Technical Service Bulletins

2008-09-29: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement (02-07-30-029L)
2008-09-29: Eliminating Unwanted Odors in Vehicles (00-00-89-027E)
2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-29: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process -For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB,Audio, Display, Map Concerns (08-08-44-010D)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-25: Updated Warranty and Goodwill Exchange Program for Electronic Products (08-08-44-029)
2008-09-23: Customer Satisfaction - OnStar System Inoperative-Replace OnStar Module (08259)
2008-09-22: Electronic Exchange Program Changes (03-00-89-013D)
2008-09-19: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords blue button communication message no noconnect operation (PIC4600A)
2008-09-18: DVD Navigation Update Program, AVN Software Update Discs and Ordering Information (06-08-44-012C)
2008-09-17: GM Tire Warranty Program Claims Submission Changes (U.S. Only) (08-03-10-012)
2008-09-15: Options Not Available Message Displayed On The DIC - keywords 1st 2nd 3rd 4th fob key personalization (PIC4095B)
2008-09-15: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including the Chevy Bowtie (06-08-111-004A)
2008-09-12: Snap Clunk Noise From Front Or Rear Of Vehicle - keywords click link noise snap stabilizer stable suspension (PIC4475B)
2008-09-12: Pop or Creak Noise From Removable Roof New Style Latches - keywords apillar cover creak guide hard latch left lift panel pillar pin plastic plate pop popping rattle removable right roller rub shield (PIC4960A)
2008-09-11: Steering Wheel ON/OFF And Volume Controls Inoperative At Start Up - keywords backlight backlighting bus button communication control data delay ignition inop LED light navigation off on operation (PIC4969)
2008-09-11: Clutch Hydraulic System - New Service/Owner Maintenance Information (07-07-31-001A)
2008-09-11: Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as Upsized to Original Equipment (05-03-10-005D)
2008-09-08: Loss of High Speed GMLAN Communications, Intermittent No Crank, IPC Gauge Fluctuation, Intermittent Door Lock Cycling, Transmission May Not Shift, DTCs U0073, U0100, U0101, U0102, U0121, U0140 Set (08-07-30-021B)
2008-09-05: Pop Or Creak Noise From Removeable Roof New Style Latches - keywords apillar cover guide hard latch lift panel pillar pin plastic plate pop popping rattle right roller rub shield snap squeak striker (PIC4960)
2008-09-05: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses (02-08-42-001C)
2008-09-05: Information on Speedometer Accuracy (08-08-49-011B)
2008-09-04: Rattle Noise At Idle From Front Of Transmission Area - keywords bearing driveshaft prop propshaft shaft torque tube (PIP4466)
2008-09-04: 5.3L LC9, LS4, L33, LH6, LM4, 5.7L LS1, LS6, 6.0L LS2, L76 6.2L L92, 7.0L LS7 - Engine Oil Leak at Rear Cover Assembly Area (Engine Block Porosity RTV Repair Procedure) (05-06-01-034F)
2008-09-04: Various Heads Up Display (HUD) Conditions - keywords appearance display IPC windshield (PIC3379B)
2008-09-02: HIGH SPEED LAN Diagnostics / Remembering Ohms Law (PIC4957)
2008-08-29: Car and Truck Fix It Right the First Time Issues (08-00-89-029A)
2008-08-29: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. and Canada Only) (07-03-10-016C)
2008-08-28: GM Training - September 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-10-89-032)
2008-08-28: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) (08-08-44-028)
2008-08-27: New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-00-89-014E)
2008-08-26: Discontinuation of Printed GM VIN Cards (08-00-89-031)
2008-08-26: Identifying Aftermarket Engine and Transmission Calibrations Gas Powered Engines Only and Automatic Transmissions (08-06-04-033B)
2008-08-26: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs) (08-08-44-015A)
2008-08-26: SES Light and DTC P0230 (PIP4462)
2008-08-25: Manual Transmission Disassemble - 5th Gear Damage During Removal (08-07-29-003)
2008-08-25: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006E)
2008-08-25: Rear Tonneau Contacts 5th Bow Or Drops Mid-Cycle - keywords b3666 convertible folding inoperative power rear roof top (PIC3650E)
2008-08-25: Snap, Pop or Rattle Noise from Lift Off Roof Panel While Driving (Replace Front Lift Off Roof Panel Handles and Lube) (08-08-67-013A)
2008-08-22: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process (For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB, Audio, Display, Map, Noise) (08-08-44-010B)
2008-08-22: Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns (08-06-03-009)
2008-08-21: Information on Automatic Transmission Service Fast Learn Adapts (SFL) Characteristics (08-07-30-039)
2008-08-21: Diagnostic Information for MIL Illuminated with DTC P1825, P182E or P1915 Found Current or as History Code in TCM, No PRNDL Display, Potential No Engine Crank (08-07-30-020A)
2008-08-20: Flare And Or Harsh 2-3 Shifts - keywords bump delay second slip third (PIP4395B)
2008-08-15: Information on XM NAV Traffic Coverage Areas (08-08-126-001)
2008-08-15: PQC Part Restriction - Corvette ZR1 Generator P/N 25888947 - keywords alternator charging LS9 order parts volt (PIC4948)
2008-08-14: Information on Aftermarket Device Interference with OnStar Diagnostic Services (08-08-46-004)
2008-08-14: Diagnostic information for Intermittent Restraints, Air Bag (SIR) Indicator/Lamp On with DTC(s) B0012, B0013, B0014, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 or B0044 Set (08-09-41-002A)
2008-08-14: Driver, Passenger Front Door Speaker Rattle, Buzz, Squeak (Apply Felt Tape to Front Door Trim Retainers) (08-08-64-012)
2008-08-13: Service Guide, Unique Characteristics, Dealer Service Information for 2009 Chevrolet Corvette ZR1 (08-00-89-030)
2008-08-13: Rattle/Tappign Type Noise Heard Under Hood (Diagnose and Replace Engine Oil Tank Transfer Tube Seal (O-Ring)) (08-06-01-019)
2008-08-13: Malfunction Indicator Lamp (MIL) - Check Engine Light On, DTCs P0171 and/or P0174 Set (Perform Repair As Outlined) (08-06-04-040)
2008-08-11: Informaiton on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
2008-08-08: 2009 Corvette LS7 and LS9 Engine Replacement Information - block coolant engine exchange head knack leak lifter noise oil piston push pqc (PIP4132C)
2008-08-08: Information on Water or Ethylene Glycol in Transmission Oil (08-07-30-035)
2008-08-07: SES Light And/Or Oil In Air Intake System - Inspect Air Intake Hydrocarbon Absorber (PIP3786B)
2008-08-06: Inability To Program Tire Pressure Sensors - keywords inflation inop inoperative learn low message monitor no receiver relearn RFA RIM service signal system TIMS TPM transmitter wheel (PIC4946)
2008-08-06: Slight Pull Left or Right Tire Wander - keywords air alignment brake pressure ride steering suspension (PIC3144A)
2008-08-06: GM Accessories VPO/LPO Programs - Reimbursement for Dealer Labor (08-00-89-005B)
2008-08-06: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022E)
2008-08-05: Question Regarding Installation Of Dealer Installed Accessories (PIT3099E)
2008-08-01: OnStar Turn By Turn / TBT Feature Inoperative - keywords blue button calibration call cellular communication data digital navigation operation performance (PIC4801A)
2008-08-01: Unable To Program Replacement VCIM - keywords module ogen8 onstar programming service sps tech2 techline tis2web UE1 vs3bgen7 (PIC4944)
2008-07-31: Flare And/Or Harsh 2-3 Shifts - keywords bump delay second slip third (PIP4395A)
2008-07-31: GM Training - August 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-028)
2008-07-25: Additional Wheel Speed Sensor Diagnostics - keywords ABS brake C0035 C0040 C0045 C0050 C0245 DTC lamp light message MIL P0609 service system unwant (PIT4683)
2008-07-25: Replacement of Incorrect Wheel Center Caps Installed on Some 2009 Chevrolet Corvette Vehicles (08-03-10-010)
2008-07-25: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 (05-03-08-002B)
2008-07-23: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information led no operation red (PIC3597F)
2008-07-23: OnStar Power Consumption - keywords battery digital discharge drain draw parasitic VCIM (PIC4935)
2008-07-21: GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) - (This in not a Saturn STS Requirement) (08-00-89-027)
2008-07-21: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output (02-06-03-008D)
2008-07-18: Audible Click Noise When turning The Steering Wheel Left Or Right - keywords angle column left position right sensor stability steering SWPS wheel (PIC4930)
2008-07-17: GM Training - July 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-026)
2008-06-27: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) (07-00-89-047B)
2008-06-27: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009B)
2008-06-27: Voice Recognition System Will Not Recognize Bluetooth Command (08-08-44-024)
2008-06-27: Service Stability Lamp DTC C0131 - keywords abs brake light message (PIT4162E)
2008-06-24: ABS Traction Control And/Or Stabilitrak Lights On With No DTCs - keywords brake C0035 C0040 C0045 C0050 C0110 C0131 C0161 C0186 C0196 C0245 C0252 C0299 C0450 C0455 C0550 C0710 control EBCM IP IPC pump (PIT4665)
2008-06-24: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047H)
2008-06-24: GM Goodwrench Limited Lifetime Service Guarantee (03-00-89-003A)
2008-06-23: Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011)
2008-06-23: Engine Exchange Program for 2009 Model Year 6.2L Supercharged V8 Engine (RPO LS9) (08-06-01-014)
2008-06-20: Information on Use of Customer Concern Verification Sheets, Comeback Prevention, GM Technical Assistance Information Form (TAC), Strategy Based Diagnostics (SBD), Intermittent Concerns, Diagnostics (01-00-89-010H)
2008-06-18: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement (08-08-44-023)
2008-06-18: TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004A)
2008-06-18: Enhancing Field Product Reports with Digital Pictures (07-00-89-036A)
2008-06-18: OnStar Voice Recognition Operation Issues - keywords information intermittent microphone performance voice (PIC3011E)
2008-06-18: Unable To Connect To OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication droppedcall failedtovoice information intermittent OPC operation no noconnect performance region (PIC4310C)
2008-06-17: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy (05-00-89-072B)
2008-06-17: Headliner Wear (Replace Bolts and Remove Sharp Edge) (08-08-110-001A)
2008-06-06: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002E)
2008-06-05: OnStar Deactivated Returned To Stock New Vehicle Inventory - keywords activation button deactivated disabled inventory keypress letter (PIC4889)
2008-06-04: Removable Top Squeaks When Stowed Away (Install Velcro) (06-08-67-002A)
2008-05-30: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. Only) (07-03-10-016A)
2008-05-30: Identifying Aftermarket Engine Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L 6.2L 7.0L, 7.4L, 8.1L Gas (08-06-04-033)
2008-05-30: Intermittent, Current or History DTC B2476 in Onstar GEN 6 or 7 VCIM - keywords blue button call communication data digital information keypad led OPC operation red (PIC4574B)
2008-05-29: Information on Visual Brake Rotor Surface Cracking (05-05-23-007A)
2008-05-29: Tapping or Scraping Noise From Rear Wheel Area (Replace Wheel Drive Shaft Nut) (07-04-95-001A)
2008-05-29: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory (08-06-03-005)
2008-05-22: IPC Odometer Programming Method Quick Reference Guide (07-08-49-020B)
2008-05-22: Information on Slight Vehicle Movement in Park at Start Up After Cold Soak (08-07-30-026)
2008-05-20: Information on Special Service Tool J44395 - Transmission Holding Fixture Modification (08-07-29-002)
2008-05-19: EI08183 - 6L50, 6L80, 6L90 RWD Leak From Transmission Oil Pan or Oil Pan Gasket (Engineering Information) (08-07-30-024)
2008-05-16: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
2008-05-12: Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
2008-05-12: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
2008-05-08: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036E)
2008-05-07: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Intrument Panel Clusters (IPC) (08-08-44-015)
2008-05-06: Disc Brake Warranty Service and Procedures (00-05-22-002K)
2008-05-02: Manual Transmission Operating Characteristics (03-07-29-004E)
2008-05-02: Required Return Criteria of Complete Electrical Centers (EC) and Body Control Modules (IBCMs) with Integrated Electrical Centers to Warranty Parts Center (WPC) (05-08-45-002D)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005)
2008-05-01: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) (08-03-10-006)
2008-05-01: Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
2008-04-30: ACDelco Replacement Battery Warranty Procedures (03-06-03-003B)
2008-04-29: Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
2008-04-28: Information on Paint Stain Under Protective Shipping Film (05-08-51-001C)
2008-04-18: Information for Dealers on How to Submit a Field Product Report (02-00-89-002G)
2008-04-18: Onstar TBT (Turn by Turn) and Digit Dispays Location keywords call cellular comunication data digit digital hud information operation radio unable turn use (PIC4510A)
2008-04-17: Being Prepared for TAC, Caller Preparedness - Contacting U.S. Technical Assistance (TAC) and Use of Strategy Based Diagnostics (08-00-89-014)
2008-04-17: Electronic Exchange Program Goodwill Procedures (05-00-89-045A)
2008-04-17: Key Code Information (99-00-89-011C)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-16: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines (05-08-44-024A)
2008-04-14: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information LED no operation red (PIC3597E)
2008-04-14: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts (00-06-01-012C)
2008-04-10: Handsfree Calling Inop With Demo Message On OnStar Keypress - keywords 05-08-46-006N blue button communication digital disabled message no OPC operation vs3bgen6 vs3bgen7 (PIC4564A)
2008-04-08: OnStar RPO Code Questions - keywords data digital information no option print (PIC4483A)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-01: Warranty Claims Submission - Importance of GM Part Numbers and Parts with Date Codes (06-00-89-054B)
2008-03-27: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008)
2008-03-25: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories (08-03-10-004)
2008-03-14: Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002A)
2008-03-12: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation (08-08-51-002)
2008-03-12: Vehicle Battery Maintenance While in Dealer Stock (05-06-03-007A)
2008-02-27: Noise During The 1-2 Shift When Cold - keywords first grate grind second (PIP4357)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-01-25: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006B)
2008-01-17: Engineering Information (EI) Process (04-00-89-053B)
2008-01-15: Clutch Pedal Sticks To The Floor And Will Not Return - keywords inoperative low shift (PIP4269A)
2008-01-10: Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029D)