Technical Service Bulletins

2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-23: Special Coverage Adjustment - Analog OnStar Deactivation (08089B)
2008-09-22: Information on OnStar Analog-Only Systems (06-08-64-007A)
2008-09-05: Information on Speedometer Accuracy (08-08-49-011B)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
2008-06-04: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
2008-06-02: Harsh Ride or Line Installation Conern with Delco Shock Kit- keywords fit fitting harsh hose install instruction kit rear ride sheet spring suspension (PIC4887)
2008-05-30: Poor Radio Reception or Radio Static/Increased Interference with Rear Window Defogger On or Some Rear Window Defogger Grids May Be Inoperative (Diagnose and Repair Rear Window Defogger Heating Grid) (03-08-44-005H)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Oil Leak, Lower Crankcase Reseal - RTV Sealant Procedure with Current Engine Oil Manifold/Distribution Plate (03-06-01-027A)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-04: Blower Motor Inop On Initial Start Up (PIC4843)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-01-30: Remote Keyless Entry Operational Characteristics (99-08-52-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-15: New Thread Repair Kit Available for Damaged Engine Block Bolt Holes (99-06-01-015A)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-30: OnStar Unwanted or Phantom Phone Calls - keywords call handsfree intermittent mmute OnStar OPC performance phantomcalls unwanted (PIC3278C)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication digital failedtovoice information intermittent OnStar OPC operation no noconnect (PIC4310A)
2007-10-29: Revised General Motors New Vehicle Tire Warranty Program (00-03-10-003M)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-21: Information on 2-3 Upshift or 3-2 Downshift Clunk Noise (01-07-30-042E)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-12: DTC C1255 With Various Sub Codes - keywords EBTCM ICCS TCS (PIC4036A)
2007-03-09: Poor Radio Reception or Radio Static/Increased Interference with Rear Window Defogger On or Some Rear Window Defogger Grids May Be Inoperative (Diagnose and Repair Rear Window Defogger Heating Grid) (03-08-44-005G)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2006-12-13: Information on OnStar Analog-Only Systems (06-08-46-007)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-19: Difficult to Maintain Desired HVAC Temperature, HVAC Blower Noisy (Update HVAC Calibrations with Tech 2) (03-01-39-006B)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-10: Info - Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-22: Info - Pitting and Brake Dust on Chrome Wheels (04-03-10-012A)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-12: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
2006-08-29: Info - Cartridge Type Crankshaft Rear Main Seal (00-06-01-005A)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-08: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002D)
2006-05-30: GM Product Recall Campaign Follow Up Post Card (06-00-89-019A)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-17: Info - Instructions to be Followed to Aid in Obtaining Root cause Analysis on Both OEM and Goodwrench Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
2006-05-02: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-06: Discontinuation of the Field Product Reminder Bulletin/Bulletin Subscription Information (06-00-89-018)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-29: Info - Vibration Analysis Worksheet (03-00-91-001C)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-02: Warranty Admin. - Labor Operation Assignments for All Control Module Reprogramming (02-06-04-057E)
2006-03-01: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
2006-02-17: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance (06-08-45-001)
2006-02-14: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004b)
2006-02-14: Info - Diagnostic Tips For Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036F)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-24: Info - Expediting Warranty Parts (99-00-89-021E)
2006-01-20: Service VME - Missing Camshaft Intermediate Drive Shaft Plug - keywords block camshaft drive engine intermediate LD8 L37 low missing no oil pressure plug replacement shaft short shortblock (PIP3687)
2006-01-18: Info - New Product Feedback Form and Process for Automatic Transmission Core Returns (01-07-30-029A)
2006-01-12: 4T65-E Automatic Transmission Fluid Leak from Reverse Servo Cover (Replace Reverse Servo Cover Seal) (04-07-30-028A)
2006-01-04: Info - Maintenance Cleaning of Fuel Injectors (04-06-04-051B)
2005-12-22: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
2005-11-21: Info - Paint-less Dent Repair Process (99-08-51-001A)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-10-20: Click Noise when Braking or on Coast Down; Buzz Noise when Reverse Engaged; Tick Noise during 2-3, 3-2 Shifts - keywords 4T80E accumulator clip cold cover decelerate down MH1 pin side upshift (PIP3594)
2005-10-20: Reverse Lockout Solenoid Click Noise - keywords console electrical noise shifter solenoid tick (PIP3595)
2005-10-06: Info - Transmission Fluid Leak Diagnosis (01-07-30-041B)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-08-18: Info - Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
2005-08-17: Info - Release of GM Tool Organizaiton DVD Version 8.0 (J-43921-G) (05-00-89-056)
2005-08-10: Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inop I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
2005-08-05: Info - SPAC Case Escalation Process (05-00-89-050)
2005-08-02: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case (05-04-21-004)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-27: Warranty Admin. - Out-Of-Warranty Parts for Engineering Analysis (05-00-89-037)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-08: Info - On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
2005-06-03: Goodwrench Powertrain Wholesale Program (U.S. Only) (05-06-01-017)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-15: Unwanted Alarm Activation, Trunk Key Cylinder Hard to Open, Trunk Ajar Lamp On, Fuel Gage Inop, RKE Inop, Interior Lamps Inop and/or No Communication with the RIM - keywords cluster dome door entry no (PIC3357A)
2005-04-12: Info - Top Tether Hardware Package for Child Restraint Seats (99-09-40-004a)
2005-04-12: Info - OnStar System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-17: Info - GM Parts Ordering System (05-00-89-018)
2005-03-08: Info - Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
2005-03-08: Info - OnStar Kit Part Numbers and Compatibility (99-08-46-001A)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-09: Info - Proper Air Bag System Diagnosis and Service (03-09-41-003A)
2005-01-31: Warranty Admin. - Guidelines for Claiming C0034 - Windshield Replacement (05-08-48-001)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-14: Info - OnStar Proactive Parts Shipment Process (02-08-46-013A)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2004-12-15: ABS Light On DTC C1226 or Unwanted ABS or TCS Activation 1996 - 2000 Eldorado 1997 Seville 1997 - 1999 Deville- kw brake accelerate (PIC3300)
2004-12-13: Info - Battery Specification Label (04-06-03-016)
2004-12-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022C)
2004-11-29: Floor Pan Corrosion Perforation in Battery Compartment (Install Repair Kit) (04-08-61-001A)
2004-11-18: Info - Shipping Enhancements for Owners Manuals and Service Manuals Ordered from Helm, Inc. (04-00-89-057)
2004-11-18: Warranty Admin. - Warranty Return Parts (04-00-89-051)
2004-11-15: High Speed Shake or Vibration - kw 00-03-10-007G alignment rear seat tire vibration wheel (PIC3249)
2004-10-27: Information on Northstar Engine Mechanical Repairs (04-06-01-032)
2004-10-20: Info - Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
2004-10-11: Info - Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002A)
2004-10-01: Shake/Vibration in Steering Wheel, Floor, Seat at Highway Speeds on Smooth Roads (Diagnose/Balance Tires/Wheels) (00-03-10-007G)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-14: Info - Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (01-01-38-006D)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-06: Service Engine Soon (SES) Light On, Diagnostic Trouble Code (DTC) P0741, Torque Converter Clutch (TCC) Excessive Slip, Transaxle Chuggle, Slip/Surge (Inspect/Replace Internal Transaxle Components) (04-07-30-034)
2004-08-03: Warranty Admin. - Dealer Installed Regular Production Options (RPO) and Regular Production Accessories (RPA) (01-00-89-015A)
2004-08-02: Info - Repair Procedure for Service Sheet Metal, Craters in ELPO Surface (04-08-98-002)
2004-07-27: Warranty Admin. - Changes to General Motors Vehicle Inquiry System (GMVIS) (04-00-89-029)
2004-07-23: Info - Application of Anti-Corrosion Materials (01-08-51-003A)
2004-07-02: Info - Battery Parasitic Drain (02-06-03-010A)
2004-06-22: Info - J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
2004-06-22: Info - New Owner Orientation Clinic Materials Now Available Online (03-00-89-002A)
2004-06-11: Vehicles with Multiple DTCs C1282 , C1283 , C1284 , C1285 , C1287 , C1288 - kw ABS accelerate aggressive brake calibration diagnostics DTC EBTCM electrical engage ICCS incorrect performance sensor (PIC3015)
2004-06-08: DTC P0442 Small Leak Detected, Inspect at Fuel Filler Neck - kw corrosion (PIP3003)
2004-05-26: Info - Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
2004-04-29: Information on Serpentine Belt Wear (04-06-01-013)
2004-04-22: Red OnStar LED , No Keypad Response When Pushed DTC B2476 - kw inoperative UE1 (PI02018)
2004-03-29: Warranty Administration - Part and Accessory Replacement Policy (04-00-89-011)
2004-03-18: No TCC Apply , MIL On , TCC Surge , Possible P0740 , P1870 , or 39 after Installation of Reman ( SRTA ) 4T60 / 4T60E - kw case cover converter slip transmission (PI01880A)
2004-03-04: 4.0L L47 4.6L LD8 L37 Engine Intermittent Slow Speed Decel - kw decelerate DTC EGR IAC MIL PCM P1599 stall (PI01803)
2004-02-26: 4.0L L47 , 4.6L LD8 L37 Engine - Water Pump Cover P/N 12571913 - Thermostat Loose - kw 03-06-02-004B coolant (PI01792)
2004-02-23: 4.0L L47 , 4.6L LD8 , L37 LH2 Engine Coolant or Oil Leak - kw back block cylinder drive head intake main manifold panporosity rear (PI01771)
2004-02-11: Info - 4L65-E, 4L60-E, 4L60 and 200-4R Automatic Transmission Oil Pump Spring First and Second Design Identification (04-07-30-006)
2004-02-05: Warranty Admin. - Dealer Disclosure Requirements (02-00-89-005A)
2004-02-04: Indentation of Rear Fascia near URPA Sensor - kw appearance body (PI01709)
2004-01-21: Front/Rear Heated Seat Inoperative/Cold (Install Seat Heat Element) (01-08-50-002C)
2003-12-11: 4.6L L37 LD8 Engine Exhaust Leak Noise Heard Inside the Vehicle (PI00062A)
2003-11-11: Info - Search Tips for Locating Preliminary Information (PI) Documents in Service Information (03-00-89-039)
2003-11-11: Engine Cold/Knock/Tick Noise (Clean Deposits) (99-06-01-010C)
2003-10-29: Info - Release of New Outer Tie Rod Ends for Service (03-02-32-049)
2003-10-29: Diagnostic Information to Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
2003-10-23: Higher Than Expected Oil Consumption (Clean Piston Rings) (02-06-01-009C)
2003-09-19: Warranty Admin. - Sublet Administrative Allowance (Coverage: S) Labor Operations (03-00-89-027)
2003-08-21: Uneven Brake Wear - caliper erratic front hydraulic outboard pad outboard right rotor (PI00222A)
2003-08-18: Info - Steering Column To Instrument Panel Fastener Removal (01-02-35-009A)
2003-08-13: 4.6L LD8 , L37 Engines Oil Consumption Greater than 1 Qt. in 2,000 Miles - cylinder economy (PI00606A)
2003-07-30: SMU - Revised Steering Wheel Position Sensor or Steering Shaft Lower Bearing Replacement Procedure and Steering Wheel Position Sensor Centering Procedure (03-02-36-002)
2003-07-30: Rear Compartment Carpet Wet/Musty Odor and/or Spare Tire Well Wet (Replace Rear Compartment Lid/Opening Weatherstrip) (03-08-66-009)
2003-07-14: Info - J 44551 A/C Suction Screen Kit Repair Recommendations and Procedures After Catastrophic Compressor Failures (01-01-39-003A)
2003-07-14: Info - HomeLink Transceiver/Garage Door Opener Transmitter Test Kit Available As Essential Tool (01-08-97-001B)
2003-06-25: Info - Most Frequently Asked Questions and Answers for J 45096 TransFlow Transmission Oil Cooling System Flushing Machine (03-07-30-027)
2003-06-10: Service VME - Transflow Transmission Cooling System Service Tool J45096 Optional Heater Blanket - 3T40 372LE 3L30 3T40 4L30E 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60E 4T65E 4T80E 5L40E automatic fluid (PI01163)
2003-04-29: Warranty Admin. - Courtesy Transportation Program (02-00-89-004B)
2003-04-24: Info - Bulletins Released Week of April 14, 2003 and Car and Truck Fix It Right the First Time Issues (03-00-89-010)
2003-03-14: Info - Automatic Air Conditioning Control Operation (99-01-39-007B)
2003-03-12: HVAC Afterblow Enable Procedure - blower fan information IPM module odor (PI00923)
2003-03-07: Info - A/C Refrigerant System Sealer and A/C System Leak Detection Guidelines (03-01-38-001)
2003-03-07: Info - Changes to Essential and Available Tool Numbering System (03-00-89-005)
2003-02-27: Info - Powertrain Quality Center for Performance Parts Engine Replacements (03-06-01-006)
2002-12-16: Adm Msg - New Labor Time Guide Available Effective February 1, 2003 (WIW20020026)
2002-10-25: Proper Diagnostic Procedures for No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, SIR, Brake, Security, Theft, ABS, Hot, DIC Messages, Lamp, Light, Battery and Generator Diag. Testing (02-06-03-012)
2002-09-23: Adm Msg - Important Programming/TIS Information for Technicians (Admin Number 20020120 - 9/10/02) (VSS20020120)
2002-09-19: Service VME - Inside Air Temperature Sensor Noisy (PI00484)
2002-08-14: Service VME - Headlamp Dimming or Flicker (PI00384)
2002-08-09: Info - Engine Crankcase Flush (02-06-01-028)
2002-07-24: Warranty Admin. - Claim Procedures for Warrantable Electronic Failures on Vehicles Sold As Certified Used Vehicles or Certified Pre-Owned Vehicles (02-00-89-013)
2002-07-19: Warranty Admin. - Revised Empowerment Level-Authorization Code E (02-00-89-009)
2002-07-19: Info - Preliminary Information (PI) Text Available in Service Information (SI) (02-00-89-008)
2002-07-08: Discoloration of Interior Wood Trim (PI00145)
2002-06-21: Info - Expandable Acoustic Foam (Two Component Sound Dampener) Usage with Collision Damage Repairs (02-08-98-003)
2002-06-13: Info - Automatic Transmission Serial Number and Site Code Locations (02-07-30-028)
2002-06-13: Info - Engine Identification Information (02-06-01-026)
2002-05-22: Clunk/Rattle Noise from Lower Steering Column Area When Traveling Over Road Bumps (Replace Lower Steering Shaft Bearing Assembly) (02-02-35-004)
2002-04-09: Squeak/Squawk Noise from Front of Vehicle When Traveling over Road Bumps/Swells (Replace Front Spring Seat and Upper Insulator) (02-03-08-004)
2002-02-27: Information on a New Engine Preluber Tool (02-06-01-008)
2002-01-30: SMU - Revised PASS-KEY III Relearn Procedure (02-08-56-001)
2001-12-18: Info - Tire Sidewall Damage (01-03-10-011)
2001-11-14: Info - Test Guidelines for Use of Essential Tool J41413-200 Evaporative System Tester (01-06-04-044)
2001-10-04: Info - Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
2001-09-18: Rear Brake Moan/Hum Noise During Brake Apply (Replace Rear Disc Brake Pads) (00-05-23-001A)
2001-09-17: Warranty Admin. - Correct Use of Labor Operation R4490, RKE Transmitter, Replace (01-00-89-013)
2001-09-13: SMU - Side Impact Air Bag Inflator Module Replacement (01-09-41-008)
2001-06-21: Info - Seat Belt System Replacement Guidelines for Vehicles Involved in Collisions (01-09-40-002)
2001-05-08: Info - Replacement of Keys, Key Numbers and/or Security Chips (01-00-89-009)
2001-04-09: Info - Guidelines for Use of Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
2001-04-06: Info - Current CIPS Campaign Number to Previous DIvisional Campaign Number (01-00-89-008)
2001-03-05: SMU - Revised Tool Requirements for Front and Rear Brake Caliper Overhaul (01-05-23-003)
2001-03-02: Info - February, 2001 Bulletin Summary (01-00-89-006)
2001-02-02: Info - January, 2001 Bulletin Summary (01-00-89-005)
2001-01-03: Info - December, 2000 Bulletin Summary (01-00-89-001)
2000-12-18: Warranty Admin. - January 1, 2001 Labor Time Guide Updates (00-00-89-031)
2000-12-15: SMU - Revised Heater Module/Heated Seat Control Module Front Replacement Procedure (00-08-50-016)
2000-12-15: SMU - Revised Memory Seat Control Module Replacement Procedure (00-08-50-015)
2000-12-15: SMU - Revised Track and Motor Synchronization Procedure (00-08-67-007)
2000-12-15: SMU - Revised Power Sunroof Motor Replacement Procedure (00-08-67-006)
2000-12-04: Info - November, 2000 Bulletin Summary (00-00-89-030)
2000-11-13: Warranty Admin. - December, 2000 Labor TIme Guide Updates (00-00-89-029)
2000-11-02: Info - October. 2000 Bulletin Summary (00-00-89-028)
2000-10-25: SMU - Addition of Fog Lamp Aiming Procedure (00-08-42-009)
2000-10-24: Info - The Importance of Chassis Lubrication (00-00-90-001)
2000-10-17: Warranty Admin. - November, 2000 Labor Time Guide Updates (00-00-89-025)
2000-10-17: Info - Revised Console Trim Plate Removal Procedure (00-08-49-012)
2000-10-06: Info - September, 2000 Bulletin Summary (00-00-89-024)
2000-09-21: Info - Correct Diagnostic Procedure When Reviewing A/C Performance/Leak Suspected (00-01-38-007)
2000-09-19: Warranty Admin. - October, 2000 Labor Time Guide Updates (00-00-89-023)
2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
2000-08-17: Warranty Admin. - Cross-line Warranty (00-00-89-021)
2000-08-14: Warranty Admin. - September, 2000 Labor Time Guide Updates (00-00-89-020)
2000-08-10: Warranty Admin. - New Electrical Relay Labor Operation Numbers (00-00-89-019)
2000-08-10: Info - Enhanced Aluminum Engine Component Thread Repair Process (00-06-01-016)
2000-08-08: Info - July, 2000 Bulletin Summary (00-00-89-018)
2000-08-03: Info - Essential Tool J 43600 ACR 2000 (00-01-38-006)
2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
2000-06-19: Warranty Admin. - July, 2000 Labor Time Guide Updates (00-00-89-014)
2000-06-19: Warranty Admin.- PCM Product Feedback Program (00-06-04-026)
2000-06-08: Info - California Consent Order on Settlement of Lawsuit on Batteries (Prop 65) (00-06-03-006)
2000-06-06: Info - May, 2000 Bulletin Summary (00-00-89-013)
2000-05-15: Info - Proper Service of Quick Connect EVAP System Connectors (00-06-04-021)
2000-05-12: Warranty Admin. - June, 2000 Labor TIme Guide Updates (00-00-89-012)
2000-05-09: Info - Fuel Sender Seal Service Parts Information (00-06-04-019)
2000-05-08: Info - Brake Fluid Level and Filling Recommendations (00-05-22-004)
2000-05-03: Info - April, 2000 Bulletin Summary (00-00-89-011)
2000-04-19: Distorted Sound from LH/RH Front S/D Radio Bose Speaker Assem. (Replace Speaker) (00-08-44-003)
2000-04-14: Warranty Admin. - May, 2000 Labor Time Guide Updates (00-00-89-010)
2000-04-04: Info - March, 2000 Bulletin Summary (00-00-89-007)
2000-03-23: MIL On, DTC P0503 Vehicle Speed Sensor Intermittent, Speedometer Fluctuates/Inop, Cruise Control Inop (Reposition/Replace) (99-07-30-015A)
2000-03-01: Warranty Admin. - Motors Insurance Corp (MIC) Extended Roadside Plan (00-00-89-005)
2000-02-11: Warranty Admin. - March, 2000 Labor Time Guide Updates (00-00-89-002)
2000-01-21: Info - Front and Rear Bumper Fascia (Foam) Engery Absorbers Available (00-08-62-001)
2000-01-19: February, 2000 Labor Time Guide Updates (00-00-89-001)
2000-01-13: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
2000-01-11: Info - Programming Vehicle to Accept Additional/Replacement Key(s) (00-08-56-001)
2000-01-04: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (99-09-41-004)
1999-12-06: Info - The Year 2000 (Y2K) and Vehicle Electronics (99-00-89-022)
1999-11-08: Accessory Receptacle is Inoperative (Check Aftermarket Device Plug) (99-08-45-005)
1999-11-02: SMU - Driven Sprocket Support Revised Art/Procedure for Hydra-Matic 4T80-T Auto (99-07-30-027)
1999-10-26: Info - PCM Reprogramming (99-06-04-053)
1999-10-22: Informational - CS-144 Generator Replacement (99-06-03-011)
1999-10-22: SMU - Revised Wiper Arm Replacement Procedure (99-08-43-020)
1999-10-20: Info - Radiator Repair/Replacement Guidelines (99-06-02-017)
1999-10-14: November, 1999 Labor Time Guide Updates (99-00-89-020)
1999-10-11: Clunk, Rattle Noise from Front of Vehicle (Install Anti-Slip/Friction Material) (99-03-08-005)
1999-10-08: Warranty Administration - October, 1999 Labor Time Guide Updates (99-00-89-017)
1999-10-08: Info - Discontinue Usage of Tool J 6627A for Wheel Stud Removal (99-03-10-103)
1999-10-07: Info - Installing Steering Column to I/P Studs With/Without a Bevel (99-02-32-009)
1999-10-06: Info - Cassette Player Cleaning and Maintenance (99-08-44-008)
1999-10-04: SMU - Cylinder Head Tightening Specification Clarification (99-06-01-016)
1999-09-28: Loss of Seat Mirror/Strg Column Memory Settings (Program DIM/MSM with TTM) (99-08-50-015)
1999-09-24: Popping Type Noise In Passenger Compartment (Remove Rivet From C/C Heat Shield) (99-06-05-005)
1999-08-10: Warranty Admin - September, 1999 Labor Time Guide Updates (99-00-89-016)
1999-08-06: AM Radio Reception Poor (Replace Radio Assembly) (99-08-44-004A)
1999-07-29: Info - Compact Disc (CD) Players and Compatible CDs (99-08-44-006)
1999-07-28: Warranty Admin - August, 1999 Labor Time Guide Updates (99-00-89-012)
1999-07-27: Info - Excessive Fuel Cap Replacement (99-06-04-025)
1999-07-27: Info - Color Change Info for Paint Code 86U (Red) (99-08-51-005)
1999-06-25: Warranty Admin - July 1999 Labor Time Guide Updates (99-00-89-010)
1999-06-15: SMU - Revised Generator Installation Torque Specification (99-06-03-006)
1999-06-10: Safety Campaign - Generator Rectifier Bridge Short (99013)
1999-05-25: Information - Original Equipment Chrome Plated Aluminum Wheel Identification (99-03-10-102)
1999-05-19: June 1999 Labor Time Guide Updates (99-00-89-008)
1999-05-17: Spotting on Rubber Portion of Ext. Mldgs/Weatherstrips (Exterior Finish Repair) (99-08-64-008)
1999-05-17: Sunroof Wind Noise/Buffeting (Replace Actuator and Control Module) (99-08-67-001)
1999-05-11: Driver/Passenger Seat Adjuster Rail/Track Noisy (Install Washer) (99-08-50-009)
1999-04-20: Warranty Admin. - May, 1999 Labor Time Guide Update (99-00-89-006)
1999-04-20: Info-Front Disc Brake Pads (Shoe/Lining Assem) Interim Design Change for Brakes (99-05-23-004)
1999-04-06: Labor Time Guide Updates - April 1999 (99-00-89-004)
1999-04-01: Info - 1998 Bill 101 French Label Installation Instructions (99-00-89-005)
1999-03-31: Info - Cleaning of Upper Instrument Panel Surfac (99-08-49-006)
1999-03-18: Front Seat Back Cushion Rear Side Tower Cover Gap (Rework Proced (99-08-50-003)
1999-03-12: Rear Suspension Clunk Noise Over Bumps (Secure Forward Body (99-03-09-001)
1999-03-09: Labor Time Guide Updates (99-00-89-003)
1999-03-04: Battery Insulator Replacement (99-06-03-002)
1999-03-02: Info - Instrument Cluster Identification (99-08-49-002)
1999-02-26: Essential Tool J 42000 Battery Tester (99-06-03-001)
1999-02-19: Warranty Parts Center/Corporate Parts Return Program (40-05-01C)
1999-02-16: Warranty Administration - Labor Time Updates (99-00-89-001)
1998-11-23: INFO - DIAGNOSTIC AND WARRENTY POLICY PROC. FOR RKE (83-90-17)
1998-11-16: INFO - ESSENTIAL TOOL J43435 ADJUSTER LOCKNUT (83-32-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-10-22: INFO - FAST FLASH TURN SIGNAL ARROW (83-82-12)
1998-10-21: PRODUCT RECALL CAMPAIGN QUICK REFERENCE CARD (41-01-02C)
1998-10-20: INFO - ESSENTIAL TOOL J43485 POWER STEERING BLEEDER ADAPTER (83-32-09)
1998-10-09: DOOR HANDLES ON WHITE PAINTED VEHICLES TURNING YELLOW (83-17-04)
1998-10-08: WARRANTY ADMIN - LTG UPDATES (83-05-09)
1998-10-07: INFO - ALIGNMENT SPECIFICATIONS (83-31-09)
1998-10-01: INFO - NEW WINDSHIELD AND STATIONATY GLASS URETHANE (83-15-16)
1998-09-17: FUEL GAUGE FLUCTUATES BETWEEN FULL AND EMPTY (83-83-10A)
1998-09-17: WARRANTY ADMIN. - LTG UPDATES (83-05-08)
1998-09-16: SMU - SEC. 3 - LOWER BALL JOINT REMOVAL TOOL UPDATE (83-33-05)
1998-09-16: INFO - NEW PCM CONNECTOR SERVICE KITS (83-81-32)
1998-09-16: SMU - SEC. 0B - CORRECTED CRANKCASE VENTILATION SYSTEM (83-02-01)
1998-09-14: OBD SYSTEM IMPROVEMENTS (RE-FLASH CALIBRATION) (87-65-24)
1998-09-03: VARIOUS DOOR FUNCTIONS DO NOT OPERATE PROPERLY (83-81-26A)
1998-08-25: ENGINE OIL COOLER LINES LEAK OIL (APPLY ADHESIVE TO OIL (83-62-12)
1998-08-21: WARRANTY ADMIN - LTG UPDATES (83-05-07)
1998-08-20: INFO - ESSENTIAL TOOL J-43241 REMOTE KEYLESS ENTRY AND (83-90-12)
1998-08-20: ALARM SYSTEM TRIGGERS WHEN UNLOCKING DOOR (83-90-13)
1998-08-14: INFO - CORRECT LABOR CODE USAGE FOR ENTERTAINMENT SYS. (84-96-01)
1998-08-12: WARRANTY ADMIN. - REDEFINED USE OF PARTS WARRANTY SPECIAL (80-05-03)
1998-07-29: TRUNK MOUNTED 12 CD CHANGER EJECTS INTERMITTENTLY (83-96-06)
1998-07-15: WARRANTY ADMIN. - LTG UPDATES (83-05-06)
1998-07-07: CAMPAIGN:WINDSHIELD WIPER LOW SPEED OPERATION (98025)
1998-06-24: NO INTERIOR LIGHTS WHEN OPENING UNLOCKED DOOR IN (83-82-06A)
1998-06-11: WARRANTY ADMIN. - LTG UPDATES (83-05-05)
1998-06-05: EXCESSIVE AIR FLOW COMING FROM VENTS AND/OR TOO COLD WHEN (83-11-14)
1998-06-03: INFO - NEW TOOL J-42958, REV. CHARTS AND SCHEM. FOR CRUISE (83-90-08)
1998-05-22: INFO - 1998-99 DELCO RADIO EXCHANGE REFERENCE (83-96-04)
1998-05-18: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-04)
1998-05-18: HARSH GARAGE SHIFT, HARSH OR DELAYED ENGAGEMENT OF PARK TO (87-71-65)
1998-05-13: INFO- REPLACEMENT OF DAMAGED REAR SEAT BACK CLIPS (83-16-01)
1998-05-07: WARRANTY ADMIN. - ELIMINATION OF LABOR OP. T6720- REPLACED (81-05-02)
1998-04-24: GENERAL MOTORS WARRANTY INQUIRY SYSTEM (82-05-05)
1998-04-24: DELAYED OR NO ENGINE BRAKING IN D3 (REPL. FORW. (87-71-64)
1998-04-21: WARRANTY ADMIN - REQ. FOR WHOLESALE AUTH. OR WARRANTY (82-05-02)
1998-04-16: INFO. - PROPER ADJUST OF NEW TWIST-LOCK STYLE BRAKE (83-83-12)
1998-04-16: SQUAWK TYPE NOISE FROM FRONT SUSPENSION (83-33-03)
1998-04-16: RIDE HEIGHT TOO LOW 7/OR AIR PUMP RUNS ALL THE TIME (83-34-09)
1998-04-16: WARRANTY ADMIN. - LTG UPDATES (83-05-03)
1998-04-16: INFORMATION - 1998-99 GM SOUND SELLING RADIO PROGRAM (83-96-03)
1998-04-02: INFO. USE OF'SURFACE CONDITIONING DISCS' (87-61-24)
1998-03-25: WARRANTY ADMIN. - NEW ESSENTIAL TOOL, J-42983 (81-05-01)
1998-03-16: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-02)
1998-03-10: SMU-SEC.6E-ENG.CONTROLS REV. FUEL PRESSURE (81-63-05)
1998-03-10: INFO. NEW TOOL J-41450-B RELEASED FOR CS GEN DIAG. (83-64-09)
1998-03-05: ACCESSORY DRIVE NOISE (FOLLOW DIAG. PROC.) (87-61-20)
1998-03-02: INFO - FUEL LEVEL SENSOR REPLACEMENT PROC (83-83-07)
1998-02-25: INFO - INSTRUMENT CLUSTER ID. (83-83-09)
1998-02-20: WARRANTY ADMIN - LABOR TIME GUIDE UPDATES (83-05-01)
1998-02-18: TEXT CHANGES IN 'UNIFORM' TIRE QUALITY GRADING (86-35-04)
1998-02-18: CAMPAIGN: HOOD HINGE PIVOT BOLT BREAKAGE (97070)
1998-02-13: INFO. ON VIN PLATE REPLACEMENT (83-01-14)
1998-01-28: BRAKE NOISE (GRUNT/GROAN/GRIND CRUNCH/ COMING FROM BRAKES (73-50-23A)
1998-01-14: INFO. - DIAG PROC. WHEN A/C DIAG INFO LEAK (73-12-12A)
1998-01-12: INFO. FRONT. SUPP. INFLAT. RESTRAINTS (SIR) ON-OFF SWITCH (73-90-23)
1997-12-18: WARRANTY ADMIN. - REPAIR/ REPLACE POLICIES & PROC. (72-05-13)
1997-12-18: WARRANTY ADMIN. - ENHANCED SUBLET REPAIR POLICY (72-05-14)
1997-12-16: WARR. ADMIN - LABOR TIME GUIDE UPDATES (73-05-09)
1997-12-01: PAINT PEELING FROM MUFFLER (NEW REPAIR PAINT AVAILABLE) (33-17-01A)
1997-11-28: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (73-05-07)
1997-11-26: INFO. ON TECHNICAL ASSISTANCE CALL PREPARATION (73-01-10)
1997-11-26: SMU-SECTIONS - 8A - 200/201 REV. LOCATION FOR GROUNDS (73-81-57)
1997-11-20: CLARIFICATION OF RAIL DUST REM (A5575-A5580) (72-05-11)
1997-11-19: SMU-SEC. 8A-132-NEW DTC INFOR (TEXT & CHARTS) (73-81-44)
1997-11-19: INFO. ON SERV. AVAILABILITY OF 1-2 & 2-3 SHIFT SOLENOIDS (77-71-73)
1997-11-12: INFORMATION - PUREGUARD 2 OPERATING ALERT (73-12-13)
1997-11-10: REDUCING DISC BRAKE COME BACKS (NEW TOOL KIT & POLICY CHANGE) (23-50-05B)
1997-11-01: WARRANTY ADMIN. - LABOR OPERATION CODE Z1241 (62-05-02A)
1997-11-01: INFO. ON GOLD KEY NEW VEHICLE RECEIVING & INSPECTING PROC. (41-01-01B)
1997-10-31: CAMPAIGN: DISCHARGED BATTERY (97054)
1997-10-31: CAMPAIGN: PURGE LINE ROUTING AND RETENTION (97056)
1997-10-27: SMU-SEC. 8 -NEW INFO FOR ENTERTAINMENT SEC. (TEXT, TBL, (73-96-02)
1997-10-24: WARR. ADMIN-LTG UPDATES 1989-98 PASS. CAR & TRUCK (73-05-06)
1997-10-23: WARRANTY ADMIN: 1998 G.S.A. FUEL EXPL FUEL PRICE CHANGE (72-05-10)
1997-10-20: SMU-SEC.8A-100/101/102 REV. CHART #2 (PARK LAMPS (73-81-49)
1997-10-10: INFO. BALANCING ALUMINUM WHEELS (73-35-05)
1997-10-08: INFO. 'ELECTRICAL CENTER' DIAGNOSTIC INFORMATION (73-81-40)
1997-09-25: INFO - DIAG. HINTS FOR 'ROLLING CODE' REMOTE FUNC. (73-90-18)
1997-09-11: WARRANTY: TIRE REPLACEMENT DURING BUMPER TO BUMPER (70-05-01)
1997-08-21: WARRANTY ADMIN - GUIDELINES FOR USING E0420 WHEEL (72-05-05)
1997-08-21: WARRANTY ADMIN- GUIDELINES FOR USING I/M 240 LABOR OP (72-05-06)
1997-08-12: WARRRANTY ADMIN - LABOR TIME GUIDE UPDATES (73-05-05)