Technical Service Bulletins

2008-09-29: Slip Condition In 2nd 3rd Or 4th - Damaged 2-4 Band Or 3-4 Clutch - keywords 4L60E 4L65E 4L70E automatic bind body busy chatter forth second shift shudder third valve (PIP3136M)
2008-09-29: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement (02-07-30-029L)
2008-09-29: Eliminating Unwanted Odors in Vehicles (00-00-89-027E)
2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-29: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process -For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB,Audio, Display, Map Concerns (08-08-44-010D)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-25: Updated Warranty and Goodwill Exchange Program for Electronic Products (08-08-44-029)
2008-09-22: Electronic Exchange Program Changes (03-00-89-013D)
2008-09-22: Rattle Type Noise Coming From Front of Vehicle (Replace Power Steering Cooler Line Retainers) (08-02-32-006)
2008-09-19: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords blue button communication message no noconnect operation (PIC4600A)
2008-09-18: Information on OnStar Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
2008-09-18: DVD Navigation Update Program, AVN Software Update Discs and Ordering Information (06-08-44-012C)
2008-09-17: GM Tire Warranty Program Claims Submission Changes (U.S. Only) (08-03-10-012)
2008-09-17: Fuel Injector Replacement Information - Inspect Fuel Injector Inlet Filter Screen For Rust - keywords P0171 P0174 P0300 P0301 P0302 P0304 P0305 P0306 P0307 P0308 (PIP3280D)
2008-09-16: Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017A)
2008-09-15: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including the Chevy Bowtie (06-08-111-004A)
2008-09-11: Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as Upsized to Original Equipment (05-03-10-005D)
2008-09-05: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses (02-08-42-001C)
2008-09-03: Catalytic Converter Break-In Information To Prevent DTCs P0420 And/Or P0430 - keywords 4.8 5.3 6.0 6.2 break low L59 L76 L92 L9H LC9 LFA LH6 LH8 LMF LMG LM7 LQ4 LQ9 LR4 LY2 LY5 LY6 P0300 P0301 (PIP3119G)
2008-08-29: Car and Truck Fix It Right the First Time Issues (08-00-89-029A)
2008-08-29: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. and Canada Only) (07-03-10-016C)
2008-08-28: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) (08-08-44-028)
2008-08-27: New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-00-89-014E)
2008-08-26: Eaton Locking Differential Chatter Shudder Noise on Turns - keywords bind grab grind (PIP4054C)
2008-08-26: Identifying Aftermarket Engine and Transmission Calibrations Gas Powered Engines Only and Automatic Transmissions (08-06-04-033B)
2008-08-26: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs) (08-08-44-015A)
2008-08-26: Damaged Turbo Chargers When Returned to the WPC - keywords diesel engine lbz leak lly lmm noise oil p003a p0234 p0299 p2563 p2564 p2565 return turbocharger (PIP3224B)
2008-08-26: SES Light and DTC P0230 (PIP4462)
2008-08-25: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006E)
2008-08-22: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process (For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB, Audio, Display, Map, Noise) (08-08-44-010B)
2008-08-22: Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns (08-06-03-009)
2008-08-21: Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up (06-08-47-001E)
2008-08-18: Information on Engine Ticking Noise (02-06-01-022H)
2008-08-15: Supplement To EGR Cleaning Bulletin 06-06-04-066C - keywords 6.6 6.6L black boost calibrate calibration control controller diesel DTC ECM engine fuel idle injector injection LBZ LLY MIL motor P0403 (PIP4456)
2008-08-14: Information on Aftermarket Device Interference with OnStar Diagnostic Services (08-08-46-004)
2008-08-11: Informaiton on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
2008-08-08: Information on Water or Ethylene Glycol in Transmission Oil (08-07-30-035)
2008-08-06: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022E)
2008-08-05: Question Regarding Installation Of Dealer Installed Accessories (PIT3099E)
2008-08-01: OnStar Turn By Turn / TBT Feature Inoperative - keywords blue button calibration call cellular communication data digital navigation operation performance (PIC4801A)
2008-08-01: Continuous OnStar Progression Tones AFTER Call End Attempt Is Made - keywords battery blue button DTC emerging flashes inoperative issue led mute no noconnect radio red (PIC4500C)
2008-07-31: LBZ, LLY Engine MIL/SES Light On With DTC P0403 Set (Check/Reprogram ECM and Perform EGR Valve Motor Cleaning Procedure) (06-06-04-066C)
2008-07-25: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 (05-03-08-002B)
2008-07-23: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information led no operation red (PIC3597F)
2008-07-23: OnStar Power Consumption - keywords battery digital discharge drain draw parasitic VCIM (PIC4935)
2008-07-21: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output (02-06-03-008D)
2008-06-27: Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs. Non-Overpower Engine Non-Function of Pistons, Cylinders and Valvetrain (06-06-01-007B)
2008-06-27: Information on Identifying Non-GM Calibration Usages for LMM Duramax Diesel Engine (08-06-04-006B)
2008-06-27: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) (07-00-89-047B)
2008-06-27: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009B)
2008-06-24: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047H)
2008-06-24: GM Goodwrench Limited Lifetime Service Guarantee (03-00-89-003A)
2008-06-23: Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011)
2008-06-20: Information on Use of Customer Concern Verification Sheets, Comeback Prevention, GM Technical Assistance Information Form (TAC), Strategy Based Diagnostics (SBD), Intermittent Concerns, Diagnostics (01-00-89-010H)
2008-06-18: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement (08-08-44-023)
2008-06-18: Enhancing Field Product Reports with Digital Pictures (07-00-89-036A)
2008-06-18: OnStar Voice Recognition Operation Issues - keywords information intermittent microphone performance voice (PIC3011E)
2008-06-18: Unable To Connect To OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication droppedcall failedtovoice information intermittent OPC operation no noconnect performance region (PIC4310C)
2008-06-17: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy (05-00-89-072B)
2008-06-16: Questions Regarding Installation Of Dealer Installed Accessories (PIT3099D)
2008-06-11: Unwanted Repeated Calls to OnStar / Replace VCIM - keywords call letter mail phantomcall phone repeat (PIC4893)
2008-06-11: GM Training:June 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-022)
2008-06-06: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002E)
2008-06-05: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors (07-08-64-022A)
2008-06-05: OnStar Deactivated Returned To Stock New Vehicle Inventory - keywords activation button deactivated disabled inventory keypress letter (PIC4889)
2008-06-04: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
2008-06-03: Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
2008-06-03: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008B)
2008-05-30: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. Only) (07-03-10-016A)
2008-05-30: Identifying Aftermarket Engine Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L 6.2L 7.0L, 7.4L, 8.1L Gas (08-06-04-033)
2008-05-30: Intermittent, Current or History DTC B2476 in Onstar GEN 6 or 7 VCIM - keywords blue button call communication data digital information keypad led OPC operation red (PIC4574B)
2008-05-29: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory (08-06-03-005)
2008-05-28: Gen III Or Gen IV V-8 Engine Misfire - keywords P0300 arm cam camshaft lifter wear worn engine L33 L59 L76 L92 LC9 LFA LH6 LH8 LM7 LMG LR4 LS2 LS4 LQ4 LQ9 LY2 LY5 LY6 miss rocker roller rough valve (PIP4138E)
2008-05-22: GEN III or IV V-8 Engine Misfire - keywords p0300 arm cam camshaft lifter wear worn engine l33 l59 l76 l93 lc9 lfa lh6 lm7 lmg lr4 ls3 ls4 lq4 lq9 ly2 ly5 miss rocker roller rough valve (PIP4138D)
2008-05-22: Information on Diesel Fuel Requirements - Service Engine Soon (SES) Indicator ON, Loss of Power, Filter Life Percentage Low as a Result of Fuel Filter Plugged/Incorrect Fuel Grade (08-06-04-032)
2008-05-22: IPC Odometer Programming Method Quick Reference Guide (07-08-49-020B)
2008-05-22: Information on Slight Vehicle Movement in Park at Start Up After Cold Soak (08-07-30-026)
2008-05-16: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
2008-05-12: Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
2008-05-12: Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036G)
2008-05-12: GM Training: May 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-019)
2008-05-12: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
2008-05-08: Growl Hiss Or Whine From The Rear Differential / Axle - keywords bearing gear moan pinion ring (PIP4083D)
2008-05-08: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036E)
2008-05-07: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Intrument Panel Clusters (IPC) (08-08-44-015)
2008-05-06: Disc Brake Warranty Service and Procedures (00-05-22-002K)
2008-05-06: LBZ, LLY, MIL/SES Light On, DTC P0087 - Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components) (08-06-04-029)
2008-05-05: Engagement Time of Electronically Controlled Transmissions in General Motors Vehicles (Garage Shifts, Park to Reverse, Neutral to Drive, Neutral to Reverse, Park to Drive, Delayed Engagement) (03-07-30-007E)
2008-05-02: Manual Transmission Operating Characteristics (03-07-29-004E)
2008-05-02: Required Return Criteria of Complete Electrical Centers (EC) and Body Control Modules (IBCMs) with Integrated Electrical Centers to Warranty Parts Center (WPC) (05-08-45-002D)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-02: OnStar Generation 5 or 6 (DIgital) System Inoperative/Has No Power, LED Light Not On (Remove/Reinstall OnStar Fuse and Replace VCIM or Follow SI Diagnostics) (05-08-46-001D)
2008-05-02: Parts Restriction on Ordering OnStar Generation 6 and 7 Vehicle Communication Interface Modules (VCIM) (03-08-46-004D)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005)
2008-05-01: Control Module Ignition On Timer Performance DTC P2610 - keywords 6.6 cal calibration ECM engine LBZ LLY MIL replace replacement (PIP4403)
2008-05-01: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) (08-03-10-006)
2008-05-01: LBZ, LLY, Engine with Rough Idle, Poor Performance, Black, White Exhaust Smoke, MIL/SES Light On, DTCs Set (Reprogram ECM and Replace EGR Motor or EGR Valve, If Necessary) (06-06-04-066B)
2008-05-01: Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
2008-04-30: Diagnostic Trouble Codes (DTCs) Required on Repair Orders (06-00-89-050B)
2008-04-30: ACDelco Replacement Battery Warranty Procedures (03-06-03-003B)
2008-04-29: Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
2008-04-28: Information on Paint Stain Under Protective Shipping Film (05-08-51-001C)
2008-04-24: Parts Restriction on Ordering XM Digital Radio Receiver (03-08-44-022E)
2008-04-23: Product Safety - Safety Belt Buckle Inoperative (05113C)
2008-04-22: Information on Removing Protective Film Bumper Covers Upon Delivery of Vehicle (PDI) (08-08-51-003)
2008-04-21: GM Training: STS Report Change Effective April 19th 2008 (U.S. Dealers) (08-00-89-016)
2008-04-21: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-015)
2008-04-18: Eaton Locking Differential Chatter Shudder NoEaton Locking Differential Chatter Shudder Noise On Turns - keywords bind grab grind (PIP4054B)
2008-04-18: Information for Dealers on How to Submit a Field Product Report (02-00-89-002G)
2008-04-17: GEN III Or GEN IV Engine Misfire - keywords P0300 arm cam camshaft lifter wear worn engine L33 L59 L76 LC9 LH6 LM7 LMG LR4 LS2 LS4 LQ4 LQ9 LY5 LY6 miss rocker roller rough valve (PIP4138C)
2008-04-17: Being Prepared for TAC, Caller Preparedness - Contacting U.S. Technical Assistance (TAC) and Use of Strategy Based Diagnostics (08-00-89-014)
2008-04-17: Electronic Exchange Program Goodwill Procedures (05-00-89-045A)
2008-04-17: Key Code Information (99-00-89-011C)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-17: Turn By Turn Will Not Cancel Route - keywords cancel navigation onstar voice rec TBT (PIC4596A)
2008-04-16: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines (05-08-44-024A)
2008-04-15: Diagnostic Information on MH1, MN8, MT1, M15 Transmission Slips, Will Not Shift or May Overheat, SES/MILMay Be Illuminated, DTCs P0218, P0894 Set (08-07-30-016A)
2008-04-14: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information LED no operation red (PIC3597E)
2008-04-14: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts (00-06-01-012C)
2008-04-14: Unnecessary Leaf Spring Clip Replacement (04-03-08-011D)
2008-04-10: Continuous OnStar Progression Tones AFTER Call End Attempt Is Made - keywords battery blue button DTC emerging flashes inoperative issue LED mute no noconnect radio red (PIC4500B)
2008-04-10: Midtronics Code Generated by J 42000 or J 42000EU Battery Tester Required for Claim Processing On Labor Operation N0110 (03-06-03-004C)
2008-04-10: Handsfree Calling Inop With Demo Message On OnStar Keypress - keywords 05-08-46-006N blue button communication digital disabled message no OPC operation vs3bgen6 vs3bgen7 (PIC4564A)
2008-04-09: Fuel Filter Contacts Fuel Tank, Poor Clearance Between Fuel Filter and Fuel Tank (Reposition Fuel Filter Mounting Bracket) (08-06-04-018A)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-02: Information on 6.6L LBZ, LB7, LLY Duramax Diesel Engine Cylinder Head Gasket Design Change - New Head Gasket Part Numbers and Head Bolt Torque Specifications (06-06-01-006B)
2008-04-01: Warranty Claims Submission - Importance of GM Part Numbers and Parts with Date Codes (06-00-89-054B)
2008-03-31: Escalation Process for Critical Orders for Electronic Service Center (ESC) Parts (06-00-89-032A)
2008-03-31: Diagnostic Information on MH1, MN8, MT1, M15 Transmission Slips, Will Not Shift or May Overheat, SES/MIL May Be Illuminated, DTCs P0218, P0894 Set (08-07-30-016)
2008-03-27: Diagnostic Information on MN8, MT1 SES/MIL Illuminated, DTC P0757, Harsh Shift, Delayed 2-3 Shift, 2-3 Shift Flare, No Third Gear, Slips in Third Gear or Reverse (08-07-30-015)
2008-03-27: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-25: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories (08-03-10-004)
2008-03-24: Hard Or Harsh 1-2 Shift - keywords 4L60E 4L65E 4L70E automatic bump first noise PQC second shift slip transmission (PIP3170G)
2008-03-20: DIagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008A)
2008-03-19: Unable To Connect To OnStar Or Use OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication failedtovoice information intermittent OPC operation no noconnect performance (PIC4310B)
2008-03-14: Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002A)
2008-03-12: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation (08-08-51-002)
2008-03-11: Intermittent No Connect Gen6 Gen7 Or Gen8 (PIC4551B)
2008-03-11: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006D)
2008-03-07: Shudder or Slip in Reverse Under Hard Acceleration- keywords chatter (PIP4022C)
2008-03-05: Unable To Receive Incoming OnStar Or HFC (Hands Free Calling) Calls - keywords blue button call cellular communication data digital incoming noconnect operation program tech2 UE1 vs3bgen6 vs3bgen7 (PIC4393G)
2008-03-04: Information OnStar Vehicles Unable To Receive Turn By Turn Directions - keywords calibration GPS navigation location radio route voice (PIC4801)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-27: Diagnostic Information for Inoperative Remote Vehicle Start (08-08-52-002)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-26: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008)
2008-02-25: General Motors Position Statement on Installation of Used, Salvaged or Imitation Air Bag System Components (08-09-41-003)
2008-02-22: Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow (02-07-30-052E)
2008-02-19: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-006)
2008-02-15: Battery Part Restriction - keywords cable cell corrosion crank hard inoperative leak low no replace start (PIT4380B)
2008-02-11: Eaton Locking Differential Chatter Shudder Noise On Turns - keywords bind grab grind (PIP4054A)
2008-02-11: Possible Engine Oil Leak Due To PCV Freeze-Up - keywords 4.8 5.3 6.0 6.2 air ambient body cold dip dipstick fill freezing intake inlet L33 L59 L76 L92 LH6 LC9 LM7 LMF LMG LQ4 LQ9 LR4 LY2 LY5 LY6 start (PIP3343A)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-06: GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078B)
2008-02-05: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
2008-02-05: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience (04-06-01-029B)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-02-04: Driveline Characteristics for All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems (01-04-18-001F)
2008-02-04: Info on Close-Coupled Converter, Engine Breakdown or Non-Function Due to Severe Overheat/Lack of Oil Causing Pistons, Rods, Crankshaft, Cylinders/Heads, Camshaft, Intake/Exhaust Valves, Bearing Damage (06-06-01-010A)
2008-02-01: Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
2008-02-01: Distortion in Outer Surface of Vehicle Glass (00-08-48-005C)
2008-02-01: Information on Eliminating Noise in Audio System When Using Portable Playback Device (06-08-44-015A)
2008-01-31: 4L60-E, 4L65-E, 4L70-E HYDRA-MATIC Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change (08-07-30-004)
2008-01-31: Vibration Analysis Worksheet (03-00-91-001D)
2008-01-30: Remote Keyless Entry Operational Characteristics (99-08-52-005C)
2008-01-25: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006B)
2008-01-25: Information on New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
2008-01-23: 18 Digit Snapshot/Charge Summary Code No Longer Required for A/C Refrigerant System repairs Submitted for Warranty Reimbursement (05-01-38-008B)
2008-01-18: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2008-01-17: Engineering Information (EI) Process (04-00-89-053B)
2008-01-17: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-003)
2008-01-17: Re-establishing Communications with OnStar Center After Battery Disconnect (00-08-46-004C)
2008-01-17: Tire Slowly Goes Flat and/or Excessive Wheel Vibration Caused by Bead Splits (Replace Wheels with New Heavy Duty Rim Version) (03-03-10-001D)
2008-01-17: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007D)
2008-01-16: 4L80E, MT1 and 4L85E, MN8 Simplified Valve Body Reconditioning Instructions, DTC P0741, P0742, P0751, P0752, P0756, P0757, P0894, Harsh or Delayed Shifts, Slips, No Drive, No Reverse (08-07-30-001)
2008-01-15: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003C)
2008-01-15: GM Technical Assistance Information Form (TAC) and Service Strategy Process Utilizing Customer Service Comeback Prevention, Strategy Based Diagnostics (SBD) and Intermittent Concern Diagnosis (01-00-89-011g)
2008-01-10: Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029D)
2008-01-10: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber (08-06-04-003)
2008-01-09: Information on Verifying OnStar System Function During Pre-Delivery Inspection (PDI) (06-08-46-006A)
2008-01-09: Availability of GM OnStar Vehicle Diagnostics and GM Goodwrench Remote Diagnostic Services (06-08-46-002B)
2008-01-09: Seat Belt Extender Availability (99-09-40-005E)
2008-01-09: Information on Tire Radial Force Variation (RFV) (00-03-10-006C)
2008-01-09: OnStar Labor Operation Codes (05-08-46-005B)
2008-01-08: Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems (02-08-44-007C)
2008-01-08: OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System (05-08-46-004B)
2008-01-08: Cataloging of Electronic Service Center Parts (06-00-89-016A)
2008-01-08: Incorrect OnStar Global Positioning System (GPS) Location Reported During OnStar Call (02-08-46-006C)
2008-01-07: Stabilitrak Disable Switch Is Inoperative - keywords ABS control off TCS traction (PIT3589B)
2008-01-07: Tire Puncture Repair Procedures for All Cars and Light Duty Trucks (04-03-10-001D)
2008-01-04: Information on The Use of Bonded Valve Body Spacer Plate and Gaskets - keywords part shift (PIP4309)
2008-01-03: Use of Nitrogen Gas in Tires (05-03-10-020A)
2008-01-03: Steering Wheel Shake and/or Tire Wear (Inspect Steering Linkage) (07-02-34-001A)
2007-12-19: Continuous OnStar Progression Tones AFTER Call End Attempt Is Made - keywords blue button DTC emerging flashes inoperative issue led mute no noconnect OnStar progression radio red tones (PIC4500A)
2007-12-17: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-062)
2007-12-17: Warranty Parts Center/Corporate Parts Return Program (99-00-89-019E)
2007-12-10: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT - CH-47976) (03-06-04-030F)
2007-12-06: Chrome Wheel And Trim Corrosion - keywords body door molding tire warranty (PIT4548)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-28: Coolant Leak from Auxiliary Heater - Fuel Operated (FOH) (Replace Hose Clamps) (07-01-37-003)
2007-11-21: Release of DEXRON-VI Automatic Transmission Fluid (ATF) (04-07-30-037D)
2007-11-19: Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029C)
2007-11-19: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes (02-08-46-007C)
2007-11-14: Whine Noise In First And Second Gear - keywords acceleration case clash filter fluid oil (PIP3259H)
2007-11-13: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-056)
2007-11-13: GM Training: 2008 Service Training Standards (STS) Updates (U.S. Dealers) (07-00-89-055)
2007-11-12: Customer Concern Not Duplicated/Verified Labor Operations (06-00-89-026A)
2007-11-09: Underbody Corrosion - keywords appearance body frame rust (PIT3749B)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-11-02: Corrosion Protection for Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008D)
2007-10-31: Seat Belt Latch Stop Button Available for Service (07-09-40-002)
2007-10-29: Revised General Motors New Vehicle Tire Warranty Program (00-03-10-003M)
2007-10-23: Information on Proper Tire Pressure (00-00-90-002I)
2007-10-22: 2006-2007 G Van Surge At 51 To 64 MPH - keywords 6.6 4L85E accel accelerate cal calibrate calibration chuggle ECM engine hesitate LLY MN8 PCM stumble throttle update (PIP4252)
2007-10-22: Slip Condition In 2nd 3rd Or 4th - Damaged 2-4 Band Or 3-4 Clutch - keywords 4L60E 4L65E 4L70E automatic bind body busy chatter fourth second shift shudder third valve (PIP3136L)
2007-10-15: GM Training:I-CAR Offers Various Resources to Help Dealers Achieve Training Goals (U.S. Dealers) (07-00-89-051)
2007-10-15: GM Training:October 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-052)
2007-10-11: Shudder Or Slip In Reverse Under Hard Acceleration - keywords chatter (PIP4022B)
2007-10-10: No Movement When The Shift Lever Is Moved To D4 Or D3 Normal Operation When Moved To D2 D1 Or Reverse - keywords drive first inoperative second sprag overdrive (PIP3931H)
2007-10-08: GEN III Or GEN IV V-8 Engine Misfire - keywords P0300 arm cam camshaft lifter wear worn engine L33 L59 L76 LC9 LH6 LM7 LMG LR4 LS2 LQ4 LQ9 LY5 LY6 misfire miss rocker roller rough valve (PIP4138B)
2007-10-05: Disabled Onstar System Identification (PIC3597D)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-09-28: Special Coverage Adjustmen t- Engine Compartment Fuse Block Cover (07095)
2007-09-28: Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs. Non Overpower Engine Non-Function of Pistons, Cylinders (06-06-01-007A)
2007-09-28: Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool (05-06-01-010B)
2007-09-27: Information on 4L60-E M30 Rear Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0756, P0894, Harsh 1-2 Shift (07-07-30-024)
2007-09-21: Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires (03-03-10-007C)
2007-09-20: Damaged Turbo Chargers When Returned To The WPC - keywords 6.6 6.6l diesel engine LBZ leak LLY LMM noise oil P003A P0234 P2563 P2564 P2565 return turbocharger (PIP3224A)
2007-09-18: Slip Condition In 2nd 3rd Or 4th - Damaged 2-4 Band Or 3-4 Clutch - keywords 4L60E 4L65E automatic bind body busy chatter fourth second shift shudder third valve (PIP3136K)
2007-09-18: OnStar Gen 6 With A Current DTC U1500 - keywords blue button call cellular communication data digital DTC LED information noconnect onstar operation program PIC3718 PIC3718A tech2 UE1 U1500 vs3bgen6 (PIC3718D)
2007-09-17: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016A)
2007-09-14: GM Training: FINAL REMINDER - Hybrid Two-Mode Training Information (U.S. Dealers) (07-00-89-046)
2007-09-14: GM Training: September 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-045)
2007-09-05: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
2007-08-29: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords B1000 blue button communication DTC information message no noconnect OnStar operation (PIC4600)
2007-08-27: Radio with Six Disc CD Changer Does Not Recognize Loaded CD/Displays An INITIALIZING Message, CD Will Not Play, CD Cannot Be Ejected or Disc Icon Does Not Illuminate (Reprogram Radio) (07-08-44-017)
2007-08-23: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors (07-00-89-043)
2007-08-17: GM Training:GM Service Technical College (STC) Northeast Regional Training Center Relocation (U.S. Dealers) (07-00-89-042)
2007-08-17: GM Training: Enhancement to Componentized Placement Assessments (U.S. Dealers) (07-00-89-041)
2007-08-17: GM Training:Hybrid Two-Mode Training Information (U.S. Dealers) (07-00-89-040)
2007-08-17: GM Training:August 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-039)
2007-08-16: Warranty Admin. - Courtesy Transportation and Roadside Assistance Programs (07-00-89-037)
2007-08-14: Gen III Or Gen IV V-8 Engine Misfire - keywords P0300 arm cam camshaft lifter wear worn engine L33 L59 L76 LC9 LH6 LM7 LMG LR4 LS2 LQ4 LQ9 LY5 LY6 misfire miss rocker roller rough valve (PIP4138A)
2007-08-14: Information on Internal Engine Noise or Damage After Oil Filter Replacement (07-06-01-016)
2007-08-09: Battery Part Restriction - keywords cable cell corrosion crank hard inoperative leak low no replace start (PIT4380A)
2007-08-07: Steering Wheel Shake and/or Tire Wear (Inspect the Idler Arm and/or Pitman Arm) (07-02-34-001)
2007-08-06: Guidelines for Usage of Transmission K Labor Operation Recondition Add Time (07-07-30-020)
2007-08-02: Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
2007-08-02: Warranty Admin. - GM Dealer Empowerment Program and Goodwill Procedures (05-00-89-055B)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-07-26: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022D)
2007-07-25: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-033)
2007-07-24: Diagnostic Information for Noise in Steering and Inspection of Idler Arm Bracket (05-03-08-019B)
2007-07-23: Rear Leaf Spring Slap or Clunk Noise (Replace Spring Inserts) (03-03-09-002B)
2007-07-23: Warranty Administration - Required Operating Procedures (04-00-89-015A)
2007-07-20: XM - Factory Kit RadioCompatibility - keywords DRR kit radio U1C UM7 UMS XM radio (PIC4575)
2007-07-20: Intermittent Current Or History DTC B2476 In OnStar Gen 5 6 or 7 VCIM - keywords B2476 blue button call communication data digital information keypad led onstar OPC red (PIC4574)
2007-07-19: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) (06-08-50-009B)
2007-07-19: Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
2007-07-13: Front Or Rear Axle Vent Hose Fluid Leak- keywords differential repeat (PIP3454D)
2007-06-29: OnStar Handsfree Calling (OHFC) Inoperative And OnStar Blue Button Keypress Is Now Receiving The Demo Message - keywords 05-08-46-006M blue button communication digital disabled message no OnStar OPC (PIC4564)
2007-06-29: Intermittent no connect Gen 6 or Gen 7 (PIC4551)
2007-06-29: Language Change for OnStar System (U.S. and Canada Only) (05-08-46-009B)
2007-06-27: ABS Light On DTC C0055 C0235 C0236 Or C0237 Stored In The EBCM - keywords brake lamp light sensor speedometer VSS (PIT3521E)
2007-06-27: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 (07-01-38-004)
2007-06-27: GM Training:May 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-028)
2007-06-26: GM Training:April 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-025)
2007-06-26: GM Training:Service Training Standard (STS) Effective Date for Two Required Technology Close-ups (TCUs) was 04/14/07 (U.S. Dealers) (07-00-89-024)
2007-06-26: GM Training:Number of Technicians Required Reduced for Two Categories (U.S. Dealers) (07-00-89-016)
2007-06-26: GM Training:Three Technology Close-Up IDL Seminars as New 2007 Service Training Standard (STS) Requirements (U.S. Dealers) (07-00-89-014)
2007-06-26: Stabilitrak Disable Message Appears On The DIC Or Unwanted Stabilitrak Activation - keywords ABS brake DTC light MIL suspension TCS (PIT3013D)
2007-06-26: GM Training:March 2007 New Course Information (For U.S. Dealers and Aftermarket) (07-00-89-013)
2007-06-26: GM Training:Course Information (For U.S. Dealers and Aftermarket) (07-00-89-011)
2007-06-26: GM Training:January 2007 GM Service Know-How Emerging Issues Seminar (#10207.01D) (For U.S. Dealers Only) (07-00-89-007)
2007-06-26: GM Training:Maintaining GM STC Master Technician Certification (MTC) (For U.S. Dealers Only) (07-00-89-005)
2007-06-26: GM Training:HVAC Systems and Operation Stage 2 WBT and IDL (11044.03) (For U.S. Dealers Only) (07-01-38-001)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-06-22: Use of Silicone for Weatherstrip Maintenance (99-08-64-016B)
2007-06-21: Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector) (07-06-04-019)
2007-06-21: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage (00-06-01-026B)
2007-06-21: 1998-2007 Cars And Light Duty Trucks TCC Operation - keywords shudder slip surge speed (PIP4001A)
2007-06-20: Sound Deadener Peeling In Wheel Well Area (Clean and Reapply Coating) (07-08-61-002A)
2007-06-19: No OnStar LED - keywords blue button communication digital disabled led information no nopower operation UE1 (PIC3597C)
2007-06-19: Information on Engine Ticking Noise (02-06-01-022G)
2007-06-15: Supplement To Special Coverage Adjustment 07103 - keywords arm attaching bracket crack (PIT4432)
2007-06-14: Communication Strategy of Service Information/Strategy Based Diagnostics (05-00-89-067B)
2007-06-13: Goodwrench Replacement Engines With Rear Main Seal Oil Leak - keywords crank crankshaft engine leak oil main rear replace replacement seal shaft (PIP4155)
2007-06-13: Safety Belt Locking Conditions (Normal Operating Characteristic) (05-09-40-002B)
2007-06-12: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT - CH-47976) (03-06-04-030E)
2007-06-08: Windshield Wiper Performance, Cleaning Instructions and Maintenance (06-08-43-003A)
2007-06-05: GM Performance Parts Engine Warranty Q and A (04-06-01-019A)
2007-06-04: No Movement When The Shift Lever Is Moved To D4 or D3 Normal Operation When Moved to D2 D1 Or Reverse - keywords drive first inoperative second sprag overdrive (PIP3931G)
2007-05-30: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (02-06-03-008C)
2007-05-29: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) (99-01-39-004B)
2007-05-29: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019E)
2007-05-25: Special Coverage Adjustment - Steering Idler Arm Attaching Bracket Fracture (07103)
2007-05-24: Corrosion Protection for Metal Panels with Dealer Installed Accessories Fastened by Drilled Holes (03-00-89-008C)
2007-05-23: Whine Noise In First And Second Gear - keywords acceleration case clash filter fluid oil (PIP3259G)
2007-05-22: Gen III Or Gen IV V-8 Engine Misfire - keywords P0300 arm engine L33 L59 LH6 LM7 LR4 LS2 LQ4 LQ9 lifter misfire miss rocker rough valve (PIP4138)
2007-05-21: Information on 2-3 Upshift or 3-2 Downshift Clunk Noise (01-07-30-042E)
2007-05-09: Interior Cleaning, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - New Product Availability (06-00-89-029B)
2007-05-04: Battery Part Restriction - keywords cable cell corrosion crank hard inoperative leak low no replace start (PIT4380)
2007-05-03: Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software (07-07-30-010)
2007-05-01: 4L60-E/4L65-E/4L70-E Automatic Transmission Product Update (07-07-30-008)
2007-05-01: Various Rear Sliding Door Conditions (Adjustments/Repair Procedures) (07-08-64-010)
2007-04-25: Catalytic Converter Replacement - keywords 4.8 5.3 6.0 6.2 P0420 P0430 converter low L59 L76 L92 LC9 LH6 LMG LM7 LQ4 LQ9 LR4 LY2 LY5 LY6 MIL P0300 P0301 P0302 P0303 P0304 P0305 P0306 P0307 P0308 P0351 (PIP3119F)
2007-04-24: Slip Condition In 2nd 3rd Or 4th - Damaged 2-4 Band Or 3-4 Clutch - keywords 4L60E 4L65E 4L70E automatic bind body busy chatter fourth second shift shudder third valve (PIP3136J)
2007-04-23: Duramax 6.6L Hollow And Solid Pushrod Interchangeability - keywords arm broken diesel hole engine noise lube lubrication push repair rocker rocker arm rod tick tube valve valvetrain (PIP4121)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-18: OnStar Customer Reports (Phantom Phone Calls) Without Attemping A Call - keywords calling calls cellular free hands HFC intermittent mute OPC performance phantomcalls UE1 (PIC3278B)
2007-04-17: Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition) (07-03-10-008)
2007-04-17: Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
2007-04-17: Information on Repair of Polypropylene Energy Absorbers (07-08-63-001)
2007-04-12: Cruise Control / PTO Inop and/or LED Stop Lamps Dimly Lit - keywords brake chms1 engage inoperative light led rear stop tail (PIT3051C)
2007-04-12: Hard or Harsh 1-2 Shift- keywords 4l60e 4l65e 4l70e automatic bump first hard harsh noise pqc second shift slip transmission (PIP3170F)
2007-04-03: Information on Engine Oil Consumption Guidelines (01-06-01-011D)
2007-04-02: Info - Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair (07-08-98-001)
2007-03-30: Turbo Charge Air Cooler Hose Oil Seepage, Or Dislodged On Acceleration - keywords 04 05 06 07 6.6 black boost clamp cool intake LBZ leak LLY low no noise P0299 pipe power smoke surge turbo whistle (PIP3068D)
2007-03-30: Info - PRNDL Display Reduced Visibility for Approximately One Minute (02-08-42-004A)
2007-03-23: Warranty Admin. - Front Seat Cushion Frame Replacement and Front Seat Back Frame Replacement Labor Operations C6060 and C6068 (07-08-50-006)
2007-03-21: Vehicles With Trouble Code P0496 - keywords 4.8 5.3 6.0 DTC evap L18 L33 L59 L76 LC9 LH6 LMG LM7 LY2 LY5 LY6 LQ4 LQ9 LU3 MIL SES tank (PIP4094)
2007-03-16: Information on Paint Stain Under Protective Shipping Film (05-08-51-001B)
2007-03-13: Information on OnStar System - Possible Loss of GPS and/or Unable to Replenish Hands-Free Calling Minutes (02-08-46-007B)
2007-03-09: LBZ LLY Engine with Rough Idle, Poor Performance, Black/White Exhaust Smoke, MIL/SES Light On, DTCs P003A, P060B, P0230, P0403, P0401, P0606, P2146, P2149, P2152, P2155 (Reprogram ECM) (06-06-04-066A)
2007-03-07: Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Idle (Replace A/C Compressor/Power Steering Pump Mounting Bracket or Enlarge Bracket Bolt Holes) (05-06-01-018A)
2007-03-07: LBZ LB7 LLY 6.6L Duramax Diesel Engine Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Start Idle (Replace Accessory Drive Belt) (07-06-01-003)
2007-03-05: Information on Revised Connecting Rod Bolt Torque for Small Block GEN III and GEN IV Vortec V8 Engines (07-06-01-002)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-28: Diesel Engine Extended Idle Smoking - keywords 6.6 black blue excessive fuel injector LBZ LLY smoke soot white (PIP3722A)
2007-02-27: 2006 LBZ LLY Diesel Engine Vibration Felt At All RPM - keywords 6.6L align alignment balance balancer bolt crankshaft duramax harmonic idle LBZ LLY loose pin rate rough (PIP3647A)
2007-02-20: Malfunction Indicator Lamp (MIL) On, Diagnostic Trouble Code (DTC) P0894, Harsh 1-2 Shift with 4L60-E, 4L65-E, 4L70-E Auto Transmission (Test/Replace TCC Enable Solenoid/Harness, Auto Trans Wiring) (06-07-30-007A)
2007-02-20: Information on Diesel Fuel Additives (03-06-04-017D)
2007-02-19: Eaton Locking Differential Chatter Shudder Noise On Turns - keywords bind grab grind (PIP4054)
2007-02-16: DRLs Will Not Disable With Headlamp Switch - keywords automatic head lamp (PIT3219B)
2007-02-15: Info - New Bulletin Category: Technical Training (U.S. Only) (07-00-89-003)
2007-02-12: Outside Mirror Glass Shake/Vibration While Driving (Replace Mirror Glass) (03-08-64-031A)
2007-02-01: Transmission Fluid Leaking From The Vent Pipe - keywords hose iss pump seal (PIP4039)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-25: Customer Satisfaction - Passenger-Side Wiper Pattern Change (06140)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-17: Info - Diagnostic Trouble Codes (DTCs) Required on Repair Orders (06-00-89-050A)
2007-01-16: ABS And Traction Off Lights Come On Intermittently DTC U1040 Or U1041 - keywords brake communication EBCM EBTCM indicator intermittent IPC lamp no TCS U1040 U1041 VSES (PIT4080A)
2007-01-16: Shudder Or Slip In Reverse Under Hard Acceleration - keywords chatter (PIP4022A)
2007-01-11: Digital Radio Receiver Rapid Activation Utilization - keywords diagnosis digital DRR exchange information lock module no number part radio receiver reception reman satellite U2K (PIC4374)
2007-01-11: Info - Non-GM Parts and Accessories (Aftermarket) (04-06-04-054A)
2007-01-11: 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L65-E, 4L70-E, 4L80-E, 4L85-E, 5L40-E, 5L50-E, 6L50, 6L80, 6L90 or Allison Trans. (05-07-30-018A)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-05: Headlamp Shakes at Night (Repair Radiator Support) (07-08-42-001)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2007-01-03: Info - Grinding and/or Growling Noise in Park on Incline (99-07-30-030E)
2006-12-28: Intermittent Red LED DTC B2470 And Possible Unable To Contact OnStar Center - keywords analog blue button connect digital DTC information led no opc operation performance PIC3341 PIC3341A PIC3341B UE1 (PIC3341C)
2006-12-19: Loaded Disc Not Recognized / Able To Play or Eject Disc - keywords cd changer display program radio stick stuck (PIT4221)
2006-12-19: Cold Start Belt Chirp - keywords AC A/C accessory air bracket compressor conditioning diesel drive engine idle LBZ LLY mounting noise PIP3138B PIP3965 PIP3965A power pump rattle squeal squeak steering (PIP3965A)
2006-12-15: Rust Found In The Injector Inlet Filter Screen During Injector Repairs - keywords 4.8 5.3 6.0 contaminated contamination DTC engine fuel gas L33 LH6 line L59 LM7 LQ4 LQ9 LR4 misfire miss P0300 SES (PIP3280C)
2006-12-13: Diesel Engine Hard Start Temperatures Below Freezing - keywords additive cold filter freeze fuel gel gelling LBZ LB7 LLY no P0087 P0093 P1093 restriction temp temperature vacuum wax waxing (PIP3317E)
2006-12-07: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (02-07-30-001E)
2006-11-30: Warranty Admin. - Brake Rotor/Drum Refinishing Labor Operations (06-05-22-007)
2006-11-29: OnStar Vehicles - Voice Recognition Inoperative - keywords analog celleular communication digital intermittent UE1 vs3bcu vs3bgen2 vs3bgen3 vs3bgen4 vs3bgen5 vs3bgen6 vs3bgen7 (PIC3011D)
2006-11-28: LB7/LBZ/LLY/LMM - Intermittent Driveability Conditions-No Crank, Crank No Start, Hard to Start, MIL/SES, HEsitation, Lack of Power, Surge, Misfire, Fuel Knock, IPC Indicates No Oil Pressure, DTCs Set (04-06-04-001C)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-11-27: No Start With DTC P1626 Or P1631 - keywords crank deterrent no nostart stall theft theftdeterrent (PIT4001A)
2006-11-20: Side Cargo Door is Hard to Open (Install New Hinge Pins) (06-08-64-032A)
2006-11-09: Crank No Start When Cold Due To Compression Loss - keywords cylinder cylinderhead extended hard head lifter loss (PIP3146B)
2006-11-09: Radio And Instrument Panel Cluster Parts Restrictions - keywords CD cluster instrument information panel part radio (PIT4068A)
2006-11-09: Tire And Wheel Alignment - keywords left pull right steering suspension tie rod turn wheel (PIT4133A)
2006-11-03: Remote Verification with RKE Is Inoperative - keywords BCM chirp door entry flash fob horn key keyless light lock open (PIT3642A)
2006-11-01: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System (01-07-31-002B)
2006-10-31: SES Light And Reduced Engine Power DTC P0120 P0220 P1516 P2135 - keywords accelerator actuator APP blade body connector connection DTC L33 L59 LH6 LR4 LM7 LS1 LS2 LQ4 LQ9 module position reduce sensor (PIP3089B)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-27: Windshield Wiper Arm Loose and Making Noise, Wiper Flops Across Windshield, Inconsistent Wiper Operation (Replace Wiper Pivot Screws) (06-08-43-006)
2006-10-26: Throttle Actuator Control Module Codes P2108 P1516 And U0107 - keywords 4.8 5.3 6.0 accel accelerate (PIP3812D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-24: Warranty Admin. - Revised Mass Air Flow Core Return Requirements (06-06-04-057)
2006-10-19: OnStar Generation 5 or 6 (Digital) System Inoperative/Has No Power, LED Light Not On (Remove/Reinstall OnStar Fuse and Replace VCIM or Follow SI Diagnostics) (05-08-46-001C)
2006-10-19: Navigation Radio Displays No GPS Signal - keywords onstar UE1 (PIT4118B)
2006-10-17: Information on Servicing Fuel Injectors to Avoid Contamination (03-06-04-036A)
2006-10-17: Hydro-Boost Unit/Power Brake Booster Appears To Be Leaking (Refer to Power Brake Booster Leak Inspection in SI) (06-05-22-006)
2006-10-13: Odometer And PRNDL Light Up With Key Out Of The Ignition And Door Open - keywords cluster DIC display indicator IPC (PIT3238A)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-10-10: Info - Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009B)
2006-10-09: Info - Metal Panel Bonding (02-08-98-001C)
2006-10-03: Info - Eliminating Unwanted Odors in Vehicles (00-00-89-027D)
2006-09-28: Service VME - Additional Information About Passenger Presence Systems (PPS) - keywords bladder information passenger PPS presence restraint seat sensor SIR system weight (PIT4138)
2006-09-28: Info - Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009A)
2006-09-26: P0300 Cylinder 7 Misfire Due To Fuel System Contamination - keywords CEL contaminated DTC engine gas L59 L76 L92 LC9 LMG LR4 LM7 LY2 LY5 LY6 LQ4 LQ9 miss P0302 P0307 P0308 SES tank water (PIP3055A)
2006-09-25: LR4, LY2, L33, LH6, LM7, L59, LC9, LMG, LY5, LS2, LQ9, LQ4, L76, LY6 Throttle Actuator Control (TAC) Module Codes, MIL/SES DTCs P2108 P1516, U0107, Reduced Engine Power (Reprogram PCM) (06-06-04-042A)
2006-09-23: Diesel Oil Leak At Right Rear Of Engine - keywords banjo bolt dye feed fitting hose LBZ LLY pipe top turbo (PIP3230B)
2006-09-22: Info - New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores (03-00-89-006D)
2006-09-22: Info - Pitting and Brake Dust on Chrome Wheels (04-03-10-012A)
2006-09-14: The Sliding Door is Hard to Open or Will Not Open - keywords adjust bind contact latch linkage lock rod side (PIT3487C)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Information on Engine Misfire MIL/SES Light Illuminated or Flashing DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, P0420 or P0430 (06-06-04-046)
2006-09-12: Info - Distortion in Outer Surface of Vehicle Glass (00-08-48-005B)
2006-09-12: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
2006-09-08: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (06-08-111-004)
2006-09-07: Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010)
2006-08-22: Installing Trailer Wiring Harness without the Z82 Option - keywords accessory brake bulb connector electrical hazard lamp light signal wire (PIT3815A)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-18: Harness Location For Trailer Brake Installation RPO Z82 and/or UY7 - keywords connector electrical hitch wire (PIT3514C)
2006-08-17: 4T65E Whine Noise Park/Neutral - keywords bearing drive sprocket support (PIP3894)
2006-08-16: Loss of Ignition 1 Voltage to the Ignition Coils - keywords 4.8 5.3 6.0 connector crank LR4 LM7 LQ4 LQ9 misfire nostart P0300 P0301 P0302 P0303 P0304 P0305 P0306 P0307 P0308 rough spark stall start (PIP3893)
2006-08-15: Engine Coolant Recycling and Warranty Information (00-06-02-006D)
2006-08-14: Loss of Power Hesitates on Acceleration - keywords 2.8 3.5 4.2 4.3 4.8 4L60E 4L65E 5.3 5.7 6.0 accelerate cold L35LK5 LL8 LM7 loss LQ4 LQ9 LS1 LS6 LU3 M30 M32 miss misfire neutral no performance power (PIP3796A)
2006-08-11: TCC Engagement in 1st, 2nd or Reverse - keywords chuggle shudder (PIP3885)
2006-08-11: 4L60E/4L65E/4L70E Snap Noise 2-1 Downshift - keywords clunk (PIP3106B)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-08-07: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
2006-08-04: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
2006-08-01: Highway Speed Excessive Smoke and Fuel Knock - keywords 6.6 additive balance black contamination cylinder injector LBZ LLY lubrication misfire noise pump white (PIP3491C)
2006-08-01: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels (00-03-10-002D)
2006-07-25: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
2006-07-21: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD (06-00-89-036)
2006-07-21: AM Radio Noise or Poor Reception Induced by Accessories Plugged Into Auxiliary Power Outlet (Install Noise Suppression Filter) (06-08-44-024)
2006-07-21: Machining Appearance At Solenoid Retaining Clip Area - keywords body valve (PIP3867)
2006-07-18: 4L60-E, 4L65-E Automatic Transmission Fluid Leak from Oil Pump or Bell Housing Area (Remove Burrs on Torque Converter Hub, Pump Drive Slots, Replace Torque Converter Hub-to-Oil Pump Seal Assem. (243)) (06-07-30-016)
2006-07-17: Drive Belt Chrip When the Engine is Shut Off - keywords 6.6 accessory alternator engine generator LBZ LLY noise off pulley squeak wear (PIP3772B)
2006-07-14: Clunking Noise in Front End On Turns (Reposition Idler Arm and Power Steering Gear Box) (06-02-34-001)
2006-07-11: Harsh Shift After Cold Start - keywords DTC MIL P1810 (PIP3857)
2006-07-10: Duramax Diesel ECM Programming - keywords 6.6L calibrate calibration control engine error flash LBZ LLY module PCM program reflash replace replacement (PIP3854)
2006-06-28: Diesel Engines with Wait to Start DTC P0381 - keywords glow glowplug indicator plug (PIP3603A)
2006-06-27: Product Safety - Safety Belt Buckle Inoperative (05113B)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Engine and Automatic Transmission/Transaxle Identification (06-00-89-031)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-08: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002D)
2006-06-07: Automatic Transmission Pump Usage, TCC Stuck on After Pump Replacement - keywords body plug pump seal (PIP3831)
2006-05-30: GM Product Recall Campaign Follow Up Post Card (06-00-89-019A)
2006-05-25: Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
2006-05-17: Info - Instructions to be Followed to Aid in Obtaining Root cause Analysis on Both OEM and Goodwrench Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
2006-05-16: Antilock Brake (ABS) Activation at Low Speeds (Clean Wheel Speed Sensor Mounting Surface) (03-05-25-007C)
2006-05-15: Locations of E85 Refueling Stations and Expanded E85 Information (06-06-04-030)
2006-05-11: Customer Satisfaction-Water in Fuel Light Inoperative-Reprogram Engine Control Module (ECM) (06529)
2006-05-02: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-05-01: 4L60E/4L65E Extension Seal Leak 2WD - keywords automatic extension housing leak rear seal slip transmission (PIP3309C)
2006-04-27: LBZ, LB7, LLY, Service Engine Soon (SES) Light Illuminated, DTC P0116, P0181 Set with Engine Coolant Heater Usage in Ambient Temps Above -18 Degrees C (0 Degrees F) (Replace Engine Coolant Heater Cord (06-06-04-027)
2006-04-26: Diagnostic Information on Turbocharger Malfunction Due to Lack of Engine Oil for LBZ, LB7, LLY Duramax Diesel Engine (03-06-93-001C)
2006-04-25: Info - Idler Arm Lubrication - Limited Access to Grease Fitting (06-00-90-002)
2006-04-19: Intermittent Neutral from a Stop or 2-3 Shift - keywords 4L60E 4L65E flare launch slip (PIP3002D)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-19: Info on Close-Coupled Converter, Engine Breakdown or Non-Function Due to Severe Overheat or Lack of Oil Causing Piston, Rod, Crankshaft, Cylinder, Head, Camshaft, Intake/Exhaust Valve, Bearing Damage (06-06-01-010)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-06: Discontinuation of the Field Product Reminder Bulletin/Bulletin Subscription Information (06-00-89-018)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-04-04: Identifying Duramax Diesel LB7/LLY/LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs. Non Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Components (06-06-01-007)
2006-04-03: Duramax Diesel with Intake Air Heater DTC P0540 - keywords 6.6 calibration circuit GPCM heat IAH LBZ LLY module P0540 program programming SES SPS start wait (PIP3776)
2006-04-03: Door Latch Freezing in Cold Temperatures (Apply Super Lube) (05-08-64-002B)
2006-03-30: Drive Belt Chirp When the Engine is Shut Off - keywords 6.6 accessory alternator engine generator LBZ LLY noise off pulley squeak wear (PIP3772)
2006-03-29: Info - Vibration Analysis Worksheet (03-00-91-001C)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-28: Diesel Engine Glow Plug Trouble Codes - keywords calibration circuit glowplug GPCM hard indicator LBZ LLY module multiple P064C P0671 P0672 P0673 P0674 P0675 P0676 P0677 P0678 program programming SES (PIP3586C)
2006-03-24: FMVSS Noncompliance-Tire and Loading Information Label Incorrect (05109)
2006-03-24: Product Emission-Engine Glow Plug System Concern-Reprogram Glow Plug Control Module (06522)
2006-03-24: Stalling SES or Noise Caused by Distributor Gear Wear - keywords cam camshaft DTC HVS knock LU3 misfire miss noise P0300 P0341 rough stall surge whine (PIP3767)
2006-03-21: Information on Change Engine Oil Light Reset Procedure to Avoid Light Remaining Illuminated After Oil Change (06-00-90-001)
2006-03-21: Replacement Two Piece Propshaft Information - keywords bearing broken drive driveshaft prop propeller shaft spline stuck (PIP3528B)
2006-03-16: Remote Start System May Induce O2 Sensor Heater Codes - keywords 4.8 5.3 6.0 aftermarket circuit cold DTC fob heat intermittent key L59 LM4 LM7 LR4 LQ4 LQ9 MIL performance P0053 P0054 P0059 P0060 (PIP3733A)
2006-03-07: Intermittent No Crank, No Start (Clean Battery Side Terminal Stripped Threads, Replace Battery Cable Bolt) (02-06-04-015A)
2006-03-01: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
2006-02-24: Information on P245/75R16 Goodyear Wrangler ST Tire Usage/Identification (06-03-10-003)
2006-02-24: Service VME - Underbody Corrosion - keywords appearance body frame rust (PIT3749A)
2006-02-24: Questions Regarding Installation of Dealer Installed Accessories - keywords 2.8 3.5 4.2 4.8 5.3 6.0 8.1 accessory part Partech (PIT3099C)
2006-02-17: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance (06-08-45-001)
2006-02-14: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004b)
2006-02-14: Info - Diagnostic Tips For Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start (01-07-30-036F)
2006-02-10: Additional Diagnostic Information DTC P0757 - keywords 2-3 4L80E 4L85E clutch fluid flare MN8 MT1 reverse shift slip third valve (PIP3427A)
2006-02-09: Diagnostic Information for Front Wheel Drive Transaxle/Transmission Final Drive and/or Front Hub Bearing Hum and/or Grind Noise (06-07-30-006)
2006-02-03: Stabiltrak Disable Switch is Inoperative - keywords ABS control off TCS Traction (PIT3589A)
2006-01-30: Info - Elimination of Fuel Filler Tube Flapper Door (06-06-04-006)
2006-01-30: SMU - Revised Disc Brake Fastener Tightening Specifications (06-05-23-001)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-24: Info - Expediting Warranty Parts (99-00-89-021E)
2006-01-20: Information on Longer Main Bearing Cap Bolts Required on Certain 2001-2006 LB7, LLY, LBZ Duramax Diesel Engines (06-06-01-003)
2006-01-09: Info - Corrosion of Radiator/Heater Hose Clamps - Release of New Clamp (06-06-02-001)
2006-01-05: Ignition Key and/or Ignition Lock Cylinder Does Not Turn (Replace Ignition Key) (06-02-35-001)
2006-01-04: Info - Maintenance Cleaning of Fuel Injectors (04-06-04-051B)
2005-12-22: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
2005-12-14: O2 Sensor Missing or Extra O2 Sensor Hole - Keywords exhaust leak plug (PIP3653)
2005-12-12: Engine Overheating No Coolant Flow - keywords cool hot leak overheat recovery temp temperature water pump waterpump (PIP3650)
2005-12-09: Info - Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems (02-08-44-007B)
2005-11-23: Info - Elimination of Front License Plate Bracket (Canada Only) (05-00-89-082)
2005-11-21: Info - Paint-less Dent Repair Process (99-08-51-001A)
2005-11-17: Info - Vehicles Without Engine Oil Life System (05-00-90-009)
2005-11-16: Product Safety - Power Steering Hose Fracture (05086A)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-11-11: Product Emission Recall - Incorrect OBD Calibration-Reprogram PCM (05564)
2005-11-04: Light Duty Truck, Van, Utility Rear Axle Lubrication Service Interval - keywords differential fluid housing label oil (PIP3001A)
2005-11-02: Info - Use of Correct Installation Procedure for Loose Hubcap Assembly (03-03-10-002B)
2005-10-27: Radio Displays XM Error or DTC U1137 - keywords communication digital loss nocomm operation performance tech2 U2K (PIC3303A)
2005-10-21: Information on New Essential Tool EN-47909 Injector Bore Cleaning Kit for 6.6L Duramax Diesel Engine (RPOs LB7, LBZ, LLY) (05-06-04-067)
2005-10-18: 4L60-E/4l65-E Automatic Transmission Diagnostic Information on Harsh 1-2 Upshift (01-07-30-030B)
2005-10-12: Turbine Shaft Usage with/without Input Speed Sensor - keywords ISS reluctor teeth 4L60E 4L65E 4L70E (PIP3583)
2005-10-06: Info - Transmission Fluid Leak Diagnosis (01-07-30-041B)
2005-10-04: New Vehicle Pre-Delivery Inspection - Perceived Fuel Economy and Driver Information Center Center/Saab Information Display (DIC/SID) Settings (03-00-89-021A)
2005-10-04: Revised Essential Tool J-35944-200-A Adapter For 9.525mm (0.375 in.) Automatic Transmission Oil Cooler Lines (05-07-30-009A)
2005-09-28: Diesel Engine ECM Programming - keywords 6.6 6.6L calibration DTC indicator LLY module program SES SPS start (PIP3566)
2005-09-23: Powertrain Control Module (PCM), Engine Control Module (ECM), Transmission Control Module (ECM), Transmission Control Module (TCM) DTCs P0601/P0602/P0603/P0604,/P1621 Shared in Multiple Modules (05-06-04-060)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-08-18: Info - Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
2005-08-17: Info - Release of GM Tool Organizaiton DVD Version 8.0 (J-43921-G) (05-00-89-056)
2005-08-10: Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inop I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
2005-08-05: Info - SPAC Case Escalation Process (05-00-89-050)
2005-08-02: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case (05-04-21-004)
2005-07-29: Information on a Revised Fuel Filter for 6.6L LLY and LB7 Duramax Diesel Engine (04-06-04-070A)
2005-07-27: Warranty Admin. - Changes to Paint Claim Submission Process - Paint Mix time Must Be Entered On Each Line (03-08-51-002A)
2005-07-21: Hydro-Boost Brake Pedal Moves or Self Applies at Full Turns - keywords booster hydroboost press steering turn wheel (PIT3665)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-27: Warranty Admin. - Out-Of-Warranty Parts for Engineering Analysis (05-00-89-037)
2005-06-08: Info - On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
2005-06-03: Goodwrench Powertrain Wholesale Program (U.S. Only) (05-06-01-017)
2005-05-17: Information on Higher Than Expected Oil Consumption (02-06-01-027A)
2005-04-26: Info - XM Radio Labor Operation Codes (03-08-44-001A)