Technical Service Bulletins

• 2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
• 2008-09-05: Information on Speedometer Accuracy (08-08-49-011B)
• 2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
• 2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
• 2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
• 2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
• 2007-04-18: Special Coverage (Policy) Adjustment - Electronic Diesel-Fuel Injection Pump Failure-Repair/Replace (00064G)
• 2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
• 2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
• 2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
• 2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
• 2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
• 2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
• 2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
• 2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
• 2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
• 2004-11-18: Warranty Admin. - Warranty Return Parts (04-00-89-051)
• 2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
• 2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
• 2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
• 2003-03-19: Info - Engine Oil Quality and Viscosity (Export Only) (03-00-90-002)
• 2001-03-16: Product Safety - Evaporative Emission Canister Fuel Leakage (00031)
• 2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
• 2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
• 2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
• 1999-12-03: 98040(A) - Special Policy - Rear Side Cargo Door Does Not Stay Open (98040(A))
• 1999-10-26: Info - PCM Reprogramming (99-06-04-053)
• 1999-04-06: Labor Time Guide Updates - April 1999 (99-00-89-004)
• 1999-03-09: Labor Time Guide Updates (99-00-89-003)
• 1999-03-04: Battery Insulator Replacement (99-06-03-002)
• 1999-02-26: Essential Tool J 42000 Battery Tester (99-06-03-001)
• 1999-02-19: Warranty Parts Center/Corporate Parts Return Program (40-05-01C)
• 1999-02-16: Warranty Administration - Labor Time Updates (99-00-89-001)
• 1999-02-12: Correct Solvent for SCPI Poppet Cleaning Procedure (99-06-04-006)
• 1998-11-16: INFO - ESSENTIAL TOOL J43435 ADJUSTER LOCKNUT (83-32-10)
• 1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
• 1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
• 1998-10-30: INFO. ON REAR AXLE LUBRICANT COMPATIBILITY (86-42-04)
• 1998-10-29: INFO - TEMP. CHANGES TO TECHLINE ESI APPLICATIONS (83-01-20)
• 1998-10-20: INFO - ESSENTIAL TOOL J43485 POWER STEERING BLEEDER ADAPTER (83-32-09)
• 1998-10-08: WARRANTY ADMIN - LTG UPDATES (83-05-09)
• 1998-10-01: INFO - NEW WINDSHIELD AND STATIONATY GLASS URETHANE (83-15-16)
• 1998-10-01: INFO - REDUCED RANGE/OPERATION OF RKE (86-90-06)
• 1998-09-29: INFO ON RECOMMENDED AXLE LUBRICANT (76-02-02A)
• 1998-09-23: SPECIAL POLICY:REAR SIDE CARGO DOOR DOES NOT STAY (98040)
• 1998-09-23: SPECIAL POLICY:REAR SIDE CARGO DOOR DOES NOT STAY (98040)
• 1998-09-22: EXTENDED ENGINE CRANKING TIME DURING HOT ENGINE RESTART IN (87-65-25)
• 1998-09-18: BRAKE LEAD/FRT BRAKE WEAR (REPLACE REAR BRAKE SHOES) (86-50-20A)
• 1998-09-17: WARRANTY ADMIN. - LTG UPDATES (83-05-08)
• 1998-09-16: INFO - NEW PCM CONNECTOR SERVICE KITS (83-81-32)
• 1998-09-16: SMU - SEC. 0B - CORRECTED CRANKCASE VENTILATION SYSTEM (83-02-01)
• 1998-08-26: INFO - DIAGNOSING VARIOUS DIESEL DRIVEABILITY CONDITIONS (87-65-13)
• 1998-08-21: WARRANTY ADMIN - LTG UPDATES (83-05-07)
• 1998-08-21: INFO - TOWING (16-01-01B)
• 1998-08-20: INFO - ESSENTIAL TOOL J-43241 REMOTE KEYLESS ENTRY AND (83-90-12)
• 1998-08-14: INFO - CORRECT LABOR CODE USAGE FOR ENTERTAINMENT SYS. (84-96-01)
• 1998-08-12: WARRANTY ADMIN. - REDEFINED USE OF PARTS WARRANTY SPECIAL (80-05-03)
• 1998-08-03: SLIDING DOOR DIFFICULT TO CLOSE AT REAR OF DOOR (76-15-16)
• 1998-07-21: OIL WEEP AT GASKET BETWEEN UPPER AND LOWER INTAKE (87-61-26)
• 1998-07-17: NO START, STALL, DTC 35 (94-95 M/Y) OR P1216 (77-63-06A)
• 1998-07-17: ROUGH IDLE AFTER START WHEN VEH. HAS SAT OVERNIGHT (87-65-07A)
• 1998-07-17: RATTLING NOISE IN SWING OUT WINDOW ASSEMBLIES (86-15-16)
• 1998-07-17: INFO. ON INSTALLATION OF A 6.5L DIESEL GOODWRENCH ENGINE (87-61-28)
• 1998-07-15: WARRANTY ADMIN. - LTG UPDATES (83-05-06)
• 1998-06-11: WARRANTY ADMIN. - LTG UPDATES (83-05-05)
• 1998-06-03: INFO - NEW TOOL J-42958, REV. CHARTS AND SCHEM. FOR CRUISE (83-90-08)
• 1998-05-18: ACCESSORY DRIVE BELT NOISE DUE TO STEERING PUMP PULLEY (77-60-02)
• 1998-05-18: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-04)
• 1998-05-11: SMU - SEC. 6/6E - REV. 'NO SERIAL DATA' DIAGNOSTIC PROC. (81-65-40)
• 1998-04-24: HARSH 1-2 UPSHIFTS ALL GEARS (87-71-62)
• 1998-04-24: GENERAL MOTORS WARRANTY INQUIRY SYSTEM (82-05-05)
• 1998-04-21: WARRANTY ADMIN - REQ. FOR WHOLESALE AUTH. OR WARRANTY (82-05-02)
• 1998-04-16: WARRANTY ADMIN. - LTG UPDATES (83-05-03)
• 1998-04-02: INFO. USE OF'SURFACE CONDITIONING DISCS' (87-61-24)
• 1998-03-31: SMU - SECTION 6E - ENGINE CONTROLS - REVISED (61-65-60A)
• 1998-03-24: HARD START, NO START, DTC 13 OR P0215, SES LIGHT ON (87-63-04)
• 1998-03-17: SMU - SEC. 6/6E - ENG CONTROLS REV. ENHANCED IGN.SYS. DIAG. (81-65-36)
• 1998-03-16: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-02)
• 1998-03-16: DIESEL ENG. HESITATION, WHITE SMOKE, ROUGH IDLE, LACK OF PWR (87-63-03)
• 1998-03-10: EXCESSIVE TICKING NOISE IN AMBIENT TEMP. (DIAG REPL. (87-63-02)
• 1998-03-10: INFO. NEW TOOL J-41450-B RELEASED FOR CS GEN DIAG. (83-64-09)
• 1998-03-02: INFO - FUEL LEVEL SENSOR REPLACEMENT PROC (83-83-07)
• 1998-03-01: INFO. - INJECTION PUMP EXCHANGE PROGRAM - GM CANADA (75-63-03A)
• 1998-02-24: INFO - PREMATURE MAIN BEARING FAILURE (87-61-22)
• 1998-02-20: WARRANTY ADMIN - LABOR TIME GUIDE UPDATES (83-05-01)
• 1998-02-13: HARDSTART & STUMBLE, WITH MIL ON & POSS. HISTORY DTC'S (77-65-27)
• 1998-02-13: INFO. ON VIN PLATE REPLACEMENT (83-01-14)
• 1998-01-21: SMU - SEC. 6 - ENG. CONTROLS REVISED TDC OFFSET ADJ. (71-65-67)
• 1998-01-14: INFO. - DIAG PROC. WHEN A/C DIAG INFO LEAK (73-12-12A)
• 1998-01-12: INFO. FRONT. SUPP. INFLAT. RESTRAINTS (SIR) ON-OFF SWITCH (73-90-23)
• 1998-01-07: FUEL LEAK FROM VAPOR CANISTER WHEN PARKED (76-63-09)
• 1997-12-18: WARRANTY ADMIN. - REPAIR/ REPLACE POLICIES & PROC. (72-05-13)
• 1997-12-18: WARRANTY ADMIN. - ENHANCED SUBLET REPAIR POLICY (72-05-14)
• 1997-12-16: WARR. ADMIN - LABOR TIME GUIDE UPDATES (73-05-09)
• 1997-12-02: LOSS OF 4TH GEAR, SLIPPING IN 4TH GEAR, BUSY 3-4 (77-71-77)
• 1997-11-28: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (73-05-07)
• 1997-11-26: INFO. ON TECHNICAL ASSISTANCE CALL PREPARATION (73-01-10)
• 1997-11-20: CLARIFICATION OF RAIL DUST REM (A5575-A5580) (72-05-11)
• 1997-11-18: INFO. ON INSTRUMENT CLUSTER IDENTIFICATION (78-83-03A)
• 1997-11-17: INOPERATIVE POWER DOOR LOCKS LOCKS WILL FUNCTION MANUALLY (63-10-41B)
• 1997-11-12: INFORMATION - PUREGUARD 2 OPERATING ALERT (73-12-13)
• 1997-11-01: WARRANTY ADMIN. - LABOR OPERATION CODE Z1241 (62-05-02A)
• 1997-10-24: WARR. ADMIN-LTG UPDATES 1989-98 PASS. CAR & TRUCK (73-05-06)
• 1997-10-24: LOAD EXHAUST DUE TO EXHAUST LEAK (77-61-20)
• 1997-10-22: ENG. TICK/KNOCK/RATTLE NOISE (NORMAL CONDITION (77-61-21)
• 1997-10-17: INFO. ON COOLER FLUSH ADAPTER TOOLS FOR HYDRA-MATIC (77-71-68)
• 1997-10-01: SMU-SECT. 6-ENG. MECH CYLINDER HEAD INSTALLATION (77-61-14)
• 1997-09-29: SMU-SECTION 10A2-SEATS -REAR BODY SIDE PANEL BRACE (76-16-15A)
• 1997-09-25: BODY LEAN WHEN TURNING (REPLACE SHOCK ABSORBERS) (66-30-02)
• 1997-09-25: INFO. NEW TUMBLERS FOR CYLINDERS RECODING REV. REPAIR (73-01-09)
• 1997-09-25: SMU-SEC.6-ENG. MECHANICAL CRANKSHAFT & BEARINGS (77-61-15)
• 1997-09-25: INFO - DIAG. HINTS FOR 'ROLLING CODE' REMOTE FUNC. (73-90-18)
• 1997-09-11: WARRANTY: TIRE REPLACEMENT DURING BUMPER TO BUMPER (70-05-01)
• 1997-09-01: ENGINE NOISE (INSTALL VALVE STEM OIL SEAL) (67-61-14B)
• 1997-09-01: INFO. ON ALUMINUM HEATER CORE AND/OR RADIATOR REPL. (73-62-13A)
• 1997-08-30: CAMPAIGN: INCORRECT LINEAR EXHAUST GAS (97024)
• 1997-08-21: WARRANTY ADMIN - GUIDELINES FOR USING E0420 WHEEL (72-05-05)
• 1997-08-21: WARRANTY ADMIN- GUIDELINES FOR USING I/M 240 LABOR OP (72-05-06)
• 1997-08-15: INFO ON DIAG OF TRANS NOISE,DELAYED, ENGAGED (77-71-67)
• 1997-08-14: SMU-SEC. 6E ENG CONT REV. TO ADD DTC P1643 (71-65-50)
• 1997-08-12: WARRRANTY ADMIN - LABOR TIME GUIDE UPDATES (73-05-05)
• 1997-07-31: SMU-SECT. 6E-ENG. CONT REV. DIAG TROUBLE CODE (71-65-36)
• 1997-07-21: WATER CONTAMINATION OF ENGINE OIL (76-60-01)
• 1997-07-01: SMU-SECTION 10A2-SEATS REAR SEAT TRACK REINF. (71-15-12)
• 1997-07-01: SMU-SECTION 10A2-SEATS REAR SEAT TRACK REINF. (76-15-12)
• 1997-06-13: UNDESIRED TRANS.DOWN SHIFTING BET. 3RD & 2ND GEAR (77-71-63)
• 1997-06-01: INFO. ON NEW AFTERMARKET PAINT SPECIFICATION (GM4901M) (63-17-07B)
• 1997-06-01: INFO. ON 1997 TRUCKS WITH 6.5L DIESEL ENGINE PRODUCTS UPDATES (67-61-20A)
• 1997-05-29: INFO ON AUTO TRANS OIL COOLER FLUSHING &FLOW CHECK PROC. (77-71-59)
• 1997-05-12: INFORMATION -TWO PART URETHANE ADHESIVE (73-10-54)
• 1997-05-12: FRONT DOOR ROLLUP GLASS SCRATCHED (RESEAT SEALING (76-15-11)
• 1997-05-01: SMU - SECTION 6E - REVISED ENHANCED IGNITION SYSTEM (71-65-40)
• 1997-04-23: TRUCK SETS LOW IN REAR (INSTALL REAR SUSPENSION) (76-34-02)
• 1997-04-18: INFORMATION DISTRIBUTOR SERVICE KITS (77-64-04)
• 1997-04-17: INFORMATION: FUEL GAUGE RESP. SLOWLY AFTER FUELING (73-83-15)
• 1997-04-17: INFO. ON A/C TOOL AND EQUIPMENT MAINTENANCE (63-12-08A)
• 1997-04-04: SMU - SECTION 8E/8E1 REVISED CLEANING PROCDURE (73-82-03)
• 1997-04-01: CAMPAIGN: BRAKE PIPE CONTACTED BY ENGINE OIL (97012)
• 1997-04-01: 1997 BILL 101 FRENCH LABEL INSTALLATION INSTRUCTIONS (35-01-04D)
• 1997-03-26: INFO. - REVISED SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) (73-01-07)
• 1997-03-20: WARRANTY ADMINISTRATION - LABOR TIME GUIDE UPDATES (73-05-03)
• 1997-03-06: INFO. ON 1997 TRUCKS WITH 6.5L DIESEL ENGINE (77-61-08)
• 1997-03-06: INFORMATION ON REPROGRAMMING CAPABILITY (73-65-13)
• 1997-03-03: MALFUNCTION INDICATOR LIGHT (MIL) ON, POOR DRIVEABILITY (76-65-04)
• 1997-03-03: CHUGGLE / SURGE ON TCC APPLY NO DTC'S - REFLASH PCM (77-71-53)
• 1997-03-01: 'CLN' INDICATOR APPEARS ON RADIO DISPLAY (54-90-01A)
• 1997-02-20: WARRANTY ADMINISTRATION LABOR TIME GUIDE UPDATES (73-05-02)
• 1997-02-07: SERVICE ISSUES FOR VEHICLES WITH R12 OR R134A A/C SYSTEMS (73-12-04)
• 1997-02-05: INFO. ON PICTORIAL OF OXYGEN SENSOR DESIGNATIONS (67-65-40)
• 1997-01-31: INFO. NEW BODY SEALER TAPE FOR COLLISION REPAIRS (73-10-49)
• 1997-01-27: FRONT DOOR & WINDSHIELD MOLDING WINDNOISE (66-15-11)
• 1997-01-24: WARRANTY ADMINISTRATION - LABOR TIME GUIDE UPDATES (73-05-01)
• 1997-01-17: SMU - SECTION 6E - ENGINE CONTROLS - REVISED (61-63-16)
• 1997-01-13: INFO. ON COMPACT DISC PLAYERS- PROCEDURES (64-96-01)
• 1997-01-07: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (63-05-07)
• 1997-01-07: SMU - SECTION 10-A - TOP TETHER ANCHOR (66-16-07)
• 1997-01-01: INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) WITH DTCS (67-65-39)
• 1996-12-03: WARRANTY ADMIN. - GM CERTIFIED USED VEHICLE WARRANTY REPAIRS (60-05-03)
• 1996-11-25: SMU - SECTION 6E - ENGINE CONTROLS - CLEAR DTC'S (61-65-59)
• 1996-11-21: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (63-05-06)
• 1996-11-15: INFO. REFERENCE CHART FOR A/C COMPRESSOR SEAL WASHERS (63-12-15)
• 1996-11-01: TRANS. PRODUCT UPDATES (NEW SHIFT SOLENOIDS) (37-71-48A)
• 1996-10-28: WARRANTY ADMIN. - GM TIRE WARRANTY POLICIES (60-05-02)
• 1996-10-25: INFORMATION ON 1997 4L80E TRANSMISSION PRODUCT UPDATES (67-71-57)
• 1996-10-22: WARRANTY ADMINISTRATION - LABOR TIME GUIDE UPDATES (63-05-05)
• 1996-10-15: INFO. ON THE GENERAL MOTORS KEY CODE VOICE RESPONSE SYSTEM (61-01-11)
• 1996-10-10: WARRANTY ADMIN. - SUBMISSION OF ALL OBDII P - CODES (67-05-02)
• 1996-10-02: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES 1989 -1997 (63-05-04)
• 1996-10-01: DRIVELINE CLUNK (56-44-01A)
• 1996-10-01: PROCEDURE TO HANDLE CUSTOMER RADIO CONCERNS (68-96-01A)
• 1996-09-30: EXCHANGE PROGRAM - KELSEY HAYES EBC - 310 & 410 (ABS) (66-50-14)
• 1996-09-01: SIR MODULE SHIPPING/RETURN PROCEDURES (31-90-04A)
• 1996-09-01: ACDELCO SERVICE CENTER LOC. FOR ODOMETER/SPEEDOMETER (66-83-04A)
• 1996-08-28: INFORMATION ON NEW PRODUCT INFORMATION (67-71-51)
• 1996-08-14: WARRANTY ADMIN. - LABOR TIME GUIDE ' REQUEST FOR REVIEW ' (63-05-03)
• 1996-06-28: SMU - SECTION 7A - AUTOMATIC TRANSMISSION / TRANSAXLE REV. (67-71-49)