002 Saturn S-Series Vehicle Equipped with Automatic Transaxles (02-C-06)
2004-08-09: Steering Wheel Shake or Vibration at 100-109 km/h (62-68 mph) (Follow Vibration Complaint Flow Chart, Replace Hub Assembly, If Necessary) (04-03-10-008)
2004-08-02: Saturn Field Product Reminder - Vehicle Fix It Right the First Time issues, Parts Restriction Information and Technical Bulletins Released in June and July 2004 (04-00-89-031)
2004-07-28: 1991-2002 ZB Saturn No Fluid Pressure , No Drive , No Reverse - kw transmission MP7 MP6 inoperative forward automatic A/T gear (PIP3082)
2004-07-02: Info - Return Form for Compact Discs (CDs) or Digital Versatile Discs (DVDs) That Are Stuck in CD Player When Returned as a Core Return (04-08-44-015)
2004-06-22: Theft Deterrent Feature Will Not Set On Cassette Single CD Player Radio (RPO UP0) (Replace Radio) (04-08-44-013)
2004-06-15: Saturn Field Product Reminder - Vehicle Fix It Right The First Time Issues, Parts Restriction Information and Technical Bulletins Released in May, 2004 (04-00-89-023)
2004-05-27: Info - Remanufactured Transmission and Remanufactured Valve Body Information Requirements (04-07-30-026)
2004-05-12: (SES) Service Engine Soon Light On with Diagnostic Trouble Code (DTC) P0731, No Movement in Drive During Cold Ambient Temperatures (Replace Oil Pump or 1st Gear Sprag Clutch Assembly) (03-07-30-008A)
2004-05-06: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in April, 2004 (04-00-89-017)
2004-04-22: Red OnStar LED , No Keypad Response When Pushed DTC B2476 - kw inoperative UE1 (PI02018)
2004-03-30: Saturn Field Product Reminder - Vehicle Fix It Right the First Time Issues, Parts Restriction Information and Technical Bulletins Released in January, February and March 2004 (04-00-89-012)
2004-02-20: 4L60E , 4L65E No 2nd , No 4th and No Reverse - automatic fourth second shift transmission (PI00822C)
2004-01-15: Service Information Regarding Service Applications for Automatic Transaxle Shift Solenoids (00-07-30-024A)
2004-01-06: Whistle Noise at Highway Speeds with HVAC in Recirc Mode (Repair Sealer Skip in the HVAC Plenum Area) (04-01-38-001)
2003-12-19: Compact Discs (CDs) Skip In Single CD Player (Replace Radio Assembly) (03-08-44-016A)
2003-10-06: Security Indicator Illuminated or Flashing, Engine Starts then Stalls and/or Disabled for 10 Minutes, Diagnostic Trouble Code P1632 Set (Follow Bulletin Diagnostic Table) (03-08-56-003)
2003-09-30: SMU for Powertrain and Engine Service Manuals Regarding Evaporative Emission Flowcharts and EVAP Pressure/Purge Diagnostic Cart Test Procedure (02-T-02)
2003-09-30: Objectionable Engine Vibration at Idle (95-T-36A)
2003-09-11: Info - Changes to the U1C Radio On-Board Diagnostic Modes and CD Load Operation (03-08-44-017)
2003-08-29: Info - Clarification of Labor Codes Used for Reprogramming Vehicle Controllers (03-00-89-025)
2003-07-22: Automatic Transaxle 2-3 Shift Flare During First Minutes of Driving After Cold Start (Perform Bulletin Procedure) (03-07-30-033)
2003-04-24: Front and Rear Side Door Window Frame Appliques and/or Windshield Frame Filler Panel Appliques Exhibiting Top Coat Paint Peeling (02-T-71)
2003-04-24: A/C System R-134a Refrigerant Ultra Vilet (UV) Dye Usage (02-T-75)
2003-04-24: Difficulty with Manual Transaxle Shifting Into Gear While Engine is Running (02-T-76)
2003-04-16: Engine Hesitation and/or Vehicle Lacks Power with DTC P0326 Knock Sensor System Performance Set (03-T-02)
2003-04-16: Rear Side Door Glass Will Not Go Up or Down, or Will Fall Down Unintentionally (03-T-05)
2003-03-07: Bumps or Iron Dust on Paint Surface (Apply Buffered Oxalic Acid Spray or a Clay Type Non-Acid Based Product Using Manufacturers Recommendations) (99-08-51-006C)
2003-02-25: Vehicle Vibration at Speeds Between 77-87 km/h (48-54 mph) (00-T-57A)
2003-01-08: Rubbing Compound on Paint Surface (92-T-55F)
2003-01-07: Service Information Regarding Upper Engine Mount Assembly (01-T-30A)
2003-01-06: Engine Coolant Recovery Reservoir Discoloration Due to Engine Cooling System Sealer (97-T-04A)
2003-01-02: Seat Belt Latch Falls to the Floor or is Difficult to Retrieve (01-T-44)
2002-12-20: Clogged Windshield Washer Nozzle and/or Poor Windshield Washer Spray (01-T-35)
2002-12-20: Service Information to Provide New Procedure for Sunroof Actuator Motor to Module Timing (01-T-42)